Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 13 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports2 injury reports
What owners actually said
13 reports
167,446 miles · Oct 20, 2012
Electrical SystemSteering
I PARKED MY CAR IN THE GARAGE AS USUAL. WHEN I WENT OUT TO LEAVE HOME THE STEERING WAS LOCKED. NOTHING OUT OF THE ORDINARY WAS DONE AFTER PARKING IT OR WHEN ATTEMPTING TO START IT. THE LIGHTS FOR THE RADIO CAME ON, THE WINDSHIELD WIPER WORKS, THE LIGHTS ON THE CONSOLE LIGHT UP, BUT THE STEERING WHEEL IS LOCKED AND THE KEY WILL N…
Read full complaint
I PARKED MY CAR IN THE GARAGE AS USUAL. WHEN I WENT OUT TO LEAVE HOME THE STEERING WAS LOCKED. NOTHING OUT OF THE ORDINARY WAS DONE AFTER PARKING IT OR WHEN ATTEMPTING TO START IT. THE LIGHTS FOR THE RADIO CAME ON, THE WINDSHIELD WIPER WORKS, THE LIGHTS ON THE CONSOLE LIGHT UP, BUT THE STEERING WHEEL IS LOCKED AND THE KEY WILL NOT TURN MORE THAN A FEW CENTIMETERS. *TR
NHTSA ODI #10481271
108,000 miles · Jul 17, 2004
Seats
WHILE SITTING IN MY 1991 BMW 525I THE SEAT SUDDENLY FELL BACKWARD,AND SIDEWAYS. AFTER REMOVING THE SEAT, AND ALMOST COMPLETELY DISSASSEMBLING IT SO I COULD TRY TO REALIGN THE THING LONG ENOGH TO MAKE IT HOME,I WAS ABLE TO THROUGH BRUTE FORCE PUT IT BACK IN PLACE. LATER AFTER SEVERAL SUBSEQUENT FAILURES I WAS ABLE TO PINPOINT THE…
Read full complaint
WHILE SITTING IN MY 1991 BMW 525I THE SEAT SUDDENLY FELL BACKWARD,AND SIDEWAYS. AFTER REMOVING THE SEAT, AND ALMOST COMPLETELY DISSASSEMBLING IT SO I COULD TRY TO REALIGN THE THING LONG ENOGH TO MAKE IT HOME,I WAS ABLE TO THROUGH BRUTE FORCE PUT IT BACK IN PLACE. LATER AFTER SEVERAL SUBSEQUENT FAILURES I WAS ABLE TO PINPOINT THE PROBLEM.THE CABLES THAT GO BETWEEN THE ELECTRIC DRIVE MOTORS AND THE SEAT ADJUSTMENT GEARBOXES WERE SHEATHED IN A FAILURE-PRONE PLASTIC! THE PLASTIC THROUGH TIME WEARS AND STRETCHES UNTILL THE DRIVE CABLE SLIPS OUT OF GEARBOX ALLOWING CATASTROPHIC FAILURE. I JUST CHECKED TO SEE IF THIS ITEM HAD BEEN RECALLED WITH NO LUCK. *AK
NHTSA ODI #10081274
Mileage unknown · Nov 7, 2002
Exterior Lighting
TAIL LIGHTS DO NOT STAY ON DUE TO DEFECTIVE SOCKETS. THE PLASTIC SOCKETS HAVE MELTED FROM THE HEAT OF THE TAIL LIGHT BULBS AND NO LONGER HOLD THE BULBS IN PROPERLY. THEY BLINK ON AND OFF AND SOMETIMES STAY OFF ALL TOGETHER. DEALER ADVISED ME TO BUY NEW ONES @ $320 EACH TO SOLVE THE PROBLEM. SINCE THIS IS A SAFETY DEFECT, BMW…
Read full complaint
TAIL LIGHTS DO NOT STAY ON DUE TO DEFECTIVE SOCKETS. THE PLASTIC SOCKETS HAVE MELTED FROM THE HEAT OF THE TAIL LIGHT BULBS AND NO LONGER HOLD THE BULBS IN PROPERLY. THEY BLINK ON AND OFF AND SOMETIMES STAY OFF ALL TOGETHER. DEALER ADVISED ME TO BUY NEW ONES @ $320 EACH TO SOLVE THE PROBLEM. SINCE THIS IS A SAFETY DEFECT, BMW SHOULD REPLACE THEM. DT
NHTSA ODI #769401
Mileage unknown · Jul 11, 2000
Electrical SystemEngine And Engine CoolingExterior Lighting
THE COOLING SYSTEM FAN CLUTCH FAILED WITHIN 45,000 MILES. NLM
NHTSA ODI #552975
Mileage unknown · Oct 13, 1999
Engine And Engine Cooling
UPPER RADIATOR "PLASTIC MALE" OUTLET CONNECTING TO UPPER RUBBER HOSE EXPLODED CAUSING EXTRIME ENGINE OVERHEATING AND ENGINE FAILURE WITH NO WARNING EVEN AFTER DEALER INSTALLED NEW RADIATOR CAP RECALL IN AUGUST 1999. ALMOST CAUSED A HIGHWAY ACCIDENT. CAR HAS EXCELLENT MAINTENANCE RECORD AT DEALERSHIP. REPORTED PROBLEM TO BMW OF N…
Read full complaint
UPPER RADIATOR "PLASTIC MALE" OUTLET CONNECTING TO UPPER RUBBER HOSE EXPLODED CAUSING EXTRIME ENGINE OVERHEATING AND ENGINE FAILURE WITH NO WARNING EVEN AFTER DEALER INSTALLED NEW RADIATOR CAP RECALL IN AUGUST 1999. ALMOST CAUSED A HIGHWAY ACCIDENT. CAR HAS EXCELLENT MAINTENANCE RECORD AT DEALERSHIP. REPORTED PROBLEM TO BMW OF NORTH AMERICA. REPRESENTATIVE TOLD ME THAT WAS NOT THE RESPONSIBILITY OF BMW OF NORTH AMERICA.
NHTSA ODI #713258
Mileage unknown · Jul 30, 1999
Engine And Engine Cooling
REPLACED THE RADIATOR CAP BUT THE NEW CAP CAUSED A HOLE IN THE RADIATOR. *AK
NHTSA ODI #843991
Mileage unknown · Feb 3, 1999
Engine And Engine CoolingInjury
ENGINE COOLING SYSTEM DESIGN CONTAINS A FLAW, WHEN REMOVING RADIATOR CAP CONSUMER SUSTAINED BURN INJURIES DUE TO CAP NOT HAVING A TWO-STAGE RELEASE, O-RINGS AT THE BASE OF THE CAP ENSURE THAT THE PRESSURE IS MAINTAINED WITHIN THE RADIATOR UNTIL THE CAP IS FULLY UNSCREWED.
NHTSA ODI #530970
Mileage unknown · Jan 24, 1999
Air Bags
THE SRS {A SAFETY SYSTEM} LIGHT KEEPS FLASHING. *AK
NHTSA ODI #702525
Mileage unknown · Jan 5, 1999
Structure
POWER DOOR LOCK MECHANISM FAILED CAUSING ERRATIC PERFORMANCE OF THE LOCKS.
NHTSA ODI #543257
Mileage unknown · Dec 14, 1998
Power Train
THE SPEEDOMETER OPERATES IRRATICALLY DURING COLD WEATHER. IT FUNCTIONS OK WHEN WARM. THIS IS CAUSED BY BAD MATERIALS USED ON THE SPEEDOMETER PCB BOARD. A NUMBER OF BMW OWNERS HAVE EXPERIENCED THIS PROBLEM AND FIXES ARE SUGGESTED ON THE INTERNET AT THE FOLLOWING LINKS. HTTP://WWW.ESKIMO.COM/~DALUS/BMW/SPEEDO/SPEEDO.HTM AND AT HT…
Read full complaint
THE SPEEDOMETER OPERATES IRRATICALLY DURING COLD WEATHER. IT FUNCTIONS OK WHEN WARM. THIS IS CAUSED BY BAD MATERIALS USED ON THE SPEEDOMETER PCB BOARD. A NUMBER OF BMW OWNERS HAVE EXPERIENCED THIS PROBLEM AND FIXES ARE SUGGESTED ON THE INTERNET AT THE FOLLOWING LINKS. HTTP://WWW.ESKIMO.COM/~DALUS/BMW/SPEEDO/SPEEDO.HTM AND AT HTTP://WWW.ESKIMO.COM/~DALUS/BMW/E30/INTERIOR/E30_SPEEDO_SENDER_PROBLEM.HTML. UNRELIABLE OR LACK OF INDICATION OF DRIVING SPEED CAN BE A SERIOUS SAFETY ISSUE. THIS APPEARS TO BE A PROBLEM THAT MANY BMW OWNERS HAVE SUFFERED AS INDICATED BY THE NUMBER OF PEOPLE WHO HAVE REPORTED IT ON THE WEB. THE DEALER WANTS OVER $600 TO FIX THE PROBLEM. *MJS
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence & remedy
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
THE AIR BAG CONTACT RING LOCKING TAB LOCATED IN THE STEERING WHEEL ASSEMBLY CAN BREAK WITHOUT WARNING.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE CONTACT RING WIRING COULD EVENTUALLY BREAK. THE AIR BAG READINESS INDICATOR LAMP (SRS OR AIRBAG) IN THE INSTRUMENT CLUSTER WILL ILLUMINATE, AND THE AIR BAG WOULD NOT DEPLOY IN THE EVENT OF A FRONTAL IMPACT VEHICLE COLLISION.
Remedy: DEALERS WILL REPLACE THE LOCKING TAB WITH ONE OF A DIFFERENT DESIGN.
THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1991 BMW 525I Problems, Complaints & Recalls | Skip That Year
Illustration