IllustrationCheck engine light came on and stays in. Vehicle always sputters to start, acceleration is sometimes slow to respond, has stalled out on a rare occasion usual on hills. I’m afraid someday I might be involved in a crash because of a lack of acceleration.
2006 Volvo S40
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Volvo S40 do not stand out strongly from the model-year median of 26.
About this comparison →How this year compares
Owner complaints by model year
Compare all S40 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
325–50K
1050–75K
1075–100K
10100–150K
3150K+
44 reports with mileage · 14 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports1 injury reports
Fuel/propulsion System complaints
7 reportsCheck engine light came on and has stayed on. Stalled out in traffic, turned the car off and it restarted and I continued. Happens two more times. Initial start up has a delay in the engine turning over. Gas pedal is slow to respond to acceleration. Verified at a garage with code reader. Suspect faulty wiring (corrosion) to fuel…
Read full complaint
Check engine light came on and has stayed on. Stalled out in traffic, turned the car off and it restarted and I continued. Happens two more times. Initial start up has a delay in the engine turning over. Gas pedal is slow to respond to acceleration. Verified at a garage with code reader. Suspect faulty wiring (corrosion) to fuel pump needing PEM replacement. No warning prior to first incident around 02/2022. I have had the check engine light reset on multiple occasions and each time the light comes back on within 2 days. Safety has been a concern at multiple times. Entered VIN number with Volvo, a Volvo dealer, and nhtsa.gov with no help in resolving issue.
IN SOME OCCASIONS CAR WON'T START AND WHILE DRIVING THE CAR IT WOULD SHUT OFF UNEXPECTEDLY CAUSING A DANGEROUS SITUATION. I BELIEVE IT'S THE PUMP ELECTRONIC MODULE WHICH IS ALREADY RECALLED IN SOME CARS. ACCORDING TO YOUR RECALL I HAVE THE EXACT SAME SYMPTOMS BUT MY VIN NUMBER IS NOT PART OF THE RECALL.
I WENT OUT TO START MY CAR FOR WORK AND IT WOULD NOT START LIKE IT WAS OUT OF BUT I HAVE A HALF TANK OF GAS IN IT BUT FOR SOME REASON IT SOUNDS LIKE THE FUEL PUMP/MODULE IS NOT WORKING.
RECALL ON- FUEL SYSTEM, GASOLINE: DELIVERY: FUEL PUMP VOVLVO RECALL NO. 190
TL* THE CONTACT OWNS A 2006 VOLVO S40. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE ENGINE STALLED WHILE THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE …
Read full complaint
TL* THE CONTACT OWNS A 2006 VOLVO S40. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE ENGINE STALLED WHILE THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE FAILURE AND THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V033000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 78,000.
TL* THE CONTACT OWNS A 2006 VOLVO S40. THE CONTACT STATED THAT FUEL FUMES WERE PRESENT AROUND THE VEHICLE, BUT NO FUEL LEAKS COULD BE FOUND. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.
Official recalls
310V566000 · Equipment:electrical:navigational System(global Positioning System)
Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
08V033000 · Fuel System, Gasoline:delivery:fuel Pump
Jan 28, 2008
ON CERTAIN VEHICLES SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, REOCCURRING, LONG-TERM EXPOSURE TO CERTAIN ENVIRONMENTAL CONDITIONS SUCH AS SALTY-WET CONDITIONS, IT IS POSSIBLE FOR THE PUMP ELECTRONIC MODULE (PEM) TO BECOME CORRODED INTERNALLY. THIS CAN CAUSE A FAULTY SIGNAL TO THE FUEL PUMP, RESULTING IN LOW OR NO FUEL PRESSURE TO THE ENGINE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE CHECK ENGINE LIGHT MAY ILLUMINATE. IN SOME CASES, THE VEHICLE MAY FAIL TO START OR MAY STALL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PEM AND INSTALL IT IN A NEW LOCATION TO PREVENT CORROSION. THE RECALL BEGAN ON FEBRUARY 20, 2008. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
06V137000 · Fuel System, Gasoline
Apr 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH T5 TURBO ENGINES, THE POLYAMIDE TUBE IN THE FUEL LINE IS SENSITIVE TO THE EXTREME TEMPERATURES THAT MAY OCCUR IN THE AREA WHERE THE TURBO/EXHAUST MANIFOLD IS LOCATED.
Consequence & remedy
Consequence: THIS MAY POTENTIALLY RESULT IN FUEL LINE LEAKAGE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL CHANGE THE FUEL LINE MATERIAL TO TEFLON FREE OF CHARGE. THE RECALL BEGAN ON JUNE 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.