THERE WERE FOUR OCCUPANTS IN THE VEHICLE. AS WE WERE DRIVING HOME FROM THE MALL, WE NOTICED A BRIEF INTERRUPTION IN THE LIGHTS AND RADIO. A FEW MILES DOWN THE ROAD, THERE WAS AN ELECTRICAL FAILURE AND THE CAR SHUT OFF IN THE MIDDLE OF THE ROAD, BUT WE WERE ABLE TO GET IT CRANKED BACK UP IN LESS THAN A MINUTE. WE DROVE APPROXI…
Read full complaint
THERE WERE FOUR OCCUPANTS IN THE VEHICLE. AS WE WERE DRIVING HOME FROM THE MALL, WE NOTICED A BRIEF INTERRUPTION IN THE LIGHTS AND RADIO. A FEW MILES DOWN THE ROAD, THERE WAS AN ELECTRICAL FAILURE AND THE CAR SHUT OFF IN THE MIDDLE OF THE ROAD, BUT WE WERE ABLE TO GET IT CRANKED BACK UP IN LESS THAN A MINUTE. WE DROVE APPROXIMATELY TWO MORE MILES AND PULLED INTO OUR DRIVEWAY AND SHUT THE CAR OFF. WE HEARD A SOUND LIKE AN ALARM, BUT IT WAS SO FAINT; BEFORE WE HAD TIME TO THINK ABOUT IT FURTHER, THE CAB BEGAN TO FILL WITH BLACKISH GREY SMOKE INTO THE BACKSEAT AREA. WE ALL GOT OUT QUICKLY AND WALKED TO THE BACK OF THE CAR. I NOTICED FLAMES BEHIND THE DRIVER SIDE TAIL LIGHT (WHERE THE BATTERY IS LOCATED) AND TOLD MY HUSBAND. HE OPENED THE TRUNK (BURNING HIS FINGERTIPS), AND FLAMES SHOT UP INTO THE AIR. I IMMEDIATELY CALLED 911 BECAUSE THE FLAMES WERE HIGH AND FAST-MOVING. THE 911 DISPATCHER INSTRUCTED US TO STAY AWAY FROM THE CAR AND NOT TRY TO PUT THE FIRE OUT DUE TO THE OBVIOUS DANGERS OF A FAST-MOVING CAR FIRE. THE FIRE DEPARTMENT ARRIVED WITHIN FIVE MINUTES AND BEGAN PUTTING THE FIRE OUT; HOWEVER, THE CAR WAS A TOTAL LOSS UP TO THE ENGINE, WHICH WAS NOT BURNED. AFTER INSPECTION, THE FIRE DEPARTMENT DEEMED IT A LOSS DUE TO AN ELECTRICAL FIRE. I HAVE CONTACTED VOLVO, BUT THEY HAVE NOT RESPONDED TO ME AS OF YET. THERE HAVE BEEN SEVERAL RECALLS ON THIS PARTICULAR VEHICLE, AND WE ARE WORRIED THAT VOLVO MAY HAVE MISSED ONE. FOR THE SAFETY OF OTHERS, I AM REPORTING THIS SAFETY HAZARD. THE CAR REMAINS IN OUR DRIVEWAY AWAITING INSURANCE ADJUSTMENT; HOWEVER, I AM HOPEFUL THAT EITHER VOLVO OR SOMEONE WHO DOES SAFETY INSPECTIONS WOULD CLAIM THE CAR TO INVESTIGATE THE CAUSE OF THE FIRE FURTHER. *TR
NHTSA ODI #10473697
135,000 miles · Jan 12, 2009
Structure
WHILE DRIVING ON THE PA TURNPIKE, MY GLASS SUNROOF INEXPLICABLY JETTISONED OUT OF THE CAR. THE GLASS WAS INTACT AND SHATTERED ON THE SHOULDER OF THE ROAD. FORTUNATELY, I WAS DRIVING IN THE SLOW LANE AND THERE WAS NO ONE BEHIND ME. THE POTENTIAL FOR SERIOUS INJURY AND PROPERTY DAMAGE WAS AVOIDED, ALTHOUGH IT IS CLEAR THAT A DE…
Read full complaint
WHILE DRIVING ON THE PA TURNPIKE, MY GLASS SUNROOF INEXPLICABLY JETTISONED OUT OF THE CAR. THE GLASS WAS INTACT AND SHATTERED ON THE SHOULDER OF THE ROAD. FORTUNATELY, I WAS DRIVING IN THE SLOW LANE AND THERE WAS NO ONE BEHIND ME. THE POTENTIAL FOR SERIOUS INJURY AND PROPERTY DAMAGE WAS AVOIDED, ALTHOUGH IT IS CLEAR THAT A DEFECT CAUSED THIS OCCURRENCE. THE MANUFACTURER (VOLVO) IS UNWILLING TO ADDRESS THE PROBLEM ALTHOUGH I HAVE CONTACTED THEIR NORTH AMERICAN OFFICE SEVERAL TIMES. I TOOK MY CAR INTO THE DEALERSHIP AND THEY TOLD ME IT WAS MY PROBLEM. *TR
NHTSA ODI #10254737
Mileage unknown · Jul 15, 2008
Structure
THE FRONT DRIVER SIDE INTERIOR DOOR HANDLE ASSEMBLY BROKE. DEALER SAID THE ONLY FIX WAS TO REPLACE THE ENTIRE INTERIOR DOOR PANEL ASSEMBLY, AS LINKAGE FOR DOOR IS BUILT INTO DOOR PANEL. DEALER ESTIMATE TO REPLACE PANEL $575. IT APPEARS LIKE VEHICLES HAVE HAD THE SAME ISSUE. THE MANUFACTURER SHOULD STEP UP TO RESOLVE THIS ISSU…
Read full complaint
THE FRONT DRIVER SIDE INTERIOR DOOR HANDLE ASSEMBLY BROKE. DEALER SAID THE ONLY FIX WAS TO REPLACE THE ENTIRE INTERIOR DOOR PANEL ASSEMBLY, AS LINKAGE FOR DOOR IS BUILT INTO DOOR PANEL. DEALER ESTIMATE TO REPLACE PANEL $575. IT APPEARS LIKE VEHICLES HAVE HAD THE SAME ISSUE. THE MANUFACTURER SHOULD STEP UP TO RESOLVE THIS ISSUE WITH LITTLE FINANCIAL IMPACT TO THE OWNER(S). *TR
NHTSA ODI #10234346
77,125 miles · Jun 23, 2008
Structure
THROUGH NORMAL USE, IN THE COURSE OF THE LAST TWO YEARS BOTH OF THE FRONT INTERIOR DOOR HANDLE ASSEMBLIES HAVE BROKEN. MANUFACTURER'S SUGGESTED FIX IS TO REPLACE ENTIRE INTERIOR DOOR PANEL ASSEMBLY, AS LINKAGE FOR DOOR IS BUILT INTO DOOR PANEL, AN EXORBITANT COST AND EXTRAVAGANT FIX FOR SOMETHING SO SMALL. BROKEN INTERIOR DOOR L…
Read full complaint
THROUGH NORMAL USE, IN THE COURSE OF THE LAST TWO YEARS BOTH OF THE FRONT INTERIOR DOOR HANDLE ASSEMBLIES HAVE BROKEN. MANUFACTURER'S SUGGESTED FIX IS TO REPLACE ENTIRE INTERIOR DOOR PANEL ASSEMBLY, AS LINKAGE FOR DOOR IS BUILT INTO DOOR PANEL, AN EXORBITANT COST AND EXTRAVAGANT FIX FOR SOMETHING SO SMALL. BROKEN INTERIOR DOOR LINKAGE MEANS OCCUPANTS MUST ROLL WINDOWS DOWN, AND ACCESS EXTERIOR DOOR HANDLE THROUGH WINDOW IN ORDER TO OPEN CAR DOOR. THIS IS A POTENTIAL SAFETY CONCERN IN EVENT OF A CRASH AND EMERGENCY EGRESS NEEDS TO BE MADE FROM THE VEHICLE. *TR
WHILE DRIVING AT HIGH SPEEDS, THE REAR OF THE VEHICLE WOULD SPIN IF THE VEHICLE WAS TURNED TOO FAR IN EITHER DIRECTION. THE DEALER COULD NOT DETERMINE THE PROBLEM, BUT THERE WAS A LACK OF STABILITY IN THE REAR OF THE VEHICLE. *AK THE CONTROL ARM BUSHING WAS REPLACED. THE CONSUMER STATED THAT THE VEHICLE LOST CONTROL,THE CO…
Read full complaint
WHILE DRIVING AT HIGH SPEEDS, THE REAR OF THE VEHICLE WOULD SPIN IF THE VEHICLE WAS TURNED TOO FAR IN EITHER DIRECTION. THE DEALER COULD NOT DETERMINE THE PROBLEM, BUT THERE WAS A LACK OF STABILITY IN THE REAR OF THE VEHICLE. *AK THE CONTROL ARM BUSHING WAS REPLACED. THE CONSUMER STATED THAT THE VEHICLE LOST CONTROL,THE CONSOLE HAD FAILED, THE LOCKS HAD BECOME INOPERATIVE, GRINDING NOISES WOULD OCCUR ON SHARP TURNS, AND THE VEHICLE WOULD LOSE TRACTION. *SCC *JB
NHTSA ODI #10040243
76 miles · Feb 20, 2003
Structure
I PURCHASED MY NEW 2002 S60 AWD VEHICLE ON NOVEMBER 17, 2002 WITH 76 MILES ON IT AT BOSTON VOLVO VILLAGE IN BOSTON MA. SOON AFTER, I STARTED TO NOTICE VIBRATIONS AND HEAR NOISES, WHICH APPEARED TO BE COMING FROM UNDERNEATH THE GAS PETAL. I SCHEDULED MY FIRST OIL CHANGE FOR WEDNESDAY JANUARY 29TH WITH 3178 MILES ON IT. WHI…
Read full complaint
I PURCHASED MY NEW 2002 S60 AWD VEHICLE ON NOVEMBER 17, 2002 WITH 76 MILES ON IT AT BOSTON VOLVO VILLAGE IN BOSTON MA. SOON AFTER, I STARTED TO NOTICE VIBRATIONS AND HEAR NOISES, WHICH APPEARED TO BE COMING FROM UNDERNEATH THE GAS PETAL. I SCHEDULED MY FIRST OIL CHANGE FOR WEDNESDAY JANUARY 29TH WITH 3178 MILES ON IT. WHILE MY OIL CHANGE WAS BEING DONE, I ALSO WANTED THESE PROBLEMS INVESTIGATED AND FIXED. ON WEDNESDAY AFTERNOON, I RECEIVED A MESSAGE THAT MY CAR WAS READY TO BE PICKED UP. WHEN MY HUSBAND AND I DROVE DOWN TO BOSTON TO PICK UP THE CAR, MY HUSBAND WAS INFORMED THAT NO PROBLEMS WERE DISCOVERED CONCERNING THE NOISE I WAS HEARING. HOWEVER, THERE IS STRUCTURAL DAMAGE TO THE SUB-FRAME OF THE VEHICLE AND THAT IT THE DAMAGE OCCURRED WHILE THE VEHICLE WAS IN MY POSSESSION. WE KNOW THIS NOT TO BE TRUE SINCE I AM SOLE DRIVER OF THE CAR. THE SERVICE DEPARTMENT PROCEEDED TO CHARGE A $90 PARTS AND LABOR FEE BEFORE WE COULD TAKE THE CAR OF THE LOT. WHAT IS THE WARRANTY FOR? THE FOLLOWING MORNING, WHEN I BEGAN TO PUT MY 7 MONTH OLD BABY''S STROLLER IN MY TRUNK, I WAS EVEN MORE FRUSTRATED TO SEE THAT A PIECE OF MY CAR WAS IN MY TRUNK. I LEFT 2 MESSAGES TO GARY IN THE SERVICE DEPARTMENT EXPLAINING THAT I WAS UPSET THAT THIS PIECE WAS IN MY TRUNK, AND CONCERNED OF THE SAFETY OF DRIVING THE CAR, ESPECIALLY WITH MY BABY. UNFORTUNATELY, MY CALL WAS NOT RETURNED. I THEN CALLED HANK, CUSTOMER SATISFACTION MANAGER ON SATURDAY MORNING. AGAIN, HE WAS UNABLE TO ASSIST ME AND OF COURSE, I DID NOT RECEIVE A PHONE CALL BACK. I PURCHASED MY VEHICLE BASED ON THE SAFETY OF THE VEHICLE HOWEVER; I DO NOT FEEL SAFE. I BELIEVE THAT THIS DAMAGE WAS CAUSED PREVIOUS TO MY PURCHASE DUE TO THE CAR BEING USED AS A TEST DRIVE VEHICLE, OR POSSIBLY DONE BY A MECHANIC AT THE DEALERSHIP. WE ARE LOOKING FOR THE DEALERSHIP TO REPLACE THE CAR BUT THEY WILL NOT TALK TO US OR RETURN CALLS.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.
Volvo Car USA LLC (Volvo Car) is recalling certain 2001-2003 S80 and S60 vehicles sold or ever registered in Alabama, Arkansas, Florida, Georgia, Hawaii, Louisiana, Mississippi, North Carolina, Oklahoma, South Carolina, Tennessee, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. The driver side frontal air bag inflator may rupture, sending metal fragments into the passage compartment, when the driver side air bag is deployed.
Consequence & remedy
Consequence: Metal fragments can strike vehicle occupants increasing the risk of serious injury or death.
Remedy: Volvo Car will notify owners, and dealers will replace the driver side air bag module, free of charge. The recall began April 20, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10058.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA, DUE TO THE COMBINATION OF FUEL QUALITY AND CLIMATE CONDITIONS, THE FUEL PUMP MAY, IN CERTAIN CASES, EXPERIENCE A REDUCED FUNCTIONALITY. THE MOST COMMON SYMPTOMS WOULD BE FUEL ODOR.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP FREE OF CHARGE. THE RECALL BEGAN ON JULY 10, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE PRESSURE LABEL IS INCORRECT. THESE VEHICLES DID NOT HAVE THE "MAX LOAD VEHICLE CAPACITY WEIGHT" INFORMATION ON THE LABEL.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECTED LABEL. IF THE OWNER SO DESIRES, A DEALER CAN INSTALL THE LABEL FOR THEM. OWNER NOTIFICATION BEGAN ON DECEMBER 8, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRECT.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL RECEIVE A LETTER/PACKAGE CONSISTING OF THE SECOND ISOFIX GUIDE WITH INSTALLATION INSTRUCTIONS, AND IN CERTAIN CASES, THE CORRECTED OWNER'S MANUAL MAY BE PROVIDED. IF THE OWNER WANTS TO TAKE THEIR VEHICLE TO A VOLVO DEALER FOR INSTALLATION OF THE GUIDE, IT WILL BE PERFORMED AT NO CHARGE TO THE OWNER. OWNER NOTIFICATION BEGAN ON DECEMBER 19, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
2002 Volvo S60 Problems, Complaints & Recalls | Skip That Year
Illustration