Power Train. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports2 fire reports4 injury reports

Latches/locks/linkages complaints

2 reports

Clear category filter

Mileage unknown · Jan 12, 2005

Latches/locks/linkages

DURING THE PAST 2 WEEKS THE LOS ANGELES AREA HAS HAD A LOT OF RAIN. AFTER THE FIRST FEW DAYS OF RAIN, MY WIFE AND DISCOVERED THAT BOTH OF THE REAR PASSENGER DOORS WILL NOT OPEN FROM THE OUTSIDE, EVEN THOUGH THE LOCK PULL KNOBS ON ALL 4 DOORS POP UP WHEN YOU CLICK "UNLOCK" ON THE REMOTE.*AK

NHTSA ODI #10106166

Mileage unknown · Apr 26, 2004

Electrical SystemEngine And Engine CoolingExterior Lighting

Read full complaint

I OWN A VOLVO XC90 T6 AWD. THIS CAR HAS HAD PROBLEMS WITH THE TWIN TURBO-CHARGERS, THE WARNING LIGHTS, A TIRE BLOWOUT, VIBRATIONS IN THE STEERING WHEEL, ALIGNMENT ISSUES, SHORT CIRCUIT IN THE DRIVER'S SIDE CONTROL PANEL, POOR FIT AND FINISH OF THE DRIVER SIDE DOOR PANEL AND A HOST OF OTHER FIT AND FINISH PROBLEMS. THE MOMENTUM VOLVO DEALERSHIP IN HOUSTON, TEXAS AND VOLVO NORTH AMERICA SERVICE REPRESENTATIVE DENIED ANY PROBLEMS BEING A SERIOUS OR RECURRING PROBLEM. THIS ALL TOOK PLACE IN A SPAN OF LESS THAN 10 MONTHS FOR A BRAND NEW VEHICLE.THE CAR SPENT MORE TIME IN THE SHOP THAN IN OUR POSSESSION INITIALLY. THE DEALERSHIP CONTINUED TO FIX THE RECURRING PROBLEMS AND DENIED ANY CHRONIC ISSUES EXISTED. I WISH TO ALERT NHTSA IN THE EVENT ANY OTHER OWNER OF VOLVO XC 1990 HAS SIMILAR COMPLAINTS OR A TRAGEDY OCCURS AS A RESULT OF THE PROBLEMS I HAVE LISTED. *AK

NHTSA ODI #10067880

Official recalls

10V566000 · Equipment:electrical:navigational System(global Positioning System)

Nov 8, 2010

VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

Consequence & remedy

Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.

Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.

09V483000 · Fuel System, Gasoline:delivery:fuel Pump

Dec 18, 2009

VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.

Consequence & remedy

Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

06V155000 · Steering:linkages:tie Rod Assembly

May 5, 2006

ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.

Consequence & remedy

Consequence: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

06V144000 · Visibility:windshield Wiper/washer

Apr 28, 2006

ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.

Consequence & remedy

Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.

Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.

03V391000 · Seat Belts:rear/other

Oct 10, 2003

ON CERTAIN SPORT UTILITY VEHICLES, THE SEAT BELT ATTACHMENT(S) FOR THE SECOND AND THIRD ROW SEAT(S) MAY NOT HAVE BEEN FITTED PROPERLY.

Consequence & remedy

Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.

Remedy: DEALERS WILL INSPECT AND REPAIR THE SECOND AND/OR THIRD ROW SEAT BELT ATTACHMENTS. OWNER NOTIFICATION BEGAN ON DECEMBER 8, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.