← New search

2005 Volvo S40

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2005 Volvo S40 do not stand out strongly from the model-year median of 26.

About this comparison →

When problems were reported

Mileage at the reported incident

56 reports with mileage · 13 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine And Engine Cooling. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Gasoline. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports0 fire reports1 injury reports

Power Train complaints

2 reports
Clear category filter
170,000 miles · Mar 20, 2024
Electrical SystemFuel/propulsion SystemPower Train

The contact's wife owns a 2005 Volvo S40. The contact stated the vehicle was difficult to start for several days. Eventually, the failure progressed and the vehicle was not able to start. The check engine warning light was illuminated. The vehicle was repaired by the contact, a previous Volvo technician. The contact stated th…

Read full complaint

The contact's wife owns a 2005 Volvo S40. The contact stated the vehicle was difficult to start for several days. Eventually, the failure progressed and the vehicle was not able to start. The check engine warning light was illuminated. The vehicle was repaired by the contact, a previous Volvo technician. The contact stated the failure was due to the pump electrical module being located out of the vehicle. The contact spoke with the dealer. The contact referenced The manufacturer was made aware of the failure. The approximate failure mileage was 170,000.

NHTSA ODI #11578530

84,000 miles · May 20, 2013
Power Train

TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT VEHICLE STALLED WITH THE ILLUMINATION OF THE INFORMATION SENSOR LIGHT. THE VEHICLE WAS NOT REPAIRED NOR WAS THE MANUFACTURER NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 84,000. *TR

NHTSA ODI #10512825

Official recalls

3

10V566000 · Equipment:electrical:navigational System(global Positioning System)

Nov 8, 2010

VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

Consequence & remedy

Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.

Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.

08V033000 · Fuel System, Gasoline:delivery:fuel Pump

Jan 28, 2008

ON CERTAIN VEHICLES SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, REOCCURRING, LONG-TERM EXPOSURE TO CERTAIN ENVIRONMENTAL CONDITIONS SUCH AS SALTY-WET CONDITIONS, IT IS POSSIBLE FOR THE PUMP ELECTRONIC MODULE (PEM) TO BECOME CORRODED INTERNALLY. THIS CAN CAUSE A FAULTY SIGNAL TO THE FUEL PUMP, RESULTING IN LOW OR NO FUEL PRESSURE TO THE ENGINE.

Consequence & remedy

Consequence: IF THIS OCCURS, THE CHECK ENGINE LIGHT MAY ILLUMINATE. IN SOME CASES, THE VEHICLE MAY FAIL TO START OR MAY STALL, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE PEM AND INSTALL IT IN A NEW LOCATION TO PREVENT CORROSION. THE RECALL BEGAN ON FEBRUARY 20, 2008. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

06V137000 · Fuel System, Gasoline

Apr 24, 2006

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH T5 TURBO ENGINES, THE POLYAMIDE TUBE IN THE FUEL LINE IS SENSITIVE TO THE EXTREME TEMPERATURES THAT MAY OCCUR IN THE AREA WHERE THE TURBO/EXHAUST MANIFOLD IS LOCATED.

Consequence & remedy

Consequence: THIS MAY POTENTIALLY RESULT IN FUEL LINE LEAKAGE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL CHANGE THE FUEL LINE MATERIAL TO TEFLON FREE OF CHARGE. THE RECALL BEGAN ON JUNE 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.