The contact owns a 2011 BMW 528i. The contact stated that the driver’s side headlight housing had an excessive amount of moisture inside. The vehicle failed to start. The daytime and parking light was illuminated. The vehicle was taken to an independent mechanic. The local dealer was not contacted. The vehicle was not diagnosed …
Read full complaint
The contact owns a 2011 BMW 528i. The contact stated that the driver’s side headlight housing had an excessive amount of moisture inside. The vehicle failed to start. The daytime and parking light was illuminated. The vehicle was taken to an independent mechanic. The local dealer was not contacted. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 140,000.
NHTSA ODI #11421045
106,000 miles · Mar 22, 2019
Exterior Lighting
HEADLIGHT WIRING IS SHORTING OUT DUE TO THE PLASTIC COATING ON THE WIRING DEGRADING. THIS ISSUE IS CURRENTLY ONLY AFFECTING THE DAYTIME RUNNING LIGHTS BUT HAS CAUSED A SHORT IN THE HEADLIGHT SYSTEM WHICH, WITHOUT REPAIR, WILL EVENTUALLY AFFECT THE HEADLIGHTS. THIS IS A SERIOUS SAFETY CONCERN BECAUSE A SHORT IN ONE HEADLIGHT CAN …
Read full complaint
HEADLIGHT WIRING IS SHORTING OUT DUE TO THE PLASTIC COATING ON THE WIRING DEGRADING. THIS ISSUE IS CURRENTLY ONLY AFFECTING THE DAYTIME RUNNING LIGHTS BUT HAS CAUSED A SHORT IN THE HEADLIGHT SYSTEM WHICH, WITHOUT REPAIR, WILL EVENTUALLY AFFECT THE HEADLIGHTS. THIS IS A SERIOUS SAFETY CONCERN BECAUSE A SHORT IN ONE HEADLIGHT CAN LEAD TO A FAILURE OF THE ENTIRE SYSTEM LEAVING ME WITHOUT HEADLIGHTS. THIS ISSUE IS APPARENTLY CAUSED BY WIRING WHICH DEGRADES IN HIGHER HEAT WHICH SHOULD NEVER HAVE BEEN INSTALLED IN A HEADLIGHT ASSEMBLY.
NHTSA ODI #11190830
Mileage unknown · Jul 5, 2016
Electrical SystemEngineExterior Lighting
THIS MALFUNCTION LIGHT HAS BEEN COMING ON SINCE I BOUGHT THIS VEHICLE. IT IS EXTREMELY FRUSTRATING BECAUSE EVERY TIME I HAVE THAT THIS CAR SERVICED THEY HAVE NEVER TRULY FIXED THE PROBLEM. IT MAY STOP FOR A MOMENT AND THEN ANY RANDOM DAY IT WILL GIVE ME THIS WARNING AS YOU SE IN THE PICTURE PROVIDED. A BIGGER PROBLEM THAT IS UNE…
Read full complaint
THIS MALFUNCTION LIGHT HAS BEEN COMING ON SINCE I BOUGHT THIS VEHICLE. IT IS EXTREMELY FRUSTRATING BECAUSE EVERY TIME I HAVE THAT THIS CAR SERVICED THEY HAVE NEVER TRULY FIXED THE PROBLEM. IT MAY STOP FOR A MOMENT AND THEN ANY RANDOM DAY IT WILL GIVE ME THIS WARNING AS YOU SE IN THE PICTURE PROVIDED. A BIGGER PROBLEM THAT IS UNEXCEPTABLE IS THAT THE CAR KEEPS FLASHING A WARNING ABOUT THE COOLENT IS NEEDED AND THAT IT NEEDS TO BE FIXED OR THERE COULD BE ENGINE DAMAGE. THIS WARNING HAS BEEN THE MAIN CONCER. I HAVE HAD THE COOLENT GO INTO THE ENGINE WHICH CAUSED MY CAR TO SHUT DOWN ON A BUSY HWY 3 SEPERATE TIMES, RISKING A DANGER TO MYSELF AND OTHERS ON THE ROAD. I HAVE NOT HEARD A WORD FROM BMW OF NORTH AMERICA THAT THEY CARE ABOUT MY CONCERNS AND I FEEL THAT THIS PROBLEM HAS LITERALLY AFFECTED MY HEALTH AND WELL BEING. I HAVE HUGE ANXIETY ISSUES BECAUSE OF THIS CAR. I HOPE MY LETTER IS HEARD SO THAT I MAY HAVE JUSTICE FOR THIS CAR. I AM OVERWHELMED WITH NERVOUSNES EVERYTIME I DRIVE IT. I FEEL LIKE SOMETHING BAD WILL HAPPEN TO ME ORCSOME ELSE. PLEASE HELP THIS MATTER BECOME RES OLVED!
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain model year 2011 BMW 528i, 528xi, 535i, 535xi, 550i and 550xi vehicles manufactured March 1, 2010, through August 31, 2011. The affected vehicles may have received a replacement Sensor Cluster Unit (SCU) during a service visit. These SCUs have an acceleration sensor that may have been incorrectly programmed and, as a result, the SCU may not accurately determine if activation and deployment of the air bags, safety belt pre-tensioners and head restraints is necessary in the event of a crash.
Consequence & remedy
Consequence: Depending on the severity of the crash, inadequate activation of the driver and/or passenger air bags, safety belt pre-tensioners and active head restraints may increase the risk of injury.
Remedy: BMW will notify owners, and dealers will replace the SCU, free of charge. The recall began on December 16, 2016. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
Consequence & remedy
Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain model year 2010-2011 128i Coupe, 128i Convertible, 328i Sedan, 328i xDrive Sedan, 328i Coupe, 328i Convertible, 328i Sports Wagon and Z4 sDrive 30i, 2011-2012 135i Coupe, 135i Convertible, 335i Sedan, X5 xDrive 35i, and X6 xDrive 35i, 2011 335i xDrive Sedan, 335i Coupe, 335i Convertible, 528i Sedan, 535i Sedan, 535i xDrive Sedan, X3 xDrive 28i, and X3 xDrive 35i, 2010 X3 xDrive 30i, and X5 xDrive 30i, 2012 640i Coupe, and 640i Convertible and 2010-2012 535i Gran Turismo vehicles. In the affected vehicles, the bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and may possibly break.
Consequence & remedy
Consequence: If the bolts loosen or break the engine may have reduced power or stall. An engine stall increases the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the four VANOS housing bolts for both VANOS units (intake and exhaust), free of charge. In addition, owners of approximately 170,172 model year 2010-2012 BMW vehicles equipped with inline 6 cylinder engines not covered by this recall, will receive an extended warranty to address this condition. The recall began on September 24, 2014. Owners may contact BMW at 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2011 BMW 528I Problems, Complaints & Recalls | Skip That Year
Illustration