Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
2125–50K
4750–75K
4475–100K
29100–150K
15150K+
162 reports with mileage · 59 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Vehicle Speed Control. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports2 fire reports7 injury reports
What owners actually said
221 reports
128,000 miles · May 2, 2014
Fuel System, GasolinePower TrainVehicle Speed Control
I STARTED THE CAR, PLACED THE CAR IN DRIVE GEAR AND IDLED THROUGH THE PARKING LOT TRAFFIC TO THE INTERSECTION BUT THE CAR WOULD NOT ACCELERATE THROUGH THE INTERSECTION THOUGH THE CONDITION RESTORED AFTER I PULLED OVER AND TURNED OFF THE IGNITION AND RESTARTED IT. THEN THE ACCELERATOR FUNCTIONED NORMALLY.HAD A SEMI TRUCK BEEN CO…
Read full complaint
I STARTED THE CAR, PLACED THE CAR IN DRIVE GEAR AND IDLED THROUGH THE PARKING LOT TRAFFIC TO THE INTERSECTION BUT THE CAR WOULD NOT ACCELERATE THROUGH THE INTERSECTION THOUGH THE CONDITION RESTORED AFTER I PULLED OVER AND TURNED OFF THE IGNITION AND RESTARTED IT. THEN THE ACCELERATOR FUNCTIONED NORMALLY.HAD A SEMI TRUCK BEEN COMING ALONG, I WOULD NOT BE HERE TO WRITE YOU THIS LETTER. *TR
NHTSA ODI #10586226
206,450 miles · Feb 27, 2014
Fuel System, Gasoline
I BEGAN TO NOTICE A FUEL SMELL AND DRIP MARKS UNDER THE VEHICLE AFTER PARKING THE VEHICLE IN THE GARAGE IN THE EVENING. UPON INVESTIGATION, I NOTED FUEL DRIPS ON THE UNDERBODY OF THE VEHICLE IN AN AREA SLIGHTLY IN FRONT OF THE FUEL TANK AND A DEVELOPING FUEL PUDDLE IMMEDIATELY UNDER THE VEHICLE. FOLLOWING AN INSPECTION AT THE VO…
Read full complaint
I BEGAN TO NOTICE A FUEL SMELL AND DRIP MARKS UNDER THE VEHICLE AFTER PARKING THE VEHICLE IN THE GARAGE IN THE EVENING. UPON INVESTIGATION, I NOTED FUEL DRIPS ON THE UNDERBODY OF THE VEHICLE IN AN AREA SLIGHTLY IN FRONT OF THE FUEL TANK AND A DEVELOPING FUEL PUDDLE IMMEDIATELY UNDER THE VEHICLE. FOLLOWING AN INSPECTION AT THE VOLVO DEALER, IT WAS DETERMINED THAT THE ELECTRIC FUEL PUMP WAS LEAKING FUEL. IT WAS EXPLAINED TO ME THAT THE FUEL PUMP HOUSING WAS CRACKED AND LEAKING FUEL AT AN UNSAFE CONDITION. I WAS ADVISED TO REPLACE THE PUMP IMMEDIATELY DUE TO THE HIGH LEVEL OF FUEL LEAKAGE. I WAS ALSO ADVISED THAT THE FUEL TANK SENDING PUMP WAS ALSO DEFECTIVE AND REQUIRED IMMEDIATE REPLACEMENT.
NHTSA ODI #10567240
206,450 miles · Dec 29, 2013
Fuel/propulsion System
I BEGAN TO NOTICE A FUEL SMELL AND DRIP MARKS UNDER THE VEHICLE AFTER PARKING THE VEHICLE AFTER DRIVING INTO THE GARAGE IN THE EVENING. UPON INVESTIGATION, I NOTED FUEL DRIPS ON THE UNDERBODY OF THE VEHICLE IN THE AREA SLIGHTLY IN THE FRONT OF THE FUEL TANK. I ALSO NOTICED THE DEVELOPMENT OF A FUEL PUDDLE IMMEDIATELY UNDER THE V…
Read full complaint
I BEGAN TO NOTICE A FUEL SMELL AND DRIP MARKS UNDER THE VEHICLE AFTER PARKING THE VEHICLE AFTER DRIVING INTO THE GARAGE IN THE EVENING. UPON INVESTIGATION, I NOTED FUEL DRIPS ON THE UNDERBODY OF THE VEHICLE IN THE AREA SLIGHTLY IN THE FRONT OF THE FUEL TANK. I ALSO NOTICED THE DEVELOPMENT OF A FUEL PUDDLE IMMEDIATELY UNDER THE VEHICLE IN THAT LOCATION. I IMMEDIATELY CONTACTED THE VOLVO DEALER FOR SERVICING. ONCE AT THE DEALER, IT WAS DETERMINED THAT THE ELECTRIC FUEL PUMP WAS LEAKING FUEL. IT WAS EXPLAINED TO ME THAT THE FUEL PUMP HOUSING WAS CRACKED AND LEAKING FUEL AT AN UNSAFE CONDITION. I WAS ADVISED TO REPLACE THE PUMP IMMEDIATELY DUE TO THE HIGH LEVEL OF FUEL LEAKAGE. I WAS ALSO ADVISED THAT THE FUEL TANK SENDING PUMP WAS ALSO DEFECTIVE AND REQUIRED IMMEDIATE REPLACEMENT. THE VOLVO DEALER, JENKINS IMPORTS, REPLACED THE DEFECTIVE UNITS ON 22 OCTOBER 2013. I HAVE RETAINED THE DEFECTIVE PARTS. *TR
NHTSA ODI #10557644
127,000 miles · Sep 4, 2013
Power Train
TRANSMISSION SHIFTS WITH A CLUNK INTO 2ND AND 3RD GEARS AS WELL AS INTO FIRST. HESITANT TO SHIFT INTO FIRST GEAR WHEN MOVING FROM A STOP. TRANSMISSION NOT SAFE!!!!
NHTSA ODI #10541842
Mileage unknown · Apr 9, 2013
Power Train
TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT STATED THAT THE TRANSMISSION SERVICE WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE ENGINE RPMS INCREASED AND THE VEHICLE SHIFTED SLOWLY, GOING THROUGH EVERY GEAR. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE TRANSMISSION NEEDED TO REPLACE. THE WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT STATED THAT THE TRANSMISSION SERVICE WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE ENGINE RPMS INCREASED AND THE VEHICLE SHIFTED SLOWLY, GOING THROUGH EVERY GEAR. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE TRANSMISSION NEEDED TO REPLACE. THE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS 113,448 AND THE FAILURE MILEAGE WAS UNKNOWN. *TR
NHTSA ODI #10505612
92,500 miles · Jan 3, 2013
Fuel/propulsion System
THE GAS TANK PUMP AND SEALS HAVE BEGUN LEAKING GAS DUE TO CRACKS IN THE PLASTIC AND SEALS. GAS LEAKS DOWN THE SIDE OF THE GAS TANK ONTO THE GROUND AND THERE ARE GAS FUMES IN THE CAR. *TR
NHTSA ODI #10490861
135,000 miles · Jul 17, 2012
Power Train
TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT STATED THAT WHILE BRAKING TO A STOP, THE VEHICLE ERRONEOUSLY SHIFTED INTO NEUTRAL AND THEN RETURNED TO DRIVE INDEPENDENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER STATED THAT THEY NEEDED TO REPLACE THE TRANSMISSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFA…
Read full complaint
TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT STATED THAT WHILE BRAKING TO A STOP, THE VEHICLE ERRONEOUSLY SHIFTED INTO NEUTRAL AND THEN RETURNED TO DRIVE INDEPENDENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER STATED THAT THEY NEEDED TO REPLACE THE TRANSMISSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 135,000 AND THE CURRENT MILEAGE WAS 178,000.
NHTSA ODI #10465992
171,000 miles · Jul 3, 2012
Visibility/wiperInjury
TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT STATED THAT THE AUTOMATIC WINDOW WOULD NOT AUTOMATICALLY STOP WHEN ACTIVATED. AS A RESULT, THE WINDOW CLOSED ON A PASSENGER'S FINGER. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT A…
Read full complaint
TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT STATED THAT THE AUTOMATIC WINDOW WOULD NOT AUTOMATICALLY STOP WHEN ACTIVATED. AS A RESULT, THE WINDOW CLOSED ON A PASSENGER'S FINGER. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 171,000.
NHTSA ODI #10464150
170,000 miles · Jun 20, 2012
Power Train
TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE TRANSMISSION FAILED. THE TRANSMISSION SERVICE REQUIRED LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THEY INFORMED THE CONTACT THAT THE TRANSMISSION NEEDED REPLACING. THE VEHICLE WAS REPA…
Read full complaint
TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE TRANSMISSION FAILED. THE TRANSMISSION SERVICE REQUIRED LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THEY INFORMED THE CONTACT THAT THE TRANSMISSION NEEDED REPLACING. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 170,000.
NHTSA ODI #10462385
167,000 miles · Jun 4, 2012
Suspension
I OWN A 2001 VOLVO XC AND BOUGHT THIS CAR FOR ITS RELIABILITY AND AS A FAMILY VEHICLE. I USE THIS VEHICLE TO COMMUTE 150 MILES PER DAY FOR MY JOB. DROVE THE CAR ON JUNE 3, 2012 WITH MY SON TO RUN ERRANDS AND THERE WERE NO PROBLEMS. THE NEXT DAY, JUNE 4, 2012 I GOT IN THE CAR TO GO TO WORK IN THE MORNING. THE MINUTE I STARTED…
Read full complaint
I OWN A 2001 VOLVO XC AND BOUGHT THIS CAR FOR ITS RELIABILITY AND AS A FAMILY VEHICLE. I USE THIS VEHICLE TO COMMUTE 150 MILES PER DAY FOR MY JOB. DROVE THE CAR ON JUNE 3, 2012 WITH MY SON TO RUN ERRANDS AND THERE WERE NO PROBLEMS. THE NEXT DAY, JUNE 4, 2012 I GOT IN THE CAR TO GO TO WORK IN THE MORNING. THE MINUTE I STARTED PULLING OUT OF THE DRIVEWAY I HEARD A NOISE COMING FROM THE CAR. I GOT MY HUSBAND AND HAD HIM LOOK AT THE CAR SINCE IT WAS FINE THE DAY BEFORE. HE DISCOVERED THE BROKEN SPRING. LUCKILY THE SPRING BROKE OVERNIGHT WHILE IT WAS SITTING IN THE DRIVEWAY AND NOT WHILE I WAS DRIVING IT ON THE HIGHWAY. WE HAVE DONE RESEARCH ON THIS PART BREAKING AND FOUND NUMEROUS OTHER VOLVO OWNERS WHO HAVE ALSO HAD THIS PART BREAK. *TR
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2001-2007 V70 and XC70 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed December 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10136.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2001-2007 V70 and XC70 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed December 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10136.
Air Bags:frontal
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2001-2007 V70 and XC70 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed December 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10136.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRECT.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL RECEIVE A LETTER/PACKAGE CONSISTING OF THE SECOND ISOFIX GUIDE WITH INSTALLATION INSTRUCTIONS, AND IN CERTAIN CASES, THE CORRECTED OWNER'S MANUAL MAY BE PROVIDED. IF THE OWNER WANTS TO TAKE THEIR VEHICLE TO A VOLVO DEALER FOR INSTALLATION OF THE GUIDE, IT WILL BE PERFORMED AT NO CHARGE TO THE OWNER. OWNER NOTIFICATION BEGAN ON DECEMBER 19, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
VEHICLE DESCRIPTION: SEDANS AND WAGONS. THE REAR OUTBOARD SEAT BELT ANCHORAGE BOLTS MAY HAVE BEEN INCORRECTLY TIGHTENED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THE ANCHORAGE BOLTS AND TIGHTEN TO THE CORRECT TORQUE LEVEL. OWNER NOTIFICATION BEGAN MAY 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
VEHICLE DESCRIPTION: WAGONS. THE BOLTED JOINT, USED FOR ATTACHING THE BRACKET THAT IS PART OF THE INSTALLATION HARDWARE FOR THE ISOFIX-TYPE CHILD RESTRAINT, MAY HAVE BEEN INCORRECTLY TIGHTENED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THE ANCHORAGE BOLTS AND TIGHTEN TO THE CORRECT TORQUE LEVEL. OWNER NOTIFICATION BEGAN MAY 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
2001 Volvo V70 Problems, Complaints & Recalls | Skip That Year
Illustration