IllustrationCAR LOOSING POWER AND ENGINE MISSING AT HIGHWAY SPEEDS. ENGINE LIGHT WENT ON. FAILURE OF FUEL PRESSURE MONITOR.
2005 Volvo S40
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Volvo S40 do not stand out strongly from the model-year median of 26.
About this comparison →How this year compares
Owner complaints by model year
Compare all S40 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
1025–50K
1150–75K
1675–100K
8100–150K
6150K+
56 reports with mileage · 13 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports1 injury reports
What owners actually said
69 reportsCAR IS ALL OF A SUDDEN ACCELERATING ON ITS OWN. IT HAS HAPPENED A HANDFUL OF TIMES WITHIN THE LAST MONTH. I WILL MAKE A TURN, LET OFF THE GAS PEDDLE AND THEN THE CAR WILL JUST JERK FORWARD REVVING UP THE RPMS AND ACCELERATING ON ITS OWN.
FUEL PUMP CONTROL MODULE (PEM) FAILS DURING WET CONDITIONS. CAR WILL CRANK LIKE NORMAL BUT WILL NOT START. LET CAR DRY OUT FOR A FEW DAYS AND THEN THE CAR WILL RUN NORMAL AGAIN.
TAKATA RECALL. I HAD ENGINE STUTTERING AT HIGH SPEED. MY FUEL PRESSURE SENSOR FAILED AND WAS REPLACED. I QUESTION WHY IT IS NOT COVERED UNDER THE NHTSA CAMPAIGN I.D. # 07V226000 WHICH IS FOR THE SAME PART IN THE SAME ENGINE BUT IN 2004 S60 MODELS.
TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT THE KEY WAS UNABLE TO TURN AND PREVENTED THE VEHICLE FROM STARTING. THE BATTERY WAS TESTED BY AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS TO BE TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS UNABLE TO BE DR…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT THE KEY WAS UNABLE TO TURN AND PREVENTED THE VEHICLE FROM STARTING. THE BATTERY WAS TESTED BY AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS TO BE TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.
[THIS IS A PREVENTATIVE COMPLAINT. NO INJURY SUSTAINED.] THIS CAR HAS A FAILED PASSENGER SEAT SENSOR THAT WHEN DEPRESSED ACTIVATES THE PASSENGER SIDE AIR BAG. THIS VEHICLE ALSO HAS A DRIVER SIDE SEAT BELT THAT CLICKS AND THEN CAN BE PULLED OUT OF THE LOCKING HARNESS. THESE ITEMS ARE NOT RECALLED BY THE MANUFACTURE BUT, IN MY…
Read full complaint
[THIS IS A PREVENTATIVE COMPLAINT. NO INJURY SUSTAINED.] THIS CAR HAS A FAILED PASSENGER SEAT SENSOR THAT WHEN DEPRESSED ACTIVATES THE PASSENGER SIDE AIR BAG. THIS VEHICLE ALSO HAS A DRIVER SIDE SEAT BELT THAT CLICKS AND THEN CAN BE PULLED OUT OF THE LOCKING HARNESS. THESE ITEMS ARE NOT RECALLED BY THE MANUFACTURE BUT, IN MY OPINION, SHOULD BE FOR CUSTOMER SAFETY.
TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE STEERING WHEEL AND ENTIRE VEHICLE BEGAN TO SHAKE AS THERE WAS AN ABNORMAL NOISE. IN ADDITION, THE AIR CONDITIONER, RADIO, HORN AND SUN ROOF FAILED TO FUNCTION WHEN ACTIVATED. THE SRS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN …
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE STEERING WHEEL AND ENTIRE VEHICLE BEGAN TO SHAKE AS THERE WAS AN ABNORMAL NOISE. IN ADDITION, THE AIR CONDITIONER, RADIO, HORN AND SUN ROOF FAILED TO FUNCTION WHEN ACTIVATED. THE SRS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ECM, FRONT AXLES AND STRUTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 194,000.
TL* THE CONTACT OWNS A 2005 VOLVO S40. WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD AND FAILED TO STOP THE VEHICLE WHEN IT WAS DEPRESSED. THE VEHICLE SHOOK VIOLENTLY WITHOUT WARNING. THE CONTACT LET THE VEHICLE DECELERATE AND THEN SLOWLY DROVE THE VEHICLE TO THE DEALER. THE DEALER DIAGNOSED THAT…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLVO S40. WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD AND FAILED TO STOP THE VEHICLE WHEN IT WAS DEPRESSED. THE VEHICLE SHOOK VIOLENTLY WITHOUT WARNING. THE CONTACT LET THE VEHICLE DECELERATE AND THEN SLOWLY DROVE THE VEHICLE TO THE DEALER. THE DEALER DIAGNOSED THAT THE BRAKE VACUUM PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V474000 (SERVICE BRAKES, HYDRAULIC). THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
TL* THE CONTACT OWNS A 2005 VOLVO S40. WHILE DRIVING VARIOUS SPEEDS ON SEVERAL OCCASIONS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP ELECTRONIC MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLVO S40. WHILE DRIVING VARIOUS SPEEDS ON SEVERAL OCCASIONS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP ELECTRONIC MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V033000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
INSERTED KEY IN IGNITION AND NOTHING HAPPENED. COMPUTER READS KEY ERROR TRY AGAIN. KEPT TRYING AND FINALLY STARTED. NEXT DAY SAME THING HAPPENED.
Official recalls
310V566000 · Equipment:electrical:navigational System(global Positioning System)
Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
08V033000 · Fuel System, Gasoline:delivery:fuel Pump
Jan 28, 2008
ON CERTAIN VEHICLES SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, REOCCURRING, LONG-TERM EXPOSURE TO CERTAIN ENVIRONMENTAL CONDITIONS SUCH AS SALTY-WET CONDITIONS, IT IS POSSIBLE FOR THE PUMP ELECTRONIC MODULE (PEM) TO BECOME CORRODED INTERNALLY. THIS CAN CAUSE A FAULTY SIGNAL TO THE FUEL PUMP, RESULTING IN LOW OR NO FUEL PRESSURE TO THE ENGINE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE CHECK ENGINE LIGHT MAY ILLUMINATE. IN SOME CASES, THE VEHICLE MAY FAIL TO START OR MAY STALL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PEM AND INSTALL IT IN A NEW LOCATION TO PREVENT CORROSION. THE RECALL BEGAN ON FEBRUARY 20, 2008. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
06V137000 · Fuel System, Gasoline
Apr 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH T5 TURBO ENGINES, THE POLYAMIDE TUBE IN THE FUEL LINE IS SENSITIVE TO THE EXTREME TEMPERATURES THAT MAY OCCUR IN THE AREA WHERE THE TURBO/EXHAUST MANIFOLD IS LOCATED.
Consequence & remedy
Consequence: THIS MAY POTENTIALLY RESULT IN FUEL LINE LEAKAGE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL CHANGE THE FUEL LINE MATERIAL TO TEFLON FREE OF CHARGE. THE RECALL BEGAN ON JUNE 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.