NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
40 reportsClear category filter134,000 miles · Oct 25, 2018
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2002 VOLVO S60. THE CONTACT SMELLED A FUEL ODOR INSIDE AND OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP WAS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATE…
Read full complaint
TL* THE CONTACT OWNS A 2002 VOLVO S60. THE CONTACT SMELLED A FUEL ODOR INSIDE AND OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP WAS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 134,000.
NHTSA ODI #11142720
Mileage unknown · Dec 29, 2014
Fuel System, Gasoline
I HAVE A GAS/FUME SMELL COMING FROM MY CAR ,I CAN SMELL THE FUMES WHEN I STAND NEXT TO VEHICLE. DO YOU KNOW WHAT I SHOULD CHECK OR ANY RECALLS FOR THIS VEHICLE. THANK YOU *TR
NHTSA ODI #10668912
136,909 miles · Oct 27, 2014
Fuel System, Gasoline
VOLVO IS REFUSING TO DO RECALL WORK NHTSA ACTION NUMBER PE09039 VOLVO SAFETY RECALL #R220 09V-483 THE FUEL PUMP IS ONE OF THE TYPE VOLVO IS TO REPLACE FUEL PUMP IS SPRAYING GAS EVERYWHERE THE SERVICE MANAGER SAYS TO DRIVE IT IN TO HAVE IT INSPECTED THAT'S AFTER I TOLD HIM ITS SPRAYING GAS ON CAT. CONVERT. *TR
NHTSA ODI #10650506
100,000 miles · Jul 31, 2014
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2002 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 25 MPH, THERE WAS A FUEL ODOR EMITTING FROM OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2002 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 25 MPH, THERE WAS A FUEL ODOR EMITTING FROM OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000 THE CONSUMER SMELLED FUEL ON THE OUTSIDE OF THE VEHICLE, WHICH WOULD CEASE ONCE THE VEHICLE WAS STOPPED AND PLACED IN PARK. IT OCCURRED WHEN THE ACCELERATOR WAS PRESSED, WHICH IN TURN PUT PRESSURE ON THE FUEL LINE AND FUEL PUMP. THE DEALER WAS UNABLE TO FIND A PROBLEM. THE CONSUMER RECENTLY FOUND THE FUEL SMELL WORSENING AND A LOSS OF FUEL. A MECHANIC CHECKED OUT THE PROBLEM AND FOUND THE FUEL PUMP FLANGE WAS CRACKED. AFTER, THE DIAGNOSIS, THE CONSUMER CONTACTED THE DEALER, AND WAS INFORMED, HER VEHICLE WAS NOT COVERED BY THE RECALL, AND IT HAD EXPIRED IN 2011. UPDATED 08/12/14
NHTSA ODI #10617910
85,862 miles · Dec 11, 2013
Fuel System, Gasoline
SMELL GASOLINE, HAD THAT FIX, BUT AUTO HARD START WHEN HOT, NOT WHEN COLD, TAKE AWHILE FOR AUTO TO START, BELIEF TO BE THE GASOLINE PUMP. NEED RECALL INF. THANK YOU [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10555691
126,200 miles · Sep 20, 2013
Fuel System, Gasoline
SMELL OF GAS LEAKING BUT NO LEAK ON GROUND...HAS RECALL FOR SAMETHING. *TR
NHTSA ODI #10544700
168,000 miles · Aug 8, 2013
Fuel System, Gasoline
TOOK VEHICLE IN QUESTION TO MY MECHANIC DUE TO STARTING ISSUE AND FUEL SMELL. HE DIAGNOSED A SIGNIFICANT FUEL LEAK DUE TO A CRACKED FLANGE ON THE FUEL PUMP. HE FOUND THERE WAS A RECALL FOR THIS EXACT PROBLEM FOR THIS EXACT MAKE, MODEL AND YEAR OF VOLVO. CALLED VOLVO AND THEY REJECTED REQUEST FOR RECALL REPAIR DUE TO VIN NUMBE…
Read full complaint
TOOK VEHICLE IN QUESTION TO MY MECHANIC DUE TO STARTING ISSUE AND FUEL SMELL. HE DIAGNOSED A SIGNIFICANT FUEL LEAK DUE TO A CRACKED FLANGE ON THE FUEL PUMP. HE FOUND THERE WAS A RECALL FOR THIS EXACT PROBLEM FOR THIS EXACT MAKE, MODEL AND YEAR OF VOLVO. CALLED VOLVO AND THEY REJECTED REQUEST FOR RECALL REPAIR DUE TO VIN NUMBER NOT BEING INCLUDED IN RECALL. I BELIEVE THIS VEHICLE SHOULD BE SUBJECT TO THE RECALL REGARDLESS OF THE VIN NUMBER BECAUSE IT HAS THE EXACT SAME DIAGNOSIS AS IS DESCRIBED BY THE RECALL. THE NOTION THAT A MAKER CAN EXCLUDE A VEHICLE WHICH EXHIBITS THE PROBLEMS TO BE FIXED BY A RECALL BASED ON EXTRANEOUS CRITERIA IS FUNDAMENTALLY FLAWED. THE VEHICLE IN QUESTION IS UNSAFE TO DRIVE AND THERE IS A RECALL TO FIX THE SAFETY ISSUE FOR THE MAKE, MODEL AND YEAR IN QUESTION. THAT THE VEHICLE IS EXCLUDED BASED ON EXTRANEOUS CRITERIA IS RECKLESS REGARD FOR MY SAFETY AND POTENTIAL BYSTANDERS! *TR
NHTSA ODI #10534308
160,000 miles · May 21, 2013
EngineFuel System, Gasoline
FUEL PUMP LEAK , DEALER TOLD ME IT WAS RECALLED FOR CRACKED FUEL PUMP UNDER CAMPAIGN # 07V152000. R176 AND CAR IS NOW TOO OLD TO HAVE FREE REPAIRS I WAS NEVER NOTIFIED OF RECALL AND THE CAR WAS PURCHASED USED BUT FROM A VOLVO NEW CAR DEALER, CAN I BE MADE WHOLE? *TR
NHTSA ODI #10512978
84,756 miles · Oct 3, 2012
Fuel System, Gasoline
THE CAR JUST BEGAN TO EMIT A FUEL SMELL WHILE PARKED. THE SMELL IS NEAR THE GAS TANK AND TENDS TO LINGER IN THE AIR DISSIPATE AND THEN RESURFACE. SOME TIMES ITS STRONG OTHER TIMES IT IS FAINT. IT ALSO TENDS TO COMES INTO THE INTERIOR COMPARTMENT AND CAN AT TIME BECOME OVER WHELMING CAUSING MY CHILDREN AND I TO GET HEADACHES A…
Read full complaint
THE CAR JUST BEGAN TO EMIT A FUEL SMELL WHILE PARKED. THE SMELL IS NEAR THE GAS TANK AND TENDS TO LINGER IN THE AIR DISSIPATE AND THEN RESURFACE. SOME TIMES ITS STRONG OTHER TIMES IT IS FAINT. IT ALSO TENDS TO COMES INTO THE INTERIOR COMPARTMENT AND CAN AT TIME BECOME OVER WHELMING CAUSING MY CHILDREN AND I TO GET HEADACHES AND NAUSEOUS. I COULD NOT FIND ANY PRESENCE OF A LEAK UNDERNEATH THE VEHICLE NEAR THE AREA OF CONCERN. THE VEHICLE HAS NEVER BEEN IN AN ACCIDENT AND IS GARAGED MOST OF THE TIME. *TR
NHTSA ODI #10478550
107,000 miles · Sep 24, 2012
Fuel System, GasolineFuel/propulsion System
I AM A RESIDENT OF TEXAS. I JUST BOUGHT A 2002 VOLVO S60 ABOUT THREE MONTHS AGO, AND I'VE NOTICED A STRONG FUEL SMELL IN AND AROUND CAR. THERE IS A LEAK IN THE FUEL PUMP AND WHEN CAR IS PARKED, FUEL FORMS A PUDDLE UNDER CAR. IT IS EXTREMELY DANGEROUS TO DRIVE A CAR IN THIS CONDITION, BOTH FOR MYSELF BUT ALSO FOR THE GENERAL PUBL…
Read full complaint
I AM A RESIDENT OF TEXAS. I JUST BOUGHT A 2002 VOLVO S60 ABOUT THREE MONTHS AGO, AND I'VE NOTICED A STRONG FUEL SMELL IN AND AROUND CAR. THERE IS A LEAK IN THE FUEL PUMP AND WHEN CAR IS PARKED, FUEL FORMS A PUDDLE UNDER CAR. IT IS EXTREMELY DANGEROUS TO DRIVE A CAR IN THIS CONDITION, BOTH FOR MYSELF BUT ALSO FOR THE GENERAL PUBLIC. I SEARCHED ONLINE ABOUT THIS ISSUE AND FOUND THE FOLLOWING RECALL INFORMATION FROM THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION WEBSITE: MAKE: VOLVO MODEL: S60 MODEL YEAR: 2002 MANUFACTURER: VOLVO CARS OF N.A. LLC. MFR'S REPORT DATE: DEC 17, 2009 NHTSA CAMPAIGN ID NUMBER: 09V483000 NHTSA ACTION NUMBER: PE09039 COMPONENT: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP RECALL STATES THAT AS REMEDY FOR THIS ISSUE: "DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. " HOWEVER, WHEN I CONTACTED ROGER BEASLEY VOLVO OF AUSTIN, TX, I WAS TOLD I WOULD HAVE TO PAY FOR THE REPAIR TO THE TUNE OF $720. *TR
NHTSA ODI #10476836
Official recalls
8Sep 30, 2021
Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.
Nov 4, 2020
Volvo Car USA LLC (Volvo Car) is recalling certain 2001-2003 S80 and S60 vehicles sold or ever registered in Alabama, Arkansas, Florida, Georgia, Hawaii, Louisiana, Mississippi, North Carolina, Oklahoma, South Carolina, Tennessee, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. The driver side frontal air bag inflator may rupture, sending metal fragments into the passage compartment, when the driver side air bag is deployed.
Consequence & remedy
Consequence: Metal fragments can strike vehicle occupants increasing the risk of serious injury or death.
Remedy: Volvo Car will notify owners, and dealers will replace the driver side air bag module, free of charge. The recall began April 20, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10058.
Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Dec 18, 2009
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Apr 5, 2007
ON CERTAIN VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA, DUE TO THE COMBINATION OF FUEL QUALITY AND CLIMATE CONDITIONS, THE FUEL PUMP MAY, IN CERTAIN CASES, EXPERIENCE A REDUCED FUNCTIONALITY. THE MOST COMMON SYMPTOMS WOULD BE FUEL ODOR.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP FREE OF CHARGE. THE RECALL BEGAN ON JULY 10, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Nov 15, 2006
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Aug 21, 2003
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE PRESSURE LABEL IS INCORRECT. THESE VEHICLES DID NOT HAVE THE "MAX LOAD VEHICLE CAPACITY WEIGHT" INFORMATION ON THE LABEL.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECTED LABEL. IF THE OWNER SO DESIRES, A DEALER CAN INSTALL THE LABEL FOR THEM. OWNER NOTIFICATION BEGAN ON DECEMBER 8, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
Aug 1, 2003
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRECT.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL RECEIVE A LETTER/PACKAGE CONSISTING OF THE SECOND ISOFIX GUIDE WITH INSTALLATION INSTRUCTIONS, AND IN CERTAIN CASES, THE CORRECTED OWNER'S MANUAL MAY BE PROVIDED. IF THE OWNER WANTS TO TAKE THEIR VEHICLE TO A VOLVO DEALER FOR INSTALLATION OF THE GUIDE, IT WILL BE PERFORMED AT NO CHARGE TO THE OWNER. OWNER NOTIFICATION BEGAN ON DECEMBER 19, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
Illustration