IllustrationIN A EVENT OF AN EMERGENCY STOP ABS BRAKES MALFUNCTION, CAUSING BRAKE PEDAL TO GO THE FLOOR, RESULTING IN EXTENDED STOPPING DISTANCE WHICH COULD RESULT IN A POTENTIAL SAFETY HAZARD. *AK
1994 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 1994 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 26 of 620 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 429 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
96 crash reports7 fire reports36 injury reports
Service Brakes, Hydraulic complaints
429 reportsEA94038; BRAKING SYSTEM MALFUNCTIONED DUE TO A DEFECTIVE EGR VALVE. VEHICLE HAD NO BRAKING ABILITY AT ALL. THIS COULD HAVE RESULTED IN A CRASH. ALSO EGR VALVE CAUSED ENGINE PROBLEMS. COMMON PROBLEM. PLEASE PROVIDE FURTHER INFORMATION AND VIN#. *AK
BRAKE PEDAL FROZE. NO AMOUNT OF PEDAL PRESSURE WOULD STOP THE VEHICLE. INTERMITTENT PROBLEM. *AK
EA94038; ABS BRAKING SYSTEM; WHEN APPLYING THE BRAKES UPON APPROACHING AN INTERSECTION, BRAKE PEDAL WAS STIFF AND WOULD NOT GO DOWN TO THE FLOORBOARD UNTIL THE DRIVER LET OFF BRAKE PEDAL AND APPLIED THE BRAKES AGAIN. THIS HAPPENED ON DRY ROAD CONDITIONS DURING NORMAL BRAKING. THE ABS BRAKE SENSORS WERE REPLACED AT THE DEALERSH…
Read full complaint
EA94038; ABS BRAKING SYSTEM; WHEN APPLYING THE BRAKES UPON APPROACHING AN INTERSECTION, BRAKE PEDAL WAS STIFF AND WOULD NOT GO DOWN TO THE FLOORBOARD UNTIL THE DRIVER LET OFF BRAKE PEDAL AND APPLIED THE BRAKES AGAIN. THIS HAPPENED ON DRY ROAD CONDITIONS DURING NORMAL BRAKING. THE ABS BRAKE SENSORS WERE REPLACED AT THE DEALERSHIP. PLEASE DESCRIBE ANY FURTHER DETAILS. *AK
ANTILOCK BRAKES FAILED CAUSING VEHICLE TO SKID AND HIT ANOTHER VEHICLE AND CAUSED INJURY TO THE DRIVER. NM
WINDSHIELD WIPERS: THE WIPERS FAIL TO WORK AT RANDOM. THE REMEDY FOR THIS SEEMS TO BE A TAP TO THE WIPER MOTOR. BRAKE FAILURE: THE BRAKE ROTOR HAS COMPLETELY SEPARATED FROM HUB ASSEMBLY. THIS OCCURRED WHILE ATTEMPTING TO BRING THE VEHICLE TO A STOP CAUSING THE VEHICLE TO VEER SHARPLY
IN RE: SEAT BELTS: THE INERTIA REELS ON THE FRONT BELTS (BOTH SIDES) OF MY VEHICLE ARE INOPERATIVE 99% OF THE TIME. YANKING THE BELTS ENGAGES THE REELS ONLY OCCASIONALLY. THE ONES IN THE SHOWROOM VEHICLES ENGAGED EVERY TIME. RESEARCH ON THE WEB REVEALS THIS TO BE A COMMON PROBLEM AND THAT CHEVROLET IS CHARGING ALMOST $300 EACH T…
Read full complaint
IN RE: SEAT BELTS: THE INERTIA REELS ON THE FRONT BELTS (BOTH SIDES) OF MY VEHICLE ARE INOPERATIVE 99% OF THE TIME. YANKING THE BELTS ENGAGES THE REELS ONLY OCCASIONALLY. THE ONES IN THE SHOWROOM VEHICLES ENGAGED EVERY TIME. RESEARCH ON THE WEB REVEALS THIS TO BE A COMMON PROBLEM AND THAT CHEVROLET IS CHARGING ALMOST $300 EACH TO REPLACE THE DEFECTIVE UNITS!. INRE: THE ABS BRAKES: I WAS TOWING A BOAT AND HAD TO SLOW, QUICKLY, FOR A YELLOW LIGHT TURNING RED. AS THE ABS ENGAGED I LOST MY BRAKES AND WENT RIGHT THROUGH THE INTERSECTION! THE BRAKES ARE IN GREAT MECHANICAL CONDITION. AGAIN, SEARCHING THE WEB FOR INFORMATION, I AM STEERED TO THE WHEEL SENSOR WIRES IN THE FRONT. THE WORD IS THAT THE WIRES ARE BADLY ROUTED, SUBJECT TO DAMAGE, AND CAUSE LOSS OF BRAKING. THERE ARE NUMEROUS REPORTS ON BULLETIN BOARDS OF COSTLY REPAIRS TO THE WIRES FOLLOWING BRAKING SYSTEM FAILURE! *AK
PEDAL IS HARD TO DEPRESS DUE TO ABS FAILURE. YH
ABS BRAKING SYSTEM FAILURE
ABS ACTIVATES ANY TIME,DRY ROAD,INFORWARD DIRECTION NO REASON,ANY SPEED 20 TO 45 MPH
Official recalls
299V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
94V114000 · Trailer Hitches
Jun 20, 1994
THE TRAILER HITCH ATTACHING BOLTS WERE NOT TIGHTENED TO THE SPECIFIED TORQUE. THIS CAN LEAD TO LOOSENING AND SUBSEQUENT BREAKAGE OF THE FASTENERS.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR WHILE THE TRAILER WAS BEING PULLED, THE HITCH AND TRAILER CAN SEPARATE FROM THE VEHICLE.
Remedy: DEALERS WILL TORQUE ALL EIGHT TRAILER HITCH BOLTS TO THE CORRECT TORQUE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA01019 · Front Seat Recliner Bolt
Opened Dec 28, 2001 · Closed Sep 27, 2002
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
There is no summary currently available
RQ99015 · Front Seat Recliner Bolt Failure
Opened Jul 14, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
No summary supplied.
PE96045 · Alleged Failure Of Rear Leaf Springs
Opened Jul 12, 1996 · Closed Dec 16, 1996
Status: closed (inferred from source dates) · Suspension
BREAKAGE OF A LEAF SPRING MAY ALLOW PARTIAL COLLAPSE OF THE REAR SUSPENSION AND INCREASE THE POTENTIAL FOR LOSS OF VEHICLE CONTROL.
PE95010 · Brake Pedal Separation From Pivot Arm
Opened Feb 15, 1995 · Closed May 26, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
PE94046 · Abs Braking System Fails
Opened Jun 17, 1994 · Closed Oct 31, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available