Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 2 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
2 reports
Mileage unknown · Feb 25, 2011
Structure
OWNER CALLED INTO ODI AND REPORTED THAT HIS MY 2008 VOLVO 780 WAS CRACKED AT WELDS IN THE FRAME. VEHICLE BOUIGHT USED FROM ADVANTAGE VOLVO-GMC IN CHARLOTTE, NC IN NOVMEBR 2010 AND USED IN LINE HAUL SERVICE. OWNER DESCRIBED WELDING ONTHE "TOP FACE" AREA OF THE FRAME. [ODI NOTE; MOST TRUCKS FRAMES ARE HEAT TREATED AND NO WELDIN…
Read full complaint
OWNER CALLED INTO ODI AND REPORTED THAT HIS MY 2008 VOLVO 780 WAS CRACKED AT WELDS IN THE FRAME. VEHICLE BOUIGHT USED FROM ADVANTAGE VOLVO-GMC IN CHARLOTTE, NC IN NOVMEBR 2010 AND USED IN LINE HAUL SERVICE. OWNER DESCRIBED WELDING ONTHE "TOP FACE" AREA OF THE FRAME. [ODI NOTE; MOST TRUCKS FRAMES ARE HEAT TREATED AND NO WELDING PERMITTED; REQUESTED OWNER TO PROVIDE PHOTOGRAPHS - GTB.]
NHTSA ODI #10385268
Mileage unknown · Jan 5, 2011
Engine And Engine Cooling
EXHAUST LEAKS INTO CAB WHILE DRIVING. THIS HAS BEEN AN ONGOING CONCERN SINCE OWNING THE TRACTOR. IT HAS BEEN IN THE SHOP AT LEAST 10 TIMES WITH CONTINUAL LEAKS WITHIN WEEKS TO MONTHS AT A TIME. MY WIFE AN I DRIVE TANDEM AND HAVE HAD A LOT OF SINUS PROBLEMS AS A RESULT OF DIESEL EXHAUST. IT MAKES MY WIFE SICK TO HER STOMACH.
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 210, "Seat Belt Assembly Anchorages."
Consequence & remedy
Consequence: In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant. This increases the risk of injury to the seat occupant.
Remedy: Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
VOLVO TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 AND 2009 VHD, MODEL YEAR 2006 THROUGH 2010 VN, AND MODEL YEAR 2007 THROUGH 2009 VT TRUCKS MANUFACTURED FROM NOVEMBER 7, 2005, THROUGH OCTOBER 30, 2009, EQUIPPED WITH AN AIR RELEASE FIFTH WHEEL. THE INVERSION VALVE ON THE FRAME MAY BE ORIENTATED WHERE CONTAMINANTS CAN ENTER THE VALVE THROUGH THE EXHAUST PORT. AS A RESULT, THE BRAKE VALVE MAY CORRODE.
Consequence & remedy
Consequence: CORROSION OF THE VALVE CAN CAUSE IT TO MALFUNCTION, THEREBY ADVERSELY AFFECTING BRAKING PERFORMANCE AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE INVERSION VALVE AND REPLACE AS REQUIRED. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 18, 2011. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
RQ11001 · Volvo Sleeper Glass de-bonding
Opened May 23, 2011 · Closed Jan 20, 2012
Status: closed (inferred from source dates) · Visibility:glass, Side/rear
ODI opened Recall Query RQ11-001 after a review of EWR Field Reports identified lower bunk window separations on the subject vehicles.Volvo had issued three recalls for sleeper window separations since 2003.Additionally, Volvo had issued two bulletins for sleeper window issues during the same time period.The frequency of related actions led ODI to open this formal investigation.An Information Request (IR) letter was sent to Volvo on 23 June 2011.Volvo responded on 17 August 2011 and then provided updated warranty information on 9 January 2012.Volvo provided production change data and warranty information which was correlated to vehicle build month and failure date.ODI analyzed the data to determine if additional production time frames should have been included in previous recalls.ODI also requested information from its network of fleet owners.The response from this network reaffirmed the accuracy of the updated warranty information.Based on the information and data received, ODI has concluded that all production periods have been appropriately addressed by Volvo's previous recalls and no additional recall action is required at this time.
2008 Volvo Vn Problems, Complaints & Recalls | Skip That Year
Illustration