IllustrationMileage unknown · Nov 16, 2021
Tires
idk
NHTSA ODI #11440683
1991 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 1991 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 222 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 125 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
32 crash reports15 fire reports9 injury reports
What owners actually said
222 reportsidk
NEW SET OF TIRES (4) INSTALLED APROX. 1 MONTH AGO. THE LEFT REAR BLEW OUT THE SIDEWALL. BLOWOUT OCCURRED AT FREEWAY SPEED APROX 70 MPH. DROVE APROX. 1/4 MILE TO GET OFF ROADWAY. OUTSIDE TIRE SIDEWALL SEPARATED AT TREAD 100% AROUND THE RADIUS (TIRES INSTALLED W/RAISED LETTERING TO INSIDE). TIRE: (COOPER) MASTERCRAFT COURSER…
Read full complaint
NEW SET OF TIRES (4) INSTALLED APROX. 1 MONTH AGO. THE LEFT REAR BLEW OUT THE SIDEWALL. BLOWOUT OCCURRED AT FREEWAY SPEED APROX 70 MPH. DROVE APROX. 1/4 MILE TO GET OFF ROADWAY. OUTSIDE TIRE SIDEWALL SEPARATED AT TREAD 100% AROUND THE RADIUS (TIRES INSTALLED W/RAISED LETTERING TO INSIDE). TIRE: (COOPER) MASTERCRAFT COURSER A/T P23575R15. *JB
A FIRE STARTED WHILE THE CONSUMER WAS DRIVING AT 26 MPH. THE DEFROSTING COIL IN THE REAR WINDOW STARTED THE FIRE, PER THE FIRE DEPARTMENT. THE ENTIRE VEHICLE'S REAR WAS DESTROYED. NO INJURIES REPORTED. *AK
I'M THE ORIGINAL OWNER OF A 1991 CHEV. S-10 BLAZER WHOM HAS LIVED AT THE SAME ADDRESS SINCE BEFORE THE PURCHASE OF THE VEHICLE. I HAVE NEVER RECEIVED ANY RECALL INFORMATION ON THIS VEHICLE SINCE THE PURCHASE OF IT. THE PAINT HAS BEEN WASHING OFF OF THE VEHICLE, IT LEAVES THE PRIMER. THE PAINT IS SEPARATING FROM THE PRIMER. I HAV…
Read full complaint
I'M THE ORIGINAL OWNER OF A 1991 CHEV. S-10 BLAZER WHOM HAS LIVED AT THE SAME ADDRESS SINCE BEFORE THE PURCHASE OF THE VEHICLE. I HAVE NEVER RECEIVED ANY RECALL INFORMATION ON THIS VEHICLE SINCE THE PURCHASE OF IT. THE PAINT HAS BEEN WASHING OFF OF THE VEHICLE, IT LEAVES THE PRIMER. THE PAINT IS SEPARATING FROM THE PRIMER. I HAVE BEEN TOLD THERE WAS A RECALL ON THIS YEAR OF VEHICLES BY GM FOR THIS PROBLEM. I WAS NEVER NOTIFIED OF THIS OR ANY RECALL ON IT. WHAT CAN BE DONE ABOUT THIS IF ANY THING? THANK YOU, [XXX] . *AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
ON THE 1991 CHEVROLET S-10 BLAZER THE SPARE TIRE IS STORED IN REAR HATCH ON DRIVERS SIDE AND BLOCKS THE BLIND SPOT ON DRIVER'S SIDE MAKING IT HARD TO SWITCH LANE AND ENTER HIGHWAYS. *AK
CONSUMER HAD TO REPLACE THE FUEL PUMP THREE TIMES, AND THE GAS TANK TWICE. CONSUMER NEVER RECEIVED ANY RECALL. CURRENTLY, SHE WAS TOLD TO REPLACE THE FUEL PUMP LINES AGAIN. *AK
CONSUMER BELIEVED SHE GOT RIPPED OFF AT A GARAGE WHEN SHE GOT HER SPARK PLUG REPLACED. (NAR) *PH *CB
THE WINDSHIELD WIPERS BECOME INOPERABLE AND RESULTED IN POOR VISIBILITY. THE DEALER INDICATED THE THE VEHICLES WIPER WERE NOT RECALLED. *NM
WHILE BRAKING AND WITHOUT WARNING, THE ABS FAILED, WHICH CAUSED THE VEHICLE TO EXPERIENCE EXTENDED STOPPING DISTANCE. THE DEALER WAS NOTIFIED. *AK CONSUMER: MATHEW SCHILLING *SCC *JB
CONSUMER WAS HAVING FUEL INJECTION SYSTEM PROBLEMS. FUEL WAS BEING DUMPED INTO THE ENGINE. CONSUMER HAS TAKEN VEHICLE TO THE DEALER TWICE AND THEY COULD NOT FIX IT. WHEN THIS HAPPENED VEHICLE JERKED AND BLACK SMOKE CAME FROM THE BACK. THEN, VEHICLE WILL NOT RUN. ALSO, CONSUMER WAS EXPERIENCING BRAKING PROBLEMS. BRAKE PEDA…
Read full complaint
CONSUMER WAS HAVING FUEL INJECTION SYSTEM PROBLEMS. FUEL WAS BEING DUMPED INTO THE ENGINE. CONSUMER HAS TAKEN VEHICLE TO THE DEALER TWICE AND THEY COULD NOT FIX IT. WHEN THIS HAPPENED VEHICLE JERKED AND BLACK SMOKE CAME FROM THE BACK. THEN, VEHICLE WILL NOT RUN. ALSO, CONSUMER WAS EXPERIENCING BRAKING PROBLEMS. BRAKE PEDAL SOMETIMES WENT ALL THE WAY TO THE FLOOR BEFORE IT STOPPED. THIS MADE HER FEEL VERY UNCOMFORTABLE.*AK
Official recalls
499V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
96V142000 · Seat Belts:rear/other
Jul 31, 1996
THESE VEHICLES EXHIBIT A CONDITION IN WHICH A REAR SEAT BELT BUCKLE RELEASE BUTTON CAN STICK IN THE UNLATCHED (DOWN) POSITION UNDER CERTAIN CONDITIONS BECAUSE THE BUCKLE ASSEMBLY CAN MOVE INSIDE THE SEAT BELT COVER. IF THE COVER MOVES FAR ENOUGH, IT CAN CREATE AN INTERFERENCE CONDITION WITH THE LATCH RELEASE BUTTON. WHEN IT DOES, THE SEAT BELT BUCKLE CANNOT BE LATCHED.
Consequence & remedy
Consequence: THE REAR BELTS MAY NOT HOLD AN OCCUPANT IN THE EVENT OF A VEHICLE ACCIDENT INCREASING THE RISK OF PESONAL INJURY.
Remedy: DEALERS WILL REPLACE THE THREE REAR-SEAT BELT BUCKLES (ONE ASSEMBLY) WITH A NEW, REVISED DESIGN.
93V119000 · Service Brakes, Hydraulic:foundation Components:disc:rotor
Aug 2, 1993
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence & remedy
Consequence: SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
91V108000 · Fuel System, Gasoline:storage
Jun 21, 1991
VEHICLES HAVE BEEN SHIPPED WITH THE FUEL TANK SENDER SEAL OUT OF POSITION.
Consequence & remedy
Consequence: IN THE EVENT OF ROLLOVER ACCIDENT, AN OUT OF POSTIONSEAL COULD ALLOW FUEL SPILLAGE IN EXCESS OF THE AMOUNT PRESCRIBED BY FMVSS 301.SPILLED FUEL COULD IGNITE NEAR AN IGNITION SOURCE.
Remedy: REPLACE SENDER SEALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA95031 · Rear Seat Belt Failure
Opened Oct 31, 1995 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Seat Belts:rear/other
COMPLAINTS INDICATE THAT THE REAR SEATBELT BUCKLES DO NOT WORK, WHICH PREVENTS USAGE OF THE BELTS.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
EA94029 · Engine Compartment Fires
Opened Jul 29, 1994 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
AN ALLEGED MALFUNCTION IN THE ATLERNATOR RESULTING IN ENGINE COMPARTMET FIRES.
PE94046 · Abs Braking System Fails
Opened Jun 17, 1994 · Closed Oct 31, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA92015 · High Idle Flare
Opened May 22, 1992 · Closed May 28, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92001 · High Idle Flare
Opened Jan 7, 1992 · Closed May 22, 1992
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA91028 · Brake Failure
Opened Jun 10, 1991 · Closed Jun 30, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
===
PE91052 · Brake Failure
Opened Feb 22, 1991 · Closed Jun 10, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available