TL*THE CONTACT OWNS A 2000 VOLVO V70. THE CONTACT STATED THAT THE TAILGATE MECHANISIM WAS DEFECTIVE AND WOULD NOT LOCK IN COLD WEATHER. THE DEALER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 00V239000 (LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH). THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 10…
Read full complaint
TL*THE CONTACT OWNS A 2000 VOLVO V70. THE CONTACT STATED THAT THE TAILGATE MECHANISIM WAS DEFECTIVE AND WOULD NOT LOCK IN COLD WEATHER. THE DEALER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 00V239000 (LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH). THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 104,000 AND CURRENT MILEAGE WAS 104,006. UPDATED 2/23/09 *CN UPDATED 02/25/09. *JB
NHTSA ODI #10256573
40,000 miles · Dec 11, 2007
Latches/locks/linkages
1) WHEN REAR HATCH DOOR IS OPENED IN COLD WEATHER IT FAILS TO LATCH PROPERLY 2) REAR HATCH DOOR FAILS TO LATCH 3) VOLVO DEALER LUBRICATED LATCH WHICH FAILS TO SOLVE THE PROBLEM. IN ADDITION, A RECALL FOR THIS EXACT PROBLEM EXISTS, HOWEVER, MY VIN DOES NOT QUALIFY. *TR
NHTSA ODI #10211428
32,000 miles · Jul 16, 2007
Latches/locks/linkages
TL*THE CONTACT OWNS A 2000 VOLVO V70. THE CONTACT STATED THAT THE TAILGATE FAILED TO LATCH WHEN CLOSED. THE DEALER STATED THAT THE VEHICLE NEEDED A NEW LOCKING MECHANISM, BUT THAT HER VIN WAS EXCLUDED FROM RECALL # 00V239000 (LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH). THE CURRENT MILEAGE IS 82,000 AND FAILURE MILEAGE WAS 32,000.
NHTSA ODI #10196457
66,000 miles · Jun 2, 2005
Latches/locks/linkagesStructure
REAR LOCKING MECHANISM BROKE . REAR LOCKING LIGHT ILLUMINATED, AND LOCK WAS NOT LOCKING COMPLETELY. CONSUMER CONTACTED THE DEALER. HOWEVER, DEALER DID NOTHING TO ASSIST THE CONSUMER. RECALL 00V239000 CONCERNING TAILGATE LOCKING MECHANISM WAS ISSUED. *AK *SB *NM
NHTSA ODI #10119110
20,000 miles · Sep 14, 2004
Latches/locks/linkages
THE TAILGATE LOCKING MECHANISM WAS DEFECTIVE, IT WILL NOT LOCK PROPERLY. ALSO, THE INSIDE PANEL WAS FALLING OFF. CURRENTLY, MANUFACTURER ISSUED A RECALL. HOWEVER, THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. *AK RECALL#00V239000 *SC *JB
NHTSA ODI #10083243
Mileage unknown · May 13, 2002
Exterior LightingLatches/locks/linkages
PURCHASED CAR IN EARLY JANUARY 2000. PROBLEMS WITH HOOD LATCH NOT RELEASING. SERVICING OF VEHICLE THREE TIMES TO RESOLVE AND WILL INTERMITTENTLY CONTINUE. BOTH TURN SIGNALS FAILED WITHIN FIRST 6 MONTHS OF OWNING CAR. RECALL WAS IN PLACE BUT DEALER DID NOT REPLACE UNTIL UNITS FAILED. LATCH ON VEHICLE FAILED WITHIN FIRST WEEK…
Read full complaint
PURCHASED CAR IN EARLY JANUARY 2000. PROBLEMS WITH HOOD LATCH NOT RELEASING. SERVICING OF VEHICLE THREE TIMES TO RESOLVE AND WILL INTERMITTENTLY CONTINUE. BOTH TURN SIGNALS FAILED WITHIN FIRST 6 MONTHS OF OWNING CAR. RECALL WAS IN PLACE BUT DEALER DID NOT REPLACE UNTIL UNITS FAILED. LATCH ON VEHICLE FAILED WITHIN FIRST WEEK OF OWNERSHIP IN COLD WEATHER. BROUGHT INTO DEALER THREE TIMES TO RESOLVE. DID NOT KNOW AT THE TIME THIS WAS A RECALL ISSUE AND DEALER SAID NOTHING WRONG WITH IT. AFTER THIRD TIME, DEMANDED ACTION AND THEN THEY SAID, "OH, IT'S ON RECALL" AND REPLACED LATCH. PROBLEM WAS WOULD NOT WORK IN COLD WEATHER, WOULD FREEZE UP SO THE LATCH WAS EITHER STUCK WHEN CLOSED OR IF YOU OPENED UP THE REAR DOOR, IT WOULD NOT CLOSE. NEXT ITEM WAS FUEL VAPOR LEAK INTO CAR. DEALER FIXED BUT CREATED PROBLEM WITH THE FUEL GAUGE. GAUGE WOULD NOT INDICATE LESS THAN 6 GALLONS. RAN OUT OF GAS THREE TIMES BEFORE FIGURING THAT OUT. DEALER REPLACED PART/ALL OF LINE OR SENSOR IN FUEL SYSTEM.*AK
NHTSA ODI #761847
Mileage unknown · Jan 3, 2002
Latches/locks/linkages
TAILGATE DOOR WILL NOT LOCK PROPERLY, AND IN COLD WEATHER DOOR ALARM WILL GO OFF BECAUSE THE DOOR IS NOT CLOSED. CONTACTED DEALER, AND DEALER WAS NOT WILLING TO DO ANYTHING.*AK
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, OVER AN EXTENDED PERIOD OF TIME, THE HEADLIGHT SWITCH MAY CEASE TO FUNCTION.
Consequence & remedy
Consequence: THE HEAD LIGHTS MAY NOT OPERATE PROPERLY WHICH COULD RESULT IN INTERMITTENT OR NO HEADLIGHT FUNCTION. THIS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: ON VEHICLES WITH AN ORIGINAL OEM SWITCH, DEALERS WILL REPLACE THE HEADLIGHT SWITCH. ALL OTHER VEHICLES WILL BE INSPECTED TO DETERMINE IF THE SWITCH HAS EEN DAMAGED AND REPLACE ONLY IF NECESSARY. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THERE COULD BE INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET WHICH COULD CAUSE THE FRONT TURN SIGNAL NOT TO FUNCTION AS DESIGNED.
Consequence & remedy
Consequence: THIS WOULD FAIL TO WARN AN APPROACHING DRIVER THAT THE VEHICLE IS TURNING AND COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT TURN SIGNAL BULB AND SOCKET.
ON CERTAIN STATION WAGONS, THE TAILGATE LOCKING MECHANISM MAY HAVE BEEN INCORRECTLY MANUFACTURED WHICH, IN COMBINATION WITH COLD TEMPERATURES, COULD CAUSE IMPROPER LOCKING OF THE TAILGATE.
Consequence & remedy
Consequence: THE TAILGATE MAY NOT LOCK PROPERLY.
Remedy: DEALERS WILL REPLACE THE LOCKING MECHANISM FOR THE TAILGATE. OWNER NOTIFICATION BEGAN SEPTEMBER 25, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Additional source detail variants (2)
Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Exterior Lighting:headlights
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
2000 Volvo V70 Problems, Complaints & Recalls | Skip That Year
Illustration