Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 5 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Equipment. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
What owners actually said
5 reports
230,000 miles · Nov 3, 2014
Electrical SystemStructure
TL* THE CONTACT OWNS A 1993 BMW 525I. THE CONTACT STATED THAT BOTH THE REAR DRIVER AND PASSENGER SIDE DOORS FAILED TO OPEN. AS A RESULT, THE REAR PASSENGERS WERE NOT ABLE TO ENTER OR EXIT THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 230,000. THE …
Read full complaint
TL* THE CONTACT OWNS A 1993 BMW 525I. THE CONTACT STATED THAT BOTH THE REAR DRIVER AND PASSENGER SIDE DOORS FAILED TO OPEN. AS A RESULT, THE REAR PASSENGERS WERE NOT ABLE TO ENTER OR EXIT THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 230,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10652023
Mileage unknown · Jun 2, 2000
Engine And Engine CoolingEquipmentFire
RECEIVED INSTALLATION OF RECALLED RADIATOR CAP AT VOB BMW IN 9/27/99 (98V178000) THAT WAS SUPPOSED TO KEEP THE BMW CARS FROM OVERHEATING WHICH CAUSES THE ENGINE TO OVERHEAT AND BURNUP. ON 5/9/00 THE TEMP WAS 95 DEGREES F, AFTER RUNNING MY AIR CONDITIONING, MY CAR BEGAN TO SMOKE HEAVILY AND THE ENGINE BURNED-OUT BEFORE I COULD G…
Read full complaint
RECEIVED INSTALLATION OF RECALLED RADIATOR CAP AT VOB BMW IN 9/27/99 (98V178000) THAT WAS SUPPOSED TO KEEP THE BMW CARS FROM OVERHEATING WHICH CAUSES THE ENGINE TO OVERHEAT AND BURNUP. ON 5/9/00 THE TEMP WAS 95 DEGREES F, AFTER RUNNING MY AIR CONDITIONING, MY CAR BEGAN TO SMOKE HEAVILY AND THE ENGINE BURNED-OUT BEFORE I COULD GET IT ALL THE WAY OFF THE ROAD. THE SERVICE MECHANIC I HAD MY CAR TOWED TO, FOUND THAT THE RADIATOR AND ENGINE BOTH HAD A LARGE HOLE IN EACH. ALSO, THE WATER PUMP IMPELLER WHICH IS PLASTIC WAS BROKEN OR MELTED OFF. AS A RESULT, NO FLUIDS WERE GETTING TO THE ENGINE; HENCE, MY ENGINE BURNED UP QUICKLY. *AK
NHTSA ODI #723498
Mileage unknown · May 22, 2000
Engine And Engine Cooling
A MALFUNCTION OR FAILURE OF A COLLING SYSTEM COMPONENT (THERMOSTAT, WATER PUMP OR FAN BELT) CAUSED THE VEHICLE TO OVERHEAT PRIOR TO RECALL NOTICE 98V-178. NLM
NHTSA ODI #552353
Mileage unknown · Jan 25, 1999
Engine And Engine Cooling
DESIGN OF CHARCOAL FILTER CANISTER CAUSED IT TO ABSORBED A LARGE AMOUNT OF WATER CAUSING IT TO FREEZE AND THE FUEL PUMP KEPT PUMPING UNTIL THE FUEL TANK IMPLODED.
NHTSA ODI #543576
Mileage unknown · Feb 25, 1998
Power Train
VEHICLE PARKED ON ON DOWN HILL GRADE. WHEN VEHICLE IS STARTED AND PUT IN REVERSE GEAR, THE TRANSMISSION DOES NOT ENGAGE IMMEDIATELY AND VEHICLE ROLLS FORWARD. INCREASED PRESSURE IS APPLIED TO THE ACCELERATOR AND SUDDENLY THE TRANSMISSION ENGAGES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence & remedy
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1993 BMW 525I Problems, Complaints & Recalls | Skip That Year
Illustration