Illustration1998 CHEVY BLAZER WITH MULTITUDE OF PROBLEMS, WHICH CHEVY DENIES. INCLUDING WIPER FAILURE, BRAKE FAILURE, COMPLETE CORROSION OF ANYTHING TOUCHED BY DEXCOOL, AND ON AND ON. VERY UNSAFE VEHICLE!!!!! *NM
1998 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 1998 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
100–25K
4425–50K
9350–75K
6775–100K
41100–150K
14150K+
269 reports with mileage · 447 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 256 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seats. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
46 crash reports15 fire reports31 injury reports
Fuel System, Gasoline complaints
23 reportsLOTS TO LIST... 1998 CHEVY BLAZER ZR2 FUEL SYSTEM FAILURE CAUSE STILL UNKNOWN, LEVER FOR PASSENGER SIDE SEAT BROKE OFF. NOW STARTING TROUBLES CAUSE STILL UNKNOWN AT THIS TIME. HELP ME. *NM
STRONG GAS SMELL ON AND OFF SINCE AUGUST 2005. LOOKED OVER BY MECHANIC - WAS TOLD I HAVE A INTERNAL GAS LEAK - AND THAT I WAS DRIVING A "FIRE HAZARD". GAS LEAKING IN ENGINE - SMALL CUP IN AREA OF ENGINE - FILLED WITH GASOLINE. *NM
1998 BLAZER FUEL INJECTORS CLOG, ENGINES CUTS OUT, NO RESPONSE, STALLING, BACK FIRES, SHUTS DOWN, THREE TIMES FUEL INJECTORS REPLACED, TOLD "THAT MODEL KNOWN FOR THAT." ARIZONA CAR ON ARIZONA GAS; ALSO DRIVER SIDE SEAT ADJUSTER LATCH BROKE OFF. COST $1500 EACH TIME TO REPLACE INJECTORS, SAME PROBLEM WITH NEW INJECTORS, UNRELIABL…
Read full complaint
1998 BLAZER FUEL INJECTORS CLOG, ENGINES CUTS OUT, NO RESPONSE, STALLING, BACK FIRES, SHUTS DOWN, THREE TIMES FUEL INJECTORS REPLACED, TOLD "THAT MODEL KNOWN FOR THAT." ARIZONA CAR ON ARIZONA GAS; ALSO DRIVER SIDE SEAT ADJUSTER LATCH BROKE OFF. COST $1500 EACH TIME TO REPLACE INJECTORS, SAME PROBLEM WITH NEW INJECTORS, UNRELIABLE VECHILCE, DRIVER IS 76 AND TRAVELS TO SUMMER HOME IN MOUNTAINS, 500 MILE STRETCH, STRANDED ON ROAD, 50 MILES FROM NEAREST TOWN IN 100+ TEMPERATURES
CONSUMER SMELLED FUEL ON THE OUTSIDE OF THE VEHICLE AND ON THE INSIDE OF THE GARAGE. FUEL INJECTION SYSTEM WAS LEAKING FUEL INTO THE WIRING HARNESS AND THE MAIN COMPUTER CHIP. THIS COULD RESULT IN AN ENGINE FIRE. *AK
MY WIFE WAS IN DANGER DRIVING THE TRUCK WHEN SHE BROUGHT IT TO ANOTHER ROUTE (ANOTHER SHOP), WHICH WAS HUTCHENS CHEVROLET. THEY TOLD MY WIFE AND GAVE HER THE PAPER WORK STATING THAT, THE TRUCK WAS UNSAFE AND SHE COULD HAVE BEEN IN DANGER IF CONTINUED DRIVING IT. WHEN HE WAS TOLD OF THE BRAKE PROBLEMS, (THE CAR DEALERSHIP OWNER)…
Read full complaint
MY WIFE WAS IN DANGER DRIVING THE TRUCK WHEN SHE BROUGHT IT TO ANOTHER ROUTE (ANOTHER SHOP), WHICH WAS HUTCHENS CHEVROLET. THEY TOLD MY WIFE AND GAVE HER THE PAPER WORK STATING THAT, THE TRUCK WAS UNSAFE AND SHE COULD HAVE BEEN IN DANGER IF CONTINUED DRIVING IT. WHEN HE WAS TOLD OF THE BRAKE PROBLEMS, (THE CAR DEALERSHIP OWNER) HE INSTRUCTED MY WIFE TO TAKE IT TO HIS OWN AUTO REPAIR SHOP, WHEN MY WIFE GOT THE TRUCK BACK, IT WAS IN THE SAME STATE NOT EVERYTHING WAS FIXED. THE WORK WAS COMPLETED AT HUTCHENS. THE WORK HAD TO HAVE COST ABOUT $378.00. AND THERE ARE MORE TROUBLES WITH THE TRUCK, I SEE SIGNS OF RUST AND CORROSION, THERE ARE VIBRATIONS WHEN THE VEHICLE IS IN EXCESS OF 60 MILES.
TRUCK IMMEDIATELY STALLED WHILE TRAVELING HIGHWAY SPEEDS 65-75 MPH DUE TO THE FUEL PUMP FAILING. THE TRUCK WAS PUT IN THE SHOP TWO TIMES BEFORE A DIAGNOSIS WAS MADE. CONSUMER WAS APPALLED THAT THERE WAS NO WARNING DEVICE TO ACKNOWLEDGE TO THE OWNER THAT FUEL PUMP FAILED.*AK *TS *JB
CONSUMER NOTICED GAS TANK WAS LEAKING AFTER SEEING GASOLINE ON DRIVEWAY. CONSUMER STATES" GAS TANK IS RUSTED AND DEVELOPED A HOLE. DEALER HAS BEEN CONTACTED. *AK
NAR 03-31-2003 *MR CONSUMER EXPERIENCED PROBLEMS WITH WHEEL BEARING, HEATER CONTROL SWITCH, GAS GAUGE, RIGHT DOOR LOCK, BRAKES, AND OIL SENDING HOSES. *CB
THE FUEL INJECTORS LEAKED ONTO THE MAIN WIRING HARNESS INSIDE THE ENGINE. ALL OF THE WIRES MELTED. THREE DIFFERENT MECHANICS CONFIRMED THAT THIS SHOULD NEVER HAVE HAPPENED AND COULD HAVE CAUSED A FIRE. I WAS REFERED TO GENERAL MOTORS. ESTIMATED REPAIRS FOR $1600.00 INCLUDE REPLACEMENT OF THE WIRING HARNESS, FUEL INJECTORS, F…
Read full complaint
THE FUEL INJECTORS LEAKED ONTO THE MAIN WIRING HARNESS INSIDE THE ENGINE. ALL OF THE WIRES MELTED. THREE DIFFERENT MECHANICS CONFIRMED THAT THIS SHOULD NEVER HAVE HAPPENED AND COULD HAVE CAUSED A FIRE. I WAS REFERED TO GENERAL MOTORS. ESTIMATED REPAIRS FOR $1600.00 INCLUDE REPLACEMENT OF THE WIRING HARNESS, FUEL INJECTORS, FUEL REGULATOR KIT, FUEL BODY KIT AND UPPER INTAKE GASKET. GM HAS AGREED TO PAY 50% OF THE BILL. SINCE THE VEHICLE HAS ONLY 42,000 MILES, HAS BEEN MAINTAINED PROPERLY WITH OIL CHANGES AND TUNE UPS, I FEEL THAT GM IS RESPONSIBLE FOR THE TOTAL AMOUNT.*AK
Official recalls
300V220000 · Exterior Lighting
Aug 11, 2000
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE DAYTIME RUNNING LIGHTS BUILT WITH A CANDELA VALUE GREATER THAN 3,000 CANNOT BE MOUNTED HIGHER THAN 864MM ABOVE THE ROAD SURFACE.
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy: DEALERS WILL INSTALL A REVISED WIRING HARNESS THAT CHANGES THE DRL'S FROM HIGH BEAM TO LOW BEAM DRL'S, AND INSTALL NEW LONG-LIFE LOW BEAM BULBS.
98V053000 · Suspension:front:control Arm:lower Arm
Mar 9, 1998
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLE EQUIPPED WITH 4-WHEEL DRIVE OR ALL-WHEEL-DRIVE. ONE OR BOTH OF THE ATTACHING NUTS FOR THE RIGHT-HAND LOWER CONTROL ARM ARE UNDER TORQUED. THIS CAN ALLOW THE ATTACHMENT BOLT TO LOOSEN AND SUBSEQUENT BREAK RESULTING IN SEPARATION OF THE LOWER CONTROL ARM FROM THE FRAME.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL INSPECT AND RETIGHTEN THE RIGHT-HAND LOWER CONTROL ARM NUTS TO THE PROPER TORQUE SPECIFICATION.
97V218000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Nov 24, 1997
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. A FATIGUE FRACTURE OF THE REAR AXLE RIGHT-HAND BRAKE PIPE CAN OCCUR CAUSING A SLOW BRAKE FLUID LEAK RESULTING IN A SOFT BRAKE PEDAL. IF THE BRAKE PIPE BREAKS, THE DRIVER WOULD EXPERIENCE A SUDDEN DROP IN THE BRAKE PEDAL, THE INSTRUMENT PANEL BRAKE LIGHT WOULD ILLUMINATE, AND THERE WOULD BE A LOSS OF REAR BRAKE PERFORMANCE.
Consequence & remedy
Consequence: PARTIAL LOSS OF BRAKING AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE BRAKE PIPE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ02012 · Front Control Arm Ball Joints
Opened Sep 10, 2002 · Closed Mar 7, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Additional source detail variants (7)
Suspension:front:control Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Suspension:front
SEE ATTACHED PAGE.
Suspension
SEE ATTACHED PAGE.