TL* THE CONTACT OWNS A 1994 CHEVROLET CAPRICE. WHILE DRIVING 55 MPH, THE ENTIRE FRONT END OF THE VEHICLE SHOOK AND THE CONTACT LOST CONTROL. THE FAILURE OCCURRED WITHOUT WARNING. THE CONTACT CONTINUED TO DRIVE SLOWLY. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT …
Read full complaint
TL* THE CONTACT OWNS A 1994 CHEVROLET CAPRICE. WHILE DRIVING 55 MPH, THE ENTIRE FRONT END OF THE VEHICLE SHOOK AND THE CONTACT LOST CONTROL. THE FAILURE OCCURRED WITHOUT WARNING. THE CONTACT CONTINUED TO DRIVE SLOWLY. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #11055362
Mileage unknown · Dec 2, 1999
Power TrainSeat BeltsService Brakes, Hydraulic
WHILE DRIVING VEHICLE AT 45MPH IT WOULD MAKE HOWLING NOISES IN THE REAR. TOOK VEHICLE TO DEALER & INFORMED BY MECHANIC THE PROBLEM WAS REAREND DIFFERENTIAL. ALSO, BRAKES WOULD PULL TO THE LEFT WHEN APPLIED. CANNOT LOCATE PROBLEM WITH NAKED EYE. TIRES WERE REPLACED & VEHICLE WAS ALIGNED, AND FRONT SEAT BELTS WOULD FAIL TO RETRA…
Read full complaint
WHILE DRIVING VEHICLE AT 45MPH IT WOULD MAKE HOWLING NOISES IN THE REAR. TOOK VEHICLE TO DEALER & INFORMED BY MECHANIC THE PROBLEM WAS REAREND DIFFERENTIAL. ALSO, BRAKES WOULD PULL TO THE LEFT WHEN APPLIED. CANNOT LOCATE PROBLEM WITH NAKED EYE. TIRES WERE REPLACED & VEHICLE WAS ALIGNED, AND FRONT SEAT BELTS WOULD FAIL TO RETRACT OR LOCK. *AK
NHTSA ODI #853602
Mileage unknown · Oct 4, 1999
Suspension
WHILE PULLING INTO THE DRIVER WAY UPPER CONTROL ARM SNAPPED IN HALF. *AK
NHTSA ODI #849811
Mileage unknown · Dec 15, 1997
Engine And Engine CoolingSuspension
LOWER BALL JOINT SNAPPED OFF CONTROL ARM.
NHTSA ODI #526126
Mileage unknown · Jul 9, 1996
Suspension
DUE TO THE SUPENSION FAILURE THE TIRE ON THE VEHICLE IS WEARING OFTEN. ALSO DUE TO A ELECTRICAL SHORT OR SHOCK THE LIGHTS COME ON AND GO OFF WHEN DRIVING.
NHTSA ODI #986635
Mileage unknown · Mar 6, 1996
Suspension
UPON MAKING A RIGHT OR LEFT TURN VEHICLE SHIMMIES. CAUSING VEHICLE TO SURGE. *AK
NHTSA ODI #980282
Mileage unknown · Dec 11, 1995
SuspensionCrashInjury
LOWER REAR AXLE CONTROL BROKE, LOSS OF STEERING CONTROL. TT
THE REAR LOWER CONTROL ARM CAN CRACK AT THE REAR STABILIZER BAR ATTACHMENT.
Consequence & remedy
Consequence: THIS CONDITION CAN BE AGGRAVATED BY THE SEVERE DUTY CYCLE OF THESE VEHICLES AND EVENTUALLY CAUSE THE LOWER CONTROL ARM TO FRACTURE COMPLETELY CAUSING A LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE BOTH REAR LOWER CONTROL ARMS AND REAR STABILIZER BAR ATTACHMENTS.
DEFECTIVE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS WERE NOT PROPERLY TORQUED AND CAN LOOSEN.
Consequence & remedy
Consequence: IF THE LOWER CONTROL ARM BALL JOINT LOOSENS, FATIGUES AND SEPARATES FROM THE FRONT SUSPENSION KNUCKLE, IT COULD CAUSE LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS FOR PROPER TORQUE. IF THE BALL JOINT HAS LOOSENED FROM THE KNUCKLE, BOTH THE BALL JOINT AND THE KNUCKLE WILL BE REPLACED.
THESE VEHICLES FAIL TO CONFORM TO FMVSS NO. 124, "ACCELERATOR CONTROL SYSTEMS." AT LOW TEMPERATURES, EXCESSIVE FRICTION CAN OCCUR IN THE ACCELERATOR PEDAL ASSEMBLY.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IN THE EVENT OF A FAILURE OF THE TROTTLE RETURN SPRING, IF THERE IS EXCESSIVE FRICTION IN THE PEDAL ASSEMBLY, THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR PEDAL ASSEMBLY.
THE FUEL TANK ATTACHMENT STRAP FASTENERS WERE NOT PROPERLY TIGHTENED. THE FASTENERS CAN COMPLETELY DETACH, EVENTUALLY ALLOWING THE FUEL TANK TO SAG AND THE BOTTOM OF THE TANK TO STRIKE THE ROADWAY.
Consequence & remedy
Consequence: THIS CAN RESULT IN A FUEL TANK LEAK AND FIRE IF THE LEAKING FUEL IS EXPOSED TO A SOURCE OF IGNITION.
Remedy: DEALERS WILL RETIGHTEN THE FUEL TANK STRAP FASTENERS.
PAINT ON THE WHEEL MOUNTING SURFACES CAN ACT AS A SHIM BETWEEN THE WHEEL AND THE ROTOR/DRUM. AS THE VEHICLE IS DRIVEN, THE WHEEL IMBEDS INTO THE PAINT, LOOSENING THE LUG NUT AND CAUSING A LOSS OF CLAMP LOAD.
Consequence & remedy
Consequence: ONCE CLAMP LOAD IS LOST, ALL TIRE LOADS ARE TAKEN BY THE WHEEL STUDS RESULTING IN A FRACTURE OF THE WHEEL STUDS. THIS COULD CAUSE THE WHEEL TO SEPARATE FROM THE VEHICLE AND COULD RESULT IN A VEHICLES CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL CLEAN THE WHEEL MOUNTING SURFACES FOR ALL FOUR WHEELS. ALSO, THE WHEEL STUDS WILL BE INSPECTED FOR DAMAGE AND WILL BE REPLACED AS NECESSARY.
THE ENGINE OIL COOLER INLET HOSE MAY HAVE BEEN INSTALLED TOO CLOSE TO THE STEERING GEAR CAUSING CHAFING. THE CHAFING CAN EVENTUALLY WEAR THROUGH THE HOSE'S PROTECTIVE SLEEVE RESULTING IN ENGINE OIL LEAKING ONTO THE ENGINE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE OIL LEAK ONTO THE ENGINE CAN RESULT IN AN ENGINE COMPARTMENT FIRE.
Remedy: Not supplied
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA99003 · Coolant Fires
Opened Jan 13, 1999 · Closed Aug 17, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98049 · Coolant Fires
Opened Sep 4, 1998 · Closed Jan 13, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
EA96022 · Steering Wheel Breakage
Opened Sep 24, 1996 · Closed Apr 4, 1997
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE96037 · Sterring Wheel Breakage
Opened May 16, 1996 · Closed Sep 24, 1996
Status: closed (inferred from source dates) · Steering
There is no summary currently available
1994 Chevrolet Caprice Problems, Complaints & Recalls | Skip That Year
Illustration