MICHELIN CROSS TERRAIN WITH < 39K MILES ON 2008 VOLVO XC90 HAD A TREAD SEPARATION AT INTERSTATE HIGHWAY SPEED DURING BUSY DOWNTOWN TRAFFIC NEARLY CREATING AN ACCIDENT FOR ME AND TWO OF MY CHILDREN. VEHICLE DAMAGE CAUSED SOLELY BY THE TIRE FLAILING THE RIGHT REAR OF MY VEHICLE EXCEEDED $3500. TREAD COMPLETELY SEPARATED FROM THE…
Read full complaint
MICHELIN CROSS TERRAIN WITH < 39K MILES ON 2008 VOLVO XC90 HAD A TREAD SEPARATION AT INTERSTATE HIGHWAY SPEED DURING BUSY DOWNTOWN TRAFFIC NEARLY CREATING AN ACCIDENT FOR ME AND TWO OF MY CHILDREN. VEHICLE DAMAGE CAUSED SOLELY BY THE TIRE FLAILING THE RIGHT REAR OF MY VEHICLE EXCEEDED $3500. TREAD COMPLETELY SEPARATED FROM THE STEEL BELTS AS A CONTINUOUS RING. TREAD LUGS CAN BE PULLED AWAY BY HAND FROM THE LOWER RUBBER THEY APPEAR TO BE BONDED TO AND THIS UNDERNEATH RING OF RUBBER HAD VERY CLEANLY PULLED AWAY FROM THE BELTS. TIRE REMAINED INFLATED. EVIDENCE OF IMPENDING FAILURE WAS NOTED AS I WAS FEELING VIBRATION FROM THE TIRE FOR 30 MINUTES PRIOR TO CATASTROPHIC FAILURE AND HAD EVEN STOPPED TO INSPECT THE WHEEL FOR A PROBABLE CAUSE. PHOTO DOCUMENTATION AVAILABLE. INTERNET SEARCHING IS CLEARLY SHOWING THAT, FOR THIS MODEL TIRE, THIS IS A COMMON OCCURRENCE. DOES ANYBODY REMEMBER THE OVER 250 DEATHS ATTRIBUTED TO THE TREAD SEPARATION OF BRIDGESTONE TIRES ON FORD EXPLORERS? I DO. *TR
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
VOLVO IS RECALLING 102 MY 2008 XC90 AND S80 VEHICLES EQUIPPED WITH V8 ENGINES. THESE VEHICLES MAY HAVE BEEN BUILT WITH INCORRECT BOLTS TO THE ENGINE MOUNT.
Consequence & remedy
Consequence: THE ALUMINUM BRACKET FOR THE ENGINE MOUNT COULD BREAK DUE TO LACK OF ADEQUATE CLAMPING FORCE. THIS COULD CAUSE THE ENGINE TO COME IN CONTACT WITH THE SUB-FRAME, ULTIMATELY RESULTING IN A REDUCED ENGINE TORQUE OR STALLING OF THE ENGINE WITHOUT PRIOR WARNING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE ENGINE MOUNT BOLTS FOR SPECIFIC MARKINGS. IF ANY OF THE BOLTS CONTAIN THE INCORRECT MARKINGS, THE BRACKET AND BOLTS WILL BE REPLACED. ALL OWNERS HAVE BEEN CONTACTED AND ARRANGEMENTS HAVE BEEN MADE TO REPAIR THESE VEHICLES.
ON CERTAIN SPORT UTILITY VEHICLES, UNDER CERTAIN CONDITIONS, THE CLIMATE CONTROL MODULE (CCM) MAY RECEIVE A 'SHUT-DOWN SIGNAL' FROM THE ENGINE CONTROL MODULE (ECM) AFTER IGNITION KEY INSERTION. IF THIS CONDITION OCCURS, THE CLIMATE CONTROL FUNCTIONS WILL NOT BE AVAILABLE (INCLUDING THE DEFROSTER) DURING THAT DRIVING CYCLE.
Consequence & remedy
Consequence: INOPERATIVE DEFROSTERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE IMPAIRED VISIBILITY WHICH HAS THE POTENTIAL TO RESULT IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.
Remedy: THE ECM SOFTWARE WILL BE UPGRADED. THE RECALL BEGAN ON JANUARY 28, 2008. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2008 Volvo XC90 Problems, Complaints & Recalls | Skip That Year
Illustration