TL* THE CONTACT OWNS A 2010 BMW 528I. THE CONTACT STATED THAT THE DRIVER'S SIDE HEADLIGHT AND BRAKE LIGHT WARNING INDICATORS ILLUMINATED AND THE EXTERIOR LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED PER AN UNKNOWN RECALL;…
Read full complaint
TL* THE CONTACT OWNS A 2010 BMW 528I. THE CONTACT STATED THAT THE DRIVER'S SIDE HEADLIGHT AND BRAKE LIGHT WARNING INDICATORS ILLUMINATED AND THE EXTERIOR LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED PER AN UNKNOWN RECALL; THEREFORE, THEY COULD NOT ASSIST. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.
NHTSA ODI #11161172
60,000 miles · Jul 9, 2018
Electrical SystemExterior Lighting
TL* THE CONTACT OWNS A 2010 BMW 528I. WHILE DRIVING VARIOUS SPEEDS, THE BRAKE WARNING INDICATOR ILLUMINATED. THE CONTACT ALSO STATED THAT THE RIGHT AND LEFT TURN SIGNAL INDICATORS FAILED TO OPERATE AND THE REAR BRAKE LIGHTS FAILED TO ILLUMINATE. IN ADDITION, THE INSTRUMENT PANEL LIGHTING FAILED TO ILLUMINATE. THE VEHICLE WAS NOT…
Read full complaint
TL* THE CONTACT OWNS A 2010 BMW 528I. WHILE DRIVING VARIOUS SPEEDS, THE BRAKE WARNING INDICATOR ILLUMINATED. THE CONTACT ALSO STATED THAT THE RIGHT AND LEFT TURN SIGNAL INDICATORS FAILED TO OPERATE AND THE REAR BRAKE LIGHTS FAILED TO ILLUMINATE. IN ADDITION, THE INSTRUMENT PANEL LIGHTING FAILED TO ILLUMINATE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OF THE FAILURES. THE CONTACT, A CERTIFIED INDEPENDENT MECHANIC, STATED THAT THE BRAKE LIGHT MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN ANY RECALLS; THEREFORE, NO ASSISTANCE WAS OFFERED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
NHTSA ODI #11110340
95,680 miles · Aug 5, 2016
Electrical SystemExterior Lighting
I TOOK MY VEHICLE TO BMW IRVINE IN CALIFORNIA FOR A RECALL ON MY TAIL LIGHTS, THEY STOP WORKING, THE RECALL WAS TO REPLACE BOTH SIDES AND THEY ONLY DID ONE. THE SIDE THAT BURN OUT BUT THEY LEFT THE SAME CONNECTOR WHICH WAS BURNT AND WITH THE WIRES LOOSE AND I WASNT EVEN NOTIFY WHEN I PICK THE VEHICLE UNTIL WHEN I START DRIVING …
Read full complaint
I TOOK MY VEHICLE TO BMW IRVINE IN CALIFORNIA FOR A RECALL ON MY TAIL LIGHTS, THEY STOP WORKING, THE RECALL WAS TO REPLACE BOTH SIDES AND THEY ONLY DID ONE. THE SIDE THAT BURN OUT BUT THEY LEFT THE SAME CONNECTOR WHICH WAS BURNT AND WITH THE WIRES LOOSE AND I WASNT EVEN NOTIFY WHEN I PICK THE VEHICLE UNTIL WHEN I START DRIVING THE LIGHT STOPWORKING AGAIN. THEY ANSWER IS NOT T HEIR FAULT DONT CARE. NOW MY VEHICLE DOESN'T RUN AND I GOT ALL KINDS OF WIRED MESSAGES ON MY IDRIVE. HALF WAY DONE RECALLS??? BAD CUSTOMER SERVICE.
NHTSA ODI #10893447
57,000 miles · Sep 4, 2013
Electrical SystemExterior Lighting
I RECEIVED A DISPLAYED MESSAGE THERE WAS A MALFUNCTION WITH THE REAR LAMP. WHEN CHECKING THE TAIL LIGHT ASSEMBLY AND WIRING, I NOTICED THE CONNECTOR ON THE TAIL LAMP ASSEMBLY WAS MELTED (PLASTIC) WHERE THE BROWN GROUND WIRE CONNECTED. THE MALE/FEMALE CONNECTOR PARTS GOT SO HOT THAT THE PLASTIC CONNECTOR WAS MELTED WHERE THE GROU…
Read full complaint
I RECEIVED A DISPLAYED MESSAGE THERE WAS A MALFUNCTION WITH THE REAR LAMP. WHEN CHECKING THE TAIL LIGHT ASSEMBLY AND WIRING, I NOTICED THE CONNECTOR ON THE TAIL LAMP ASSEMBLY WAS MELTED (PLASTIC) WHERE THE BROWN GROUND WIRE CONNECTED. THE MALE/FEMALE CONNECTOR PARTS GOT SO HOT THAT THE PLASTIC CONNECTOR WAS MELTED WHERE THE GROUND WIRE CONNECTS. THIS WAS ON THE DRIVERS SIDE, BUT IT IS LIKELY THE PASSENGER SIDE WOULD HAVE THE SAME PROBLEM. THE HEAT GENERATED TO MELT THE PLASTIC CONNECTOR COULD CAUSE THE GROUND WIRE TO BURN AND THE BRAKE/REAR LIGHTS TO FAIL. WITH A FAILURE OF THE REAR LIGHTS, AN ACCIDENT COULD HAPPEN. *JB
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
BMW is recalling certain model year 2008 through 2010 528i, 535i, 550i, and M5 passenger cars manufactured from March 1, 2007, through December 31, 2009. Over time, increased resistance at the taillight electrical contact points may cause damage to the ground terminal and housing of the connector resulting in an intermittent or permanent loss of functionality of one or more rear lamp functions (tail, brake, turn-signal, reverse).
Consequence & remedy
Consequence: Intermittent light operation reduces the ability to warn other motorists of the driver's intentions, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the rear lamp bulb carriers free of charge. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2010 BMW 528I Problems, Complaints & Recalls | Skip That Year
Illustration