IllustrationINSTRUMENT CLUSTER GOES BLACK IF TURN CAR OFF COMES BACK ON. MESSAGE CENTER SAY SRS AIR BAG FAILURE. *TR
2003 Volvo XC90
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Volvo XC90 do not stand out strongly from the model-year median of 34.
About this comparison →How this year compares
Owner complaints by model year
Compare all XC90 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
100–25K
1025–50K
2050–75K
1575–100K
20100–150K
4150K+
79 reports with mileage · 14 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports2 fire reports4 injury reports
Air Bags complaints
4 reportsTHE SRS LIGHT CAME ON, WHICH APPEARS TO BE A COMMON PROBLEM WITH MY MODEL. THE DEALER SAID THEY NEED TO REPLACE THE ENTIRE SRS CONSOLE FOR $1000. THEY CANNOT GUARANTEE IT, BUT IT'S POSSIBLE MY AIRBAGS WILL NOT DEPLOY IF THEY DO NOT REPLACE THIS. *TR
OPERATING VEHICLE SINCE OCT '08, SINCE THAT TIME THERE HAS BEEN A NOISE EMANATING FROM FRONT PASS-SIDE WHEEL AREA. PURCHASING DEALER(HALL CHEVY, CHESAPEAKE, VA) PERFORMED WHEEL-ALIGNMENT TO "FIX" THE NOISE WHICH DID NOT REMEDY. VOLVO DEALER IN ARVADA, CO DIAGNOSED IT AS FAILED, OR FAILING WHEEL HUB, TO BE REPLACED AT COST OF $…
Read full complaint
OPERATING VEHICLE SINCE OCT '08, SINCE THAT TIME THERE HAS BEEN A NOISE EMANATING FROM FRONT PASS-SIDE WHEEL AREA. PURCHASING DEALER(HALL CHEVY, CHESAPEAKE, VA) PERFORMED WHEEL-ALIGNMENT TO "FIX" THE NOISE WHICH DID NOT REMEDY. VOLVO DEALER IN ARVADA, CO DIAGNOSED IT AS FAILED, OR FAILING WHEEL HUB, TO BE REPLACED AT COST OF $500. THIS VEHICLE ALSO HAD TRANS FAILURE AT APPX 76K MILES, AND THROTTLE CONTROL MODULE FAILURE IN OCT '09. I BELIEVE THERE ARE MANY CONCERNS ABOUT OPERATING AND HAVING CONFIDENCE IN ITS ABILITY TO OPERATE "SAFELY AND RELIABLY" THE VEHICLE HAS BEEN IN THE SHOP NEARLY AS MUCH AS ON-THE-ROAD SINCE IT'S I PURCHASED IT IN OCT '08. *TR
WHILE BACKING PUT OF A PARKING LOT POWER STEERING FAILED, VEHICLE SMOKED THEN CAUGHT ON FIRE. DRIVER SUFFERED FROM SMOKE INHALATION. *AK PRIOR TO THE VEHICLE CATCHING ON FIRE THE CONSUMER WAS INVOLVED IN AN ACCIDENT THE YEAR BEFORE (JULY 12, 2003). THE CONSUMER WAS PRESSING ON THE HORN WHEN THE CRASH OCCURRED. THE CONSUMERS …
Read full complaint
WHILE BACKING PUT OF A PARKING LOT POWER STEERING FAILED, VEHICLE SMOKED THEN CAUGHT ON FIRE. DRIVER SUFFERED FROM SMOKE INHALATION. *AK PRIOR TO THE VEHICLE CATCHING ON FIRE THE CONSUMER WAS INVOLVED IN AN ACCIDENT THE YEAR BEFORE (JULY 12, 2003). THE CONSUMER WAS PRESSING ON THE HORN WHEN THE CRASH OCCURRED. THE CONSUMERS HAND WAS ON THE WHEN THE AIR BAG DEPLOYED. THE DRIVER SUSTAINED SEVERAL BROKEN ONES IN HER RIGHT HAND WHICH REQUIRED 2 SURGERIES, EXTENSIVE PHYSICAL THERAPY AND MANY OTHER MEDICAL PROCEDURES. *NM *LA
Official recalls
510V566000 · Equipment:electrical:navigational System(global Positioning System)
Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
09V483000 · Fuel System, Gasoline:delivery:fuel Pump
Dec 18, 2009
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
06V155000 · Steering:linkages:tie Rod Assembly
May 5, 2006
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Consequence & remedy
Consequence: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
06V144000 · Visibility:windshield Wiper/washer
Apr 28, 2006
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Consequence & remedy
Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
03V391000 · Seat Belts:rear/other
Oct 10, 2003
ON CERTAIN SPORT UTILITY VEHICLES, THE SEAT BELT ATTACHMENT(S) FOR THE SECOND AND THIRD ROW SEAT(S) MAY NOT HAVE BEEN FITTED PROPERLY.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT AND REPAIR THE SECOND AND/OR THIRD ROW SEAT BELT ATTACHMENTS. OWNER NOTIFICATION BEGAN ON DECEMBER 8, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.