2005 Volvo S60

ANGLE/COLLAR GEAR/SLEEVE, HALDEX AWD. HUNDREDS OF THOUSANDS OF AWD VOLVOS HAVE THIS ISSUE YET VOLVO HAS NEVER TAKEN ACTION OR RECALLED PART. THIS IS JUST ONE OF MANY ISSUES THOUSANDS OF VOLVO'S HAVE. BUT THE AWD SYSTEM NON FUNCTIONING DUE TO STRIPPED TEETH CAUSED BY RUST BECAUSE OF INADEQUATE GREASE/LUBE ETC. ON THOUSANDS OF VEHICLES RANGING FROM THEIR SMALL SEDANS TO SUV'S SHOULD BE SOMETHING. THEY HAVE EVEN UPDATED THE ANGLE GEAR/COLLAR SLEEVE WITH ONE THAT HAS "HARDENED" TEETH, BUT NO RECALL ON A PART OF THE VEHICLE THAT IS SUPPOSE TO ALWAYS FUNCTION. A LOT WERE LUCKY ENOUGH IT HAPPENED WHILE STILL UNDER WARRANTY. BUT GETTING STUCK/STRANDED IN SNOW BECAUSE YOUR VEHICLE IS ONLY 2 WHEEL DRIVE WHEN ITS SUPPOSE TO BE AWD. I DID NOT FIND OUT MY AWD DID NOT WORK UNTIL I HAD GOTTEN STUCK IN THE SNOW. TURNS OUT HUNDREDS IF NOT THOUSANDS OF PEOPLE HAD TO FIND OUT THIS SAME WAY. I BELIEVE VOLVO HAS JUST BEEN LUCKY NO ONE HAS DIED YET DUE TO FAILED AWD SYSTEM. I AM NOT CERTAIN ABOUT WHAT CONDITIONS NEED TO BE MET BEFORE A RECALL IS DONE. THIS IS JUST ONE OF THE ISSUES WITH VOLVO'S. I AM NOT SURE ON THE EXACT DATE MY AWD SYSTEM STOPPED WORKING BECAUSE DRIVING ON ANYTHING OTHER THAN SNOW, OR ICE YOU CANNOT TELL. BUT A SIMPLE SEARCH ON THE INTERNET AND HUNDREDS IF NOT THOUSANDS OF PEOPLE STARTING EARLY AS 2000'S TO MOST RECENT AS 2019 HAVING SAME ISSUES, SOME MORE THAN ONCE, AND A FEW COMING UP WITH THEIR OWN WAY OF FIXING VOLVOS ISSUE. BUT PHOTOS CAN BE FOUND ALL OVER THE WEB. ALSO VOLVO SELLS THESE ADVERTISED AS AWD WHEN IN FACT IT IS FWD ALL TIME, UNTIL FRONT TIRES LOSE TRACTION WHICH ONLY THEN DO THE REAR WHEELS ENGAGE. YET CAN BREAK OR MALFUNCTION EVEN THOUGH THEY ONLY EVER COME ON 20-30% OF THE VEHICLES TOTAL MILES DRIVEN. NOT SURE OF AWD DEFINITION BUT I ALWAYS THOUGHT IT STOOD FOR ALL WHEEL DRIVE, NOT FRONT WHEEL DRIVE; ALL WHEEL DRIVE WHEN FRONT WHEELS LOSE TRACTION.

TL* THE CONTACT OWNS A 2005 VOLVO S60. THE CONTACT STATED THAT THE SRS AIR BAG LIGHT REMAINED ILLUMINATED EVER SINCE THE VEHICLE WAS PURCHASED TEN MONTHS AGO. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE FAILURE RECURRED AND WAS NOT REMEDIED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 215,077. UPDATED 08/10/16*LJ *CN

TL* THE CONTACT OWNS A 2005 VOLVO S60. WHILE DRIVING AT APPROXIMATELY 40 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE ENGINE STALLED. THE VEHICLE RESTARTED, BUT THE ENGINE STALLED AGAIN. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE MASS AIR FLOW SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 165,000.

TWICE NOW OVER A TEN DAY PERIOD FIRST WHEN REDUCING SPEED TO A STOP OR THEN AGAIN AT A SPEED OF LESS THAN 5 MPH, THE CAR DIED...FIRST THE ENGINE DIED THEN ALL ELSE DIED. THE CAR WENT DEAD. I STILL HAD MY STEERING AND SLOWLY ROLLED TO THE CURBED THEN AS I GENTLY PUT ON THE BRAKES THE CAR JERKED TO A HALT. DURING THE SECOND INCIDENT THE CAR STILL JERKED AFTER I HAD STOPPED. A LOUD SOUND OF A FAN FROM THE ENGINE COULD BE HEARD. THE FAN STOPPED AFTER 10 TO 15 SECONDS. AFTER A MINUTE I RESTARTED THE CAR AND MADE IT HOME BOTH TIMES. *TR

THE CAR HAD DIFFICULTY IN STARTING ALL OF A SUDDEN. IT APPEARED TO BE AN ELECTRONIC IGNITION PROBLEM. AFTER A FEW STARTS, WARNING SIGNALS STARTED COMING ON. FIRST WAS "ENGINE UNDER PERFORMANCE" AND THEN IT WAS "BREAK FAILURE". THE CAR WAS STOPPED AND TOWED TO VOLVO DEALER. THE DEALER INDICATED THAT THE CAR'S FUEL PUMP / LINES WERE DESIGNED AND INSTALLED OUTSIDE THE WEATHER SHIELDED HOUSING. THE SALT USED FOR SNOW MELTING CORRODES THESE LINES AND SEVERAL CARS SHOW UP WITH THIS ISSUE.SO THEY REPLACED THEM AND MOVED THEM TO WITHIN THE WEATHER PROTECTED AREA. SEARCHING THE INTERNET, I FOUND SEVERAL VOLVO CARS OF THIS ERA HAVE THIS PROBLEM AND SEVERAL OCCURRED WHILE DRIVING - BOTH LOSS OF SPEED AND BREAK FAILURE. MY CAR WAS WELL MAINTAINED, REGULAR OIL CHANGES WITH THE SYNTHETIC OIL AND MAINTAINED BY VOLVO DEALER OR SPECIALIST. I ALSO USE THE RECOMMENDED 91 OR 93 OCTANE GAS, SO IT CANNOT BE ATTRIBUTED TO LAX MAINTENANCE OR LESSER QUALITY FUEL. THE ONLINE FORUMS SEEM TO HAVE ALL KINDS OF DIAGNOSTICS FOR THIS PROBLEM. IF IT WAS A DESIGN FAULT AT MANUFACTURER, AS ADVISED BY THE VOLVO DEALER, I WOULD THINK IT WOULD SHOULD BE INVESTIGATED FOR RECALL. *TR

TL* THE CONTACT OWNS A 2005 VOLVO S60. THE CONTACT STATED THAT THE VEHICLE WAS SLOW TO START. ONCE STARTED, THE VEHICLE WOULD RIVE SLUGGISH AND WAS SLOW TO ACCELERATE. THE CONTACT HAD AN INDEPENDENT MECHANIC REPLACE THE MASS AIR FLOW SENSOR MORE THAN THREE TIMES BUT THE FAILURE RECURRED. THE MASS AIR FLOW SENSOR WAS CLEANED AND THE SENSOR WAS RESET BY THE INDEPENDENT MECHANIC BUT THAT DID NOT REMEDY THE FAILURE. THE CONTACT INDICATED THAT AN INTERIM SOLUTION WAS TO DISCONNECT THE MASS AIR FLOW SENSOR AND UPON DOING SO THE VEHICLE DID NOT HAVE THE HESITATION. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE WAS RECURRING INTERMITTENTLY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.