2001 Volvo V70

TL* THE CONTACT OWNS A 2001 VOLVO V70. WHILE OPERATING THE VEHICLE, THE ODOR OF FUEL WAS PRESENT INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TOP OF THE FUEL TANK WAS LEAKING AND THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND LOCAL DEALER (MAPLE HILL VOLVO IN KALAMAZOO, MI) WERE NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED BY THE DEALER THAT THE VEHICLE WAS PREVIOUSLY INSPECTED PER NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE), BUT THE FAILURE STILL OCCURRED. THE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT STATED THAT THE KEY FOB WOULD NOT FUNCTION INTERMITTENTLY, THE DOOR LOCKS WORKED INTERMITTENTLY, AND THE TURN SIGNALS WORKED INDEPENDENTLY. ALSO, VARIOUS OTHER ELECTRICAL SYSTEMS BEGAN EXPERIENCING ISSUES. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.

TL* THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT DISCOVERED THAT FLUID WAS LEAKING FROM THE VEHICLE WHEN ANTI FREEZE WAS ADDED. IN ADDITION, WHEN THE AIR CONDITIONER WAS ACTIVATED, WARM AIR EMITTED FROM THE VENTS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE COOLING FAN NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY SERVICED PER NHTSA CAMPAIGN NUMBER: 04V451000 (ENGINE AND ENGINE COOLING) YEARS AGO. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000. THE VIN WAS NOT PROVIDED. UPDATED 09/22/16*LJ CONSUMER STATED "RECALLED PART COOLANT FAN MODULE" AGAIN BECAME DEFECTIVE. IT CAUSED DAMAGED TO THE VEHICLE, INCLUDING A RADIATOR AND COOLANT RESERVE TANK, IN ADDITION TO REPLACEMENT OF THE DEFECTIVE MODULAR/ COOLANT FAN ASSEMBLY. UPDATED 6/19/18*JB

THERE IS A KNOWN SAFETY ISSUE WITH THIS 2001 VOLVO V70 XC AWD TRANSMISSION AND IT NEEDS TO BE ADDRESSED ASAP. VOLVO AND THE NHTSA BOTH KNOW ABOUT THIS ONGOING PROBLEM AND REFUSE TO FIX THE PROBLEM. THE TRANSMISTION SLIPS BAD AND STOPS WORKING AND LOSES POWER AND THE DEALERS STATES THE COMPUTER UPDATES WILL FIX THE PROBLEM AS EVEN TOLD BYE THE DEALER ITS A KNOWN ISSUE THAT VOLVO REFUSES TO RECTIFY UNFORTUNATELY. BUT THIS IS A SAFTY ISSUE AT THIS POINT THERE ARE SO MANY COMPLAINTS AND I WANT TO KNOW WHY NOTHING IS BEING DONE AFTER ALL THESE YEARS ? I WANT A REBUILT OR NEW SAFE TRANSMISSION INSTALLED AT THE COST OF VOLVO FOR NOT FIXING THE ONGOING PROBLEMS THEY KNEW ABOUT BACK IN 2001 AND THERE COMPLETE WRONG MAINTENANCE ON THE TRANSMISSION STATING NOT TO CHANGE THE FLUID UNTIL 90K. I BELIEVE THE NHTSA HAS MANY COMPLAINTS IN REFRANCE TO THIS SAME ISSUE WHY IS NOTHING BEING DONE ?

TL* THE CONTACT OWNS A 2001 VOLVO V70. WHILE THE VEHICLE WAS AT AN INDEPENDENT MECHANIC FOR ROUTINE INSPECTION, IT WAS DISCOVERED THAT THE FUEL PUMP WAS FRACTURED AND LEAKING DUE TO DEFECTIVE MATERIAL. THE FUEL PUMP WAS REPLACED. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 106,000.

TRANSMISSION HAS HAD PROBLEMS FOR ABOUT THREE YEARS. WE WERE TRAVELING ON THE HWY AND THE CAR STARTED SHAKING, THEN STOPPED. WE HAD TO HAVE IT TOWED TO OUR MECHANIC. NEEDS NEW TRANSMISSION AND ALTERNATOR WHICH WOULD COST MORE THAN IT IS WORTH. OUR MECHANIC HAS SEEN A NUMBER OF 2001S WITH PROBLEMATIC TRANSMISSIONS. WE ARE VERY DISAPPOINTED IN VOLVO FOR NOT FIXING THIS PROBLEM. NOW THIS BEAUTIFUL CAR IS SITTING IN OUR DRIVEWAY UNUSED.

I NOTICED THE TAIL LIGHT BRAKE BULBS WERE BURNING OUT QUICKLY. AFTER GETTING A TICKET I STOPPED DRIVING IT UNTIL I COULD DETERMINE THE CAUSE. VOLVO LISTS A BRAKE RELAY RECALL. BRAKE LIGHT FUSES AND RELAYS ARE IN 4 LOCATIONS IN THE CAR. THEY ARE: 1. UNDER THE HOOD IN THE ENGINE CONTROL UNIT ECU, 2.THE PASSENGER COMPARTMENT A. CENTRAL CONTROL UNIT CCU AND B. FUSE PANEL BY DRIVERS SIDE DOOR POST 3. REAR CONTROL UNIT IN THE CARGO COMPARTMENT. THE PROBLEM WAS AN ELECTRICAL ENGINEERING DESIGN WHERE A STEEL RACE THAT SURROUNDS THE TAILLIGHT BULBS TRANSFERS THE ELECTRICAL CURRENT IS DESIGNED TO FAIL. AS THE BULB HEATS UP IT TRANSFERS THE HEAT TO THE PLATE AND PLASTIC PINS THAT HOLD IT IN PLACE UNDER PRESSURE FROM THE SPRING STEEL PARTS OF THE REMOVABLE BULB SOCKET UNIT. AS THE PLASTIC PINS WEAKEN AND MOVE AWAY UNDER PRESSURE AND HEAT FROM THE BULB SOCKET SPRING STEEL KEEPERS, AND CONDUCTORS OF VOLTAGE AND CURRENT, THE CURRENT IS THROTTLED DOWN TO A PIN POINT AS THE PLATE MOVES AWAY FROM THE BULB CREATING MORE HEAT AND ARCING TO MELT THE STEEL RACE SURROUND THE BULBS THAT SUPPLY THE CURRENT. THE REPLACED BULBS SEEM TO WORK FOR A SHORT TIME AS THE CONNECTION IS REESTABLISHED WHEN THE BULB SOCKET IS REMOVED AND REPLACED, AND THE CONNECTION IS REESTABLISHED FOR A TIME, BUT IT WILL SOON OVER HEAT AND FAIL FROM THE WEAKENED AND MELTED PLASTIC LENS. BRAKE LIGHT FAILURE RESULTS NOT FROM A FAILED PART, RELAY, FUSE OR WIRE, BUT FROM AN ENGINEERING DESIGN FLAW THAT WAS RECOGNIZED AND ELIMINATED IN THE 2005 MODELS. FORD AND VOLVO NEVER MENTION THIS. A RECALL COULD AMOUNT TO SIX HUNDRED TO A THOUSAND DOLLARS PER CAR FOR THE 4 LENSES WITH LABOR. THE ARCING IN THE WIRING MAY ALSO CAUSE OTHER COMPUTER FAILURES AS THE TRANSMISSION ALSO HAS AN ELECTRICAL PROBLEM IN THE KICKDOWN PROCESS THAT CAUSES AN ABNORMAL DELAY IN NEUTRAL GEAR AND HARD ENGAGEMENT OF THE LOWER GEAR. *TR

THE IGNITION IS SHUT OFF MOMENTARILY AS THE TRANSMISSION ATTEMPTS TO DOWNSHIFT CAUSING IT TO SLIP INTO NEUTRAL THEN ENGAGE THE LOWER GEAR HARD AS THE TRANSMISSIONS COMPUTER REESTABLISHES CONTROL. THIS ACTION IS RECORDED ON A VIDEO CAR CAMERA OPERATED BY THE IGNITIONS ON AND OFF POSITION. THE HARD SHIFTING PROBLEM THOUGHT TO BE FIXED BY SOFTWARE UPDATE MAY BE ADDRESSING THE SYMPTOM NOT THE CAUSE. ACCELERATION IS ALSO AFFECTED AT OTHER TIMES WHERE THE FOOT PEDAL IS INOPERABLE, BUT REESTABLISHED WHEN SHUTTING THE IGNITION OFF AND ON. THE DRIVE TRAIN BECOMES WOBBLY AFTER A SHORT PERIOD OF TIME AT HIGHWAY SPEEDS MAKING TRAVEL BETWEEN CITIES UNSAFE. A CLUNKING SOUND FROM THE REAR, AS BROKEN SPRING OR LOOSE BOWLING BALL MAKES, IS HEARD AT TIMES OF MILD ACCELERATION AT LOWER SPEEDS. PERHAPS A GROUNDING STRAP MY ALLEVIATE STATIC BUILDUP IN THE IGNITION SYSTEM. *JS