Service Brakes, Hydraulic. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

11 crash reports4 fire reports5 injury reports

Steering complaints

2 reports

Clear category filter

Mileage unknown · Aug 13, 2019

Fuel/propulsion SystemSteeringVisibility/wiper

Read full complaint

I BOUGHT A 2001 VOLVO S40 FROM TOM BLEVINS OWNER OF POPPLES GARAGE. THE ODOMETER QUIT WORKING AS SOON AS I BOUGHT IT. THE KEY WOULD GET STUCK IN THE IGNITION AND WOULD HAVE TO BE LEFT IN THE IGNITION. THE DRIVERS SIDE WINDOW GOT STUCK IN THE DOWN POSITION BECAUSE OF A FAULTY CONTROLLER. THE HOOD HYDRAULIC ARM THAT HOLDS THE HOOD UP WHEN IT'S RAISED DOES NOT WORK AND HAS TO BE PROPPED UP WITH A WOOD BLOCK. HEADLIGHTS AND TURN SIGNALS DO NOT WORK. THERE ARE MORE PROBLEMS TO DISCUSS BUT I AM OUT OF SPACE.

NHTSA ODI #11243446

10,230 miles · May 28, 2003

Exterior LightingService Brakes, HydraulicSteering

CONSUMER HAD TO REPLACE TWO REAR BRAKE PADS AFTER 10230. IN ADDITION, HEADLIGHTS BURNED OUT AND NEEDED TO BE REPLACED. POWER STEERING WHEEL SHAFT. PH

NHTSA ODI #10022349

Official recalls

03V284000 · Equipment:other:labels

Aug 1, 2003

CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRECT.

Consequence & remedy

Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Remedy: OWNERS WILL RECEIVE A LETTER/PACKAGE CONSISTING OF THE SECOND ISOFIX GUIDE WITH INSTALLATION INSTRUCTIONS, AND IN CERTAIN CASES, THE CORRECTED OWNER'S MANUAL MAY BE PROVIDED. IF THE OWNER WANTS TO TAKE THEIR VEHICLE TO A VOLVO DEALER FOR INSTALLATION OF THE GUIDE, IT WILL BE PERFORMED AT NO CHARGE TO THE OWNER. OWNER NOTIFICATION BEGAN ON DECEMBER 19, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.

01V169000 · Equipment:appliance:air Conditioner

May 21, 2001

VEHICLE DESCRIPTION: SEDAN AND WAGON PASSENGER VEHICLES. A DIODE IN THE ELECTRONIC CLIMATE CONTROL SYSTEM MAY HAVE A REDUCED SERVICE LIFE.

Consequence & remedy

Consequence: IF THE DIODE FAILS, THE HEATER FAN STOPS OPERATING AND THE DEFROSTER FUNCTION IS AFFECTED.

Remedy: DEALERS WILL INSTALL AN ADAPTER WITH A DIODE FITTED TO THE HEATER FAN MOTOR. OWNER NOTIFICATION BEGAN JUNE 11, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA02026 · Volvo S40/V40 My 2000-2001

Opened Sep 10, 2002 · Closed Nov 21, 2003

Status: closed (inferred from source dates) · Service Brakes, Hydraulic

IN A NOVEMBER 6, 2003 SAFETY DEFECT REPORT, VOLVO INDICATED THAT THEY WILL CONDUCT A SAFETY-RELATED DEFECT RECALL OF THE 2000 MODEL YEAR (MY) SUBJECT VEHICLES (ABOUT 36,000 VEHICLES).VOLVO WILL ALSO CONDUCT A SERVICE CAMPAIGN OF ABOUT 31,000 2001 MY SUBJECT VEHICLES.ODI INVESTIGATED BOTH THE 2000 AND 2001 MY VEHICLES AND DETERMINED THAT THE 2001 MY VEHICLES EXPERIENCED SUBSTANTIALLY LOWER RATES OF FAILURES BASED ON THE NUMBER OF OWNER REPORTS AND WARRANTY CLAIMS SUBMITTED TO ODI.ODI BELIEVES THAT THE PROPOSED ACTION IS SUFFICIENT TO RESOLVE THIS INVESTIGATION'S SAFETY ISSUES. FOR THE CRASHES, IN ADDITION TO THE 22 SUBMITTED BY VOLVO, ODI FOUND 10 ADDITIONAL CRASH ALLEGATIONS IN THE OWNER REPORTS, FIELD REPORTS, AND WARRANTY CLAIMS SUBMITTED BY VOLVO.OF THESE 32 CRASHES, ODI BELIEVES THAT 10 ARE CLEARLY RELATED TO THE ALLEGED DEFECT, AND 5 APPEAR TO BE RELATED.OF THE 17 REMAINING CASES, TWO DID NOT INVOLVE A CRASH AND THE OTHER 15 COULD NOT BE DIRECTLY CONNECTED TO THE ALLEGED DEFECT.ODI WILL SUPPLEMENT THIS RESUME WITH A CLOSING REPORT AND ADDITIONAL TECHNICAL DETAILS CONCERNING THE DEFECT.