LEAVING A PARKING LOT AND HEARD LOUD SOUND CAR WOULDN'T MOVE. VOLVO SAYS THE FOLLOWING IS BROKEN: LOWER CONTROL ARM, CV AXLE, ROTOR AND DAMAGED RIM. WE HAD BEEN PARKED AND WERE ATTEMPTING TO LEAVING PARKING LOT(.BARELY MOVING) COULD HAVE BEEN KILLED IF THIS HAPPENED AT HIGHER SPEED. WE HAVE CONSTANTLY SPENT MONEY ON THIS VEHICLE…
Read full complaint
LEAVING A PARKING LOT AND HEARD LOUD SOUND CAR WOULDN'T MOVE. VOLVO SAYS THE FOLLOWING IS BROKEN: LOWER CONTROL ARM, CV AXLE, ROTOR AND DAMAGED RIM. WE HAD BEEN PARKED AND WERE ATTEMPTING TO LEAVING PARKING LOT(.BARELY MOVING) COULD HAVE BEEN KILLED IF THIS HAPPENED AT HIGHER SPEED. WE HAVE CONSTANTLY SPENT MONEY ON THIS VEHICLE AND I FEEL IT IS UNSAFE AND THAT WHEN THE RECALLS WERE MADE THERE COULD HAVE ALREADY BEEN A FRACTURE. THIS CAR IS ONLY DRIVEN TO WORK AND HOME ON A REGULAR BASIS. NO ROUGH ROADS. WE HAVE NOT CAUSED ANY DAMAGE. THIS WEBSITE DOES NOT ALLOW PROPER SELECTION UNDER VOLVO AND MAKE TO ALLOW SELECTION OF THE SUSPENSION/CONTROL ARM / ROTORS / AXLE / TIRE RIMS / BALL JOINT, ALL OF WHICH WERE DAMAGED IN THIS 4 MPH ACCIDENT. HAD THIS HAPPENED AT 65 MPH I HAVE NO DOUBT ME AND MY FAMILY WOULD NOT HAVE SURVIVED. *TR
NHTSA ODI #10352913
104,000 miles · Apr 18, 2010
Engine And Engine CoolingEquipmentFuel System, Gasoline
MY 2003 VOLVO XC90 HAS BEEN TO THE DEALER SEVERAL TIMES INCLUDING OVER 3 TIMES FOR SAME PROBLEM WHEN I PURCHASED THE VEHICLE IN 2006. ALL RECALLS HAVE BEEN FIXED, FRONT AXLE, WIPERS ETC. I HAVE PURCHASED 4 SETS OF TIRES, TIRES BOSTON VOLVO INSTALLED AND MY 17 YEAR OLD SON RECEIVED A COMPLETE BLOW OUT BECAUSE WRONG SIZE TIRES. I …
Read full complaint
MY 2003 VOLVO XC90 HAS BEEN TO THE DEALER SEVERAL TIMES INCLUDING OVER 3 TIMES FOR SAME PROBLEM WHEN I PURCHASED THE VEHICLE IN 2006. ALL RECALLS HAVE BEEN FIXED, FRONT AXLE, WIPERS ETC. I HAVE PURCHASED 4 SETS OF TIRES, TIRES BOSTON VOLVO INSTALLED AND MY 17 YEAR OLD SON RECEIVED A COMPLETE BLOW OUT BECAUSE WRONG SIZE TIRES. I CONTINUE TAKING TO SAME DEALER AND SINCE OWNING THE CAR HAVE HAD THE SAME NOISES IN FRONT OF CAR. BOSTON VOLVO HAS STATED IN OCTOBER AND SINCE OWNING THE VEHICLE CAN FIND NOTHING WRONG, APRIL DIAGNOSED WITH NEED NEW DRIVE SHAFT AFTER HAVING CAR FOR 2 DAYS BUT COULD NOT REALLY FINE ANYTHING BUT DRIVE SHAFT. A STRONG FUEL SMELL STATED FUEL PUMP DOES NOT NEED TO BE CORRECTED. I NEED NEW MUFFLER AND TAKING TO MY OWN MECHANIC THE REAL ISSUE IS TRANSMISSION SERVICE URGENT AND NEED NEW TRANSMISSION. VOLVO DID NOT DIAGNOSE THIS PROBLEM AND MY SON IS DRIVING THE CAR! MY SON IS DRIVING A LEMON THAT IS A DANGER TO HIMSELF. TAKING TO VOLVO DOES NOTHING, THEY CANNOT EVEN DIAGNOSE AND GIVE WRONG INFO GIVEN TO ME. I AM CURRENTLY UP TO OVER $8,000 IN DAMAGES AND STILL OWE ON THIS LEMON. I NEED NEW TRANSMISSION, MUFFLER, STILL CAR VIBRATES AND FRONT END NOISES FROM WHINING, THUMPING ETC. *TR
NHTSA ODI #10326221
Mileage unknown · Jan 21, 2010
Equipment
2003 VOLVO XC90 SPARE TIRE PROBLEM. *NJ THE CONSUMER STATED WHILE DRIVING ON A SECONDARY ROAD, THE SPARE TIRE FELL FROM UNDERNEATH THE VEHICLE. THE SPARE TIRE HAD NEVER BEEN REMOVED. THE CAUSE OF THE PROBLEM WAS DETERMINED TO BE A FRAYED CABLE THAT BROKE WHICH HELD THE SPARE TIRE TIGHT AGAINST THE BOTTOM OF THE VEHICLE. *JB
NHTSA ODI #10300568
15,090 miles · Nov 30, 2004
Electrical SystemEquipmentSeats
THE CONSUMER PURCHASED NEW TIRES BECAUSE OF EXTREME WEAR AT LOW MILEAGE. THE 2003 VOLVO XC90 HAD NUMEROUS PROBLEMS THAT HAD TO BE CORRECTED ON A REGULAR BASIS. *BF THE LUG NUTS WERE REPLACED TWICE DUE TO RUST WHEN THE VEHICLE WAS DELIVERED, UNABLE TO TURN THE IGNITION, RADIO WAS INOPERATIVE AND THE LEFT DOOR COULD NOT BE OP…
Read full complaint
THE CONSUMER PURCHASED NEW TIRES BECAUSE OF EXTREME WEAR AT LOW MILEAGE. THE 2003 VOLVO XC90 HAD NUMEROUS PROBLEMS THAT HAD TO BE CORRECTED ON A REGULAR BASIS. *BF THE LUG NUTS WERE REPLACED TWICE DUE TO RUST WHEN THE VEHICLE WAS DELIVERED, UNABLE TO TURN THE IGNITION, RADIO WAS INOPERATIVE AND THE LEFT DOOR COULD NOT BE OPENED DUE TO THE PROBLEM WITH THE SEAT MOLDING. AFTER 15K PLUS MILES, THE TIRES HAD WORN SMOOTH TO THE CORD. (TIRE-PERRILLI SCORPION) *SC
NHTSA ODI #10103496
15,000 miles · Oct 18, 2004
Electrical SystemEquipmentSeats
MULTIPLE FAILURES; DOOR LOCK,TIRES WERE WORN TO THE CORD. * BF THE LUG NUTS WERE REPLACED BECAUSE THEY WERE RUSTED WHEN THE VEHICLE WAS DELIVERED, THE DOORS DID NOT FIT PROPERLY, THE RADIO FAILED, THE KEY WOULD NOT TURN IN THE IGNITION, THE LEFT REAR DOOR COULD NOT BE OPENED DUE TO THE PROBLEM WITH THE SEAT MOLDING AND THE TI…
Read full complaint
MULTIPLE FAILURES; DOOR LOCK,TIRES WERE WORN TO THE CORD. * BF THE LUG NUTS WERE REPLACED BECAUSE THEY WERE RUSTED WHEN THE VEHICLE WAS DELIVERED, THE DOORS DID NOT FIT PROPERLY, THE RADIO FAILED, THE KEY WOULD NOT TURN IN THE IGNITION, THE LEFT REAR DOOR COULD NOT BE OPENED DUE TO THE PROBLEM WITH THE SEAT MOLDING AND THE TIRE DISPLAYED UNUSUAL WEAR AND WERE WORN SMOOTH TO THE CORD. THE LUG NUTS THAT WERE INSTALLED RUSTED AGAIN. (TIRES/PERRILLI SCORPIAN) *SC *JB
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Consequence & remedy
Consequence: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Consequence & remedy
Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
ON CERTAIN SPORT UTILITY VEHICLES, THE SEAT BELT ATTACHMENT(S) FOR THE SECOND AND THIRD ROW SEAT(S) MAY NOT HAVE BEEN FITTED PROPERLY.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT AND REPAIR THE SECOND AND/OR THIRD ROW SEAT BELT ATTACHMENTS. OWNER NOTIFICATION BEGAN ON DECEMBER 8, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2003 Volvo XC90 Problems, Complaints & Recalls | Skip That Year
Illustration