2000 Volvo S80

MY WIFE AND I NOTICED THAT THE NHTSA IS INVESTIGATING POWER LOSS COMPLAINTS REGARDING THE S-80 MODEL OF THE 2000 VOLVO. WE HAD A QUICK AND COMPLETE LOSS OF POWER ON THE INTERSTATE ON OCTOBER 24, 2003. WE WERE ABLE TO DRIVE OFF THE INTERSTATE AND GET TO A PARKING LOT. THE ENGINE STOPPED AND COULD NOT BE RESTARTED. WE HAD THE CAR TOWED TO THE CROWN VOLVO DEALERSHIP IN GREENSBORO, NC (TEL: 336 834-7350). CROWN VOLVO REPLACED THE ELECTRONIC THROTTLE MODULE AND DOWNLOADED NEW SOFTWARE. THE REPAIR COST US $899.48. THE MILEAGE ON THE CAR WAS 79,089 MILES. IN FEBRUARY 2003, THE CAR WAS STALLING REPEATEDLY. WHEN RESTARTED, THE ENGINE REVVED AND STALLED AGAIN. THE CAR WAS TOWED TO VOLVO SAAB OF CHARLOTTE (TEL: 704 563-8816) AND A REPAIR WAS MADE. THE MASS AIR FLOW SENSOR WAS REPLACED AT A COST $443.23. THE ODOMETER AT THE TIME OF THE REPAIR WAS 68,066 MILES. THE CAR HAD NO MALFUNCTIONS BETWEEN THE FEBRUARY AND OCTOBER REPAIRS. THE SERVICE CENTERS RETAINED ALL REPLACED COMPONENTS. THE VEHICLE ID IS [XXX]. SERVICE REFERENCE NUMBERS ARE THE FOLLOWING: CROWN VOLVO - [XXX] VOLVO SAAB OF CHARLOTTE - INVOICE [XXX]. *NM UPDATED 07/19/2012 *JS

ENGINE CONSTANTLY SURGES FORWARD WHILE BRAKES ARE APPLIED. AT A STOPLIGHT, THE CAR WILL JUST SUDDENLY LURCH FORWARD. ON HIGHWAY, CAR LOST POWER AND ACCELERATION. WHEN I PULLED OVER, THE ENGINE CUT OFF. DEALERSHIP TOLD ME TO THE PROBLEM WAS THE ELECTRONIC THROTTLE, WHICH I REPLACED FOR $2100. THE CAR CONTINUES TO HAVE ENGINE SURGES. *NM

THE ELECTRONIC THROTTLE CONTROL FAILED DURING A LEFT TURN TO A FREEWAY ON-RAMP. THE CAR STOPPED AND WOULD NOT START. I WAS LUCKY IT WAS POURING RAIN AND TRAFFIC WAS LIGHT BECAUSE I WAS IN THE MIDDLE OF THE ROAD FOR ABOUT 1/2 HOUR. IT WAS TOWED TO THE DEALER AND THE MODULE REPLACED FOR APPROXIMATELY $800. THE FOLLOWING YEAR THE SECOND MODULE EXHIBITED THE SAME SYMPTOMS. I DROVE IT TO THE DEALER AND HAD IT CLEANED FOR APPROXIMATELY $200. I WAS TOLD THAT THE MODULE HAD TO BE CLEANED EVERY YEAR - WHICH I WOULD HAVE TO PAY FOR - OR IT WOULD FAIL AND HAVE TO BE REPLACED. I WAS TOLD THIS HAPPENED TO ALL VOLVOS WHICH PREDOMINATELY WERE DRIVEN IN CITY TRAFFIC. I AM ABOUT DUE TO HAVE THE PROBLEM THIS YEAR. *NM

DT: BEGINNING LAST YEAR, WHILE DRIVING IN THE NEIGHBORHOOD RPMS WOULD GO WAY UP AND FALL BACK DOWN OVER AND OVER FOR ABOUT 5 MINUTES. THEN ,THE ENGINE CUT OFF. THE VEHICLE STARTED RIGHT BACK UP. THEN, RIGHT AWAY THE PROBLEM WOULD OCCUR AGAIN. THE CAR WAS TAKEN TO THE DEALERSHIP. THE AIR INTAKE VALVE WAS REPLACED. THE PROBLEM STOPPED FOR A WHILE. THEN, THE EXACT PROBLEM HAPPENED AGAIN ON JUNE 15 2005. THE CAR WOULD STOP IN TRAFFIC. THE RMPS WOULD GO UP AND DOWN FOR ABOUT 5 MINUTES, AND TTHERE WAS ELECTRICAL POWER. THERE WAS NO POWER STEERING OR BRAKES WHEN THE CAR SHUT COMPLETELY DOWN.*AK

MY WIFE WAS DRIVING ON A BUSY 4 LANE HIGHWAY WHEN THE CAR STALLED WHILE IN MOTION. SHE WAS UNABLE TO RESTART IT WHEN IT WAS IN NEUTRAL. SHE CAME VERY CLOSE TO AN ACCIDENT AS IT WAS A VERY BUSY STREET. HAD THE CAR TOWED TO VOLVO OF FIFE AND THEY COULD FIND NOTHING WRONG WITH IT. SAID NOTHING REGISTERED ON THE COMPUTER. I TOLD THEM THIS HAD HAPPENED TO ME ONCE AND SEEMED LIKE A VAPOR LOCK. I WAS TOLD THAT THERE WAS A PART THAT HAS GONE OUT ON SOME OF THE EARLY MODEL S80'S BUT IT'S $1,300.00 TO REPLACE AND THEY DIDN'T WANT TO DO THAT UNLESS THEY KNEW FOR SURE. THE PART HASN'T BEEN REPLACED AND MY WIFE IS VERY CONCERNED ABOUT WHAT WILL HAPPEN IF IT STALLS WHEN SHE'S DOING 65 MPH DOWN THE FREEWAY. *NM

THE VEHICLE WOULD HAVE SMALL CHANGES IN SPEED OVER THE COURSE OF SEVERAL MONTHS THE CAR BEGAN TO LOSE POWER AND THEN STALL AT SPEED BETWEEN 50-75 MPH. THE CAR RESTARTED BUT SPEED WAS INCONSISTENT EVEN WITH CRUISE CONTROL. DEALER WAS CONTACTED AND THEY ADVISED THAT IS WAS PROBABLY THE ELECTRONIC THROTTLE CONTROL MODULE, THIS WAS WITHOUT FURTHER INSPECTION OF THE VEHICLE. THE SERVICE WORK WAS DONE AND SO FAR THE PROBLEM HAS BEEN CORRECTED. *NM

DT: THE VEHICLE CUT OFF. WHEN GETTING READY TO PARK THE VEHICLE LUNGED FORWARD. DID THE SAME THING WHEN SITTING AT A LIGHT IF LET TING UP FROM THE BRAKES. THE ENGINE REVVED. WHEN TURNING STEERING WHEEL TO MAKE A LEFT OR RIGHT HAND TURNS ITS WA SHARD TO GET IT TO GO BACK FORWARD. THIS STARTED BACK IN 2000 BUT IT BECAME WORSE. *AK

AS WITH A NUMBER OF OTHER POSTINGS ON THIS SITE, I HAVE A 2000 VOLVO S80 T6 AND HAD A FAILURE OF THE THROTTLE BODY UNIT AT ABOUT 72,000 MILES ON THE CAR. I WAS TRAVELING ON THE INTERSTATE IN ATLANTA WHEN I GOT THE WARNING MESSAGE THAT PERFORMANCE HAD BEEN REDUCED. I CALLED THE VOLVO DEALER, THEY STATED TO TURN THE CAR OFF AND BACK ON AND THE PROBLEM MAY CORRECT ITSELF. (THEY DID SAY THAT I NEEDED TO BRING THE CAR IN FOR THEM TO LOOK AT.) THE PROBLEM THEN WAS FIXED FOR ABOUT 80 MILES BEFORE I HAD FAILURE AGAIN AND HAD TO HAVE THE CAR TOWED. THEY REPLACED THE PART AND SAID IT WAS NOT COVERED AS A PART OF THE "CERTIFIED PRE-OWNED" WARRANTY. *NM

MY 2000 S80 VOLVO A FEW WEEKS AGO HAD A SUDDEN LOSS OF SPEED ON HIGHWAY. MESSAGE SCREEN SAID TO SHUT OFF ENGINE AND RESTART. THIS WAS AT 65 MPH. AFTER PULLING OVER AND RESTARTING CAR IT WOULD NOT GO ABOVE 2K RPMS. AFTER 20 MINUTES IT STARTED AND I BROUGHT IT TO DEALER. THEY REPLACED THE ELECTRONIC THROTTLE CONTROL MODULE AND ALSO STRONGLY RECOMMENDED AND I DID UPGRADE SOFTWARE ON ANOTHER CONTROLLER. I AM VERY CONCERNED AFTER READING ARTICLE TODAY THAT THE PROBLEM COULD HAPPEN AGAIN. I WAS LUCKY TO BE ABLE TO GET TO SIDE OF ROAD. *NM

OUR VOLVO WAS SERVICED REGULARLY BY OUR DEALER. WE COMPLAINED ABOUT THE CAR HESITATING AND WAS TOLD THAT THE PROBLEM WAS CORRECTED. WE LEFT NJ FOR A THANKSGIVING HOLIDAY TRIP TO MYRTLE BEACH SC. ABOUT 30 MILES FROM OUR DESTINATION, THE CAR BEGAN TO DECELERATE FROM 65 MPH AND WOULD NOT GO ANY FASTER THAN 20 MPH. WE PROCEED TO PULL OFF THE HIGHWAY AND LET THE CAR COOL DOWN. AFTER APPROX. 30 MINUTES WE TRIED TO RESTART THE CAR AND IT DID START SO WE CONTINUED ONTO MYRTLE BEACH AT NO MORE THAN 30 MPH AS THAT WAS AS FAST AS THE CAR WOULD GO. THE NEXT MORNING IT WAS TAKEN TO THE LOCAL VOLVO DEALER APPROX. 5 MILES AWAY AND IT AGAIN REFUSED TO ACCELERATE ABOVE 20-30 MPH. BEACH VOLVO OF MYRTLE BEACH, SC SAID THE PROBLEM WAS THE THROTTLE CONTROL MODULAR. A NEW THROTTLE BODY WAS INSTALLED AT A COST OF $871.51. THE CAR HAD 53,481 MILES ON IT JUST OVER THE 50,000 MILEAGE WARRANTY PERIOD. THE CAR IS A 2000 S80 VIN [XXX]. WHEN TOLD OF THE PROBLEM BY THE DEALER HE SAID WHEN THE PART GOES, IT GOES WITHOUT WARNING AND THERE ISN'T ANYTHING YOU CAN DO BUT REPLACE IT. I AM GLAD WE BROKE DOWN LATE AT NIGHT WHEN THERE WAS NO TRAFFIC AROUND US BECAUSE WE WERE IN THE HIGH SPEED LANE DOING 65 MPH WHEN IT JUST QUITE AND SLOWED TO BARELY A CRAWL. IF WE HAD BEEN ON A BUSY CORRIDOR SOMEONE COULD HAVE HIT US FROM THE REAR AND CAUSED A TERRIBLE ACCIDENT. VOLVO SHOULD BE HELD ACCOUNTABLE FOR THIS DEFECT IN DESIGN. *NM UPDATED 07/19/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)