IllustrationVEHICLE EXPERIENCED PREMATURE STEER TIRE WEAR.*AK *JB
1997 Volvo Wia
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Wia years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 8 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
8 reportsCONSUMER STATED WHILE DRIVING, THE TRUCK STARTED TO PULL VERY HARD TO THE LEFT AND CONSUMER HAD A VERY DIFFICULT TIME STOPPING THE TRUCK, ONCE THE TRUCK WAS UNDER CONTROL, CONSUMER GOT OUT AND NOTICED THAT THE RIGHT STEER TIRE WAS WORN DOWN TO THE VERY OUTSIDE EDGE TO THE THREAD, ON A SEPARATE OCCASION THE FRONT END OF THE TRUCK…
Read full complaint
CONSUMER STATED WHILE DRIVING, THE TRUCK STARTED TO PULL VERY HARD TO THE LEFT AND CONSUMER HAD A VERY DIFFICULT TIME STOPPING THE TRUCK, ONCE THE TRUCK WAS UNDER CONTROL, CONSUMER GOT OUT AND NOTICED THAT THE RIGHT STEER TIRE WAS WORN DOWN TO THE VERY OUTSIDE EDGE TO THE THREAD, ON A SEPARATE OCCASION THE FRONT END OF THE TRUCK WAS VIBRATING SO BAD THAT THE CONSUMER HAD TO PULL OVER, CONSUMER STATED THAT IN FEBUARY 1998 THE REAR SUSPENSION WAS REBUILT.*JB
CONSUMER COMPLAINS OF REPLACING HIS 6TH SET OF STEER TIRES. *JG
THERE IS CONSTANT SHAKING IN FRONT END OF VEHICLE AND IN STEERING WHEEL, AT ANY SPEED. DEALER HAS REPLACED TIRES AND ALIGNED VEHICLE. DID NOT REMEDY THE PROBLEM. NLM CONSUMER ADDS THAT THE VEHICLE IS STILL SHAKING VIOLENTLY. *TT
TRANSMISSION JUMPS OUT OF GEAR UNDER A LOAD ,THIS TRANSMISSION WAS REBUILT NOV 2000 FOR THIS PROBLUM. IT STARTED AGAIN IN NOV.2001. OTHER OWNERS OF THIS TYPE TRANSMISSION TELL ME THEY HAVE THE SAME PROBLUM. THERE IS NOTHING AS DANGEROUS AS A TRUCK GEARING DOWN ON A HILL , AND HAVING THE TRANSMISSION JUMP OUT OF GEAR. THANK YOU …
Read full complaint
TRANSMISSION JUMPS OUT OF GEAR UNDER A LOAD ,THIS TRANSMISSION WAS REBUILT NOV 2000 FOR THIS PROBLUM. IT STARTED AGAIN IN NOV.2001. OTHER OWNERS OF THIS TYPE TRANSMISSION TELL ME THEY HAVE THE SAME PROBLUM. THERE IS NOTHING AS DANGEROUS AS A TRUCK GEARING DOWN ON A HILL , AND HAVING THE TRANSMISSION JUMP OUT OF GEAR. THANK YOU FOR YOUR TIME.*AK
CONSUMER STATES VEHICLE HAD A WIRING HARNESS PROBLEM UNDER THE DASH. (VOLVO TRUCK 64TWIA)*YH
WHEN DRIVING AT ANY SPEED, THERE IS VIBRATION WITHIN THE FRAME, TIRE IS WORN OUT. VECHICLE ISN'T STAYING ON TRACK, IT KEEPS GOING INTO OTHER LANES. ALSO, FRAME IS BENT. *AK THE CONSUMER POINTS OUT THAT THE APPEAL FORUM IS HELPFUL BUT THERE SHOULD BE A METHOD FOR CONSUMERS TO REACH THE MANUFACTURERS EASILY. *YH CONSUMER STAT…
Read full complaint
WHEN DRIVING AT ANY SPEED, THERE IS VIBRATION WITHIN THE FRAME, TIRE IS WORN OUT. VECHICLE ISN'T STAYING ON TRACK, IT KEEPS GOING INTO OTHER LANES. ALSO, FRAME IS BENT. *AK THE CONSUMER POINTS OUT THAT THE APPEAL FORUM IS HELPFUL BUT THERE SHOULD BE A METHOD FOR CONSUMERS TO REACH THE MANUFACTURERS EASILY. *YH CONSUMER STATES THE PROBLEM IS PROXIMATE TO THE CROSS MEMBERS WITHIN THE FRAME RAILS, THEY ARE OF INSUFFICIENT STRENGTH TO KEEP THE FRAME RAILS WITHIN ACCEPTABLE FLEXIBILITY PARAMETERS, THIS CAUSES A TEMPORARY BREECH IN THE CONTACT POINTS BETWEEN THE FRAME AND THE FORWARD DRIVE AXLE, THIS RESULTS IN THE FORWARD DRIVE AXLE BECOMING MISALIGNED WHEN CLOSED AND CAUSES A THRUST PROBLEM TO THE STEER AXLE AS THE FORWARD DRIVE IS NOW PUSHING IT AT AN ANGLE TO A FORWARD STRAIGHT LINE, THERE IS STRESS ON REAR SUSPENSION ASSEMBLY, THE NET RESULT IS COMPONENT BREAKAGE, PREMATURE WEAR, AND A TRUCK THAT DRIFTS AND WANDERS, VOLVO REPLACED THE REAR SUSPENSION, FRONT BUSHINGS, STRAIGHTEN FRAME, AND THEY ALSO BENT THE STEER AXLE AND ATTEMPTED TO PUSH IT FURTHER BACK THUS NECESSATING THAT THEY BENT THE STEERING ROD. *SLC
WHEN APPLYING THE BRAKE THERE IS A VIBRATION IN THE WHOLE TRUCK .
Official recalls
602V238000 · Exterior Lighting:tail Lights:switch
Sep 9, 2002
CERTAIN HEAVY DUTY CLASS 8 TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE TWO TAIL LAMPS, BACK-UP LAMP,AND LICENSE TAG LAMP WERE MOUNTED ON INSUFFICIENTLY RIGID MOUNTS.
Consequence & remedy
Consequence: IT MAY NOT ALLOW THE DRIVER OF A REARWARD APPROACHING VEHICLE TO HAVE FULL VIEW OF THE LAMPS.
Remedy: DEALERS WILL ATTACH THE TWO TAIL LAMPS, BACK-UP LAMP, AND THE LICENSE TAP LAMP ON STIFFER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 31, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
00V002002 · Parking Brake
Feb 24, 2000
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH HALDEX MANIFOLD DASH VALVES (MDV) USED IN TRACTOR AND TRAILER PARKING BRAKES. THESE VALVES DO NOT MEET THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." A LOSS OF THE ISOLATION OF THE TWO BRAKE SYSTEM CIRCUITS CAN RESULT IN THE LOSS OF SERVICE BRAKES WHEN THERE IS ANOTHER FAILURE OF ONE OF THE TWO BRAKE CIRCUITS.
Consequence & remedy
Consequence: THE LOSS OF SERVICE BRAKES CAN OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SUSPECT VALVES.
98V255000 · Suspension:front:springs:air Suspension:lines And Fittings
Oct 14, 1998
VEHICLE DESCRIPTION: CLASS 8 HEAVY DUTY TRUCKS. THE AIR SUSPENSION CONTROL VALVE SUPPLY LINE WAS NOT PLUMBED THROUGH AN AIR PRESSURE PROTECTION VALVE. IN THE EVENT OF A FAILURE, THERE WOULD BE LOSS OF AIR PRESSURE IN THE 'B' SYSTEM AIR RESERVOIR THAT SUPPLIES AIR PRESSURE FOR THE FRONT STEER AXLE BRAKES.
Consequence & remedy
Consequence: THIS CONDITION WOULD RESULT IN INCREASED STOPPING DISTANCES.
Remedy: DEALERS WILL INSTALL THE NECESSARY AIR PRESSURE PROTECTION VALVE.
98V120001 · Wheels:rim
May 19, 1998
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH AFTERMARKET ALUMINUM DUAL WHEELS, 22.5X8.25, ONE-PIECE, TUBELESS, SUPPLIED BY ACCURIDE/AKW. CERTAIN DESIGN REVISIONS COMBINED WITH PROCESS CONDITIONS CAUSED FATIGUE CRACKS IN THESE WHEELS.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE FAILURE OF THESE WHEELS.
Remedy: ACCURIDE/AKW WILL REPLACE THESE WHEELS.
97V212000 · Suspension:front:wheel Bearing
Nov 17, 1997
VEHICLE DESCRIPTION: CLASS 8 HEAVY DUTY TRUCKS. THE STEER AXLE WHEEL BEARING JAM NUT LOCK WASHER MAY NOT HAVE BEEN BENT OVER THE JAM NUT AFTER THE WHEEL BEARINGS WERE ADJUSTED.
Consequence & remedy
Consequence: IF THIS CONDITION EXISTS, THE JAM NUT AND WHEEL BEARING ADJUSTING NUT CAN BACK OFF THE SPINDLE ALLOWING THE WHEEL AND THE BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING AXLE WHEEL BEARING JAM NUT LOCK WASHER TO DETERMINE IF IT IS BENT OVER THE JAM NUT, AND IF NOT, REPAIR AS REQUIRED.
97V023000 · Structure:body
Feb 24, 1997
WARNING LABELS IDENTIFYING THE CLIMBING SEQUENCE AND PROCESS WERE OMITTED.
Consequence & remedy
Consequence: PERSONS NOT USING THE SEQUENCE AND PROCESS DURING CAB ENTRY OR EXIT OR WHEN USING THE OPTIONAL BACK OF CAB ACCESS MAY SLIP AND/OR FALL CAUSING PERSONAL INJURY.
Remedy: VOLVO HEAVY TRUCK WILL BE PROVIDING WARNING LABELS TO BE INSTALLED BY OWNERS ON THEIR TRUCKS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP01004 · Frame Bending
Opened Sep 26, 2001 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Suspension
No summary supplied.