Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 13 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports2 injury reports
What owners actually said
13 reports
Mileage unknown · Nov 30, 1998
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
FLUID LEAKS SINCE '11/95. HAVE HAD A TOTAL OF 3 COILS REPLACED; R/R LOWER TIMING COVER, REPLACED GASKETS/NEW DRIVE BELTS - R/R OIL PAN AND REPLACED GASKET TO THE TUNE OF $1,125.00 AT 39,243 MILES. WARANTY IS 4 YRS./50K MILES. ASKED FOR AN ADJUSTMENT DUE TO LOW MILEAGE AND HIGHLY UNUSUAL PROBLEMS. RECEIVED FORM LETTER SAYING …
Read full complaint
FLUID LEAKS SINCE '11/95. HAVE HAD A TOTAL OF 3 COILS REPLACED; R/R LOWER TIMING COVER, REPLACED GASKETS/NEW DRIVE BELTS - R/R OIL PAN AND REPLACED GASKET TO THE TUNE OF $1,125.00 AT 39,243 MILES. WARANTY IS 4 YRS./50K MILES. ASKED FOR AN ADJUSTMENT DUE TO LOW MILEAGE AND HIGHLY UNUSUAL PROBLEMS. RECEIVED FORM LETTER SAYING "SORRY, CAR IS OUT OF WARRANTY." THIS $45K+ AUTO
NHTSA ODI #701020
Mileage unknown · Nov 17, 1998
Air BagsInjury
TRAVELING 65MPH GOING AROUND A CURB WHEN SUDDENLY, THE DRIVER'S SIDE AIR BAG DEPLOYED FOR NO REASON. IT OBSTRUCTED THE DRIVER'S VIEW. HAD NOT HIT ANYTHING & NO OTHER VEHICLE HAD HIT BMW. STEERING WHEEL HAD TO BE TAPED TO BE DRIVEN. *AK
NHTSA ODI #830898
Mileage unknown · Oct 1, 1998
Vehicle Speed Control
VEHICLE COLLISION DUE TO FAILURE OF THE CRUISE CONTROL AND THROTTLE CABLES, RECALL ISSUED AFTER ACCIDENT OCCURED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence & remedy
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
THE AIR BAG CONTACT RING LOCKING TAB LOCATED IN THE STEERING WHEEL ASSEMBLY CAN BREAK WITHOUT WARNING.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE CONTACT RING WIRING COULD EVENTUALLY BREAK. THE AIR BAG READINESS INDICATOR LAMP (SRS OR AIRBAG) IN THE INSTRUMENT CLUSTER WILL ILLUMINATE, AND THE AIR BAG WOULD NOT DEPLOY IN THE EVENT OF A FRONTAL IMPACT VEHICLE COLLISION.
Remedy: DEALERS WILL REPLACE THE LOCKING TAB WITH ONE OF A DIFFERENT DESIGN.
THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1991 BMW 525I Problems, Complaints & Recalls | Skip That Year
Illustration