IllustrationEXHAUST: CATALYTIC CONVERTEWR FAILED/PLUGGED UP. TRANSMISSION: SHIFT LOCK RELEASE BUTTON ON SHIFTER LOCKED UP.
1996 Volvo 850
Owner reports · Recalls · Investigations
More warning signs than most 850 years
Owner complaints for the 1996 Volvo 850 are substantially higher than the model-year median of 78.
About this comparison →How this year compares
Owner complaints by model year
Compare all 850 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
325–50K
850–75K
1475–100K
14100–150K
9150K+
49 reports with mileage · 143 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports20 fire reports9 injury reports
What owners actually said
192 reports1996 VOLVO 850 WAGON TAILGATE HYDRAULIC HINGE JACK. JACK REPEATEDLY FAILED TO HOLD UP THE TAILGATE WHEN TEMPERSTURE DROPS BELOW 52 DEGREE, OR WHILE PARKED IN UPHILL POSITION. ON DECEMBER 18, 2003, IT ALMOST FELL ON MY 5 AND 3 YEARS OLD; I AM THANKFUL THAT I STILL HAD A TALL LARGE BOX IN THE WAY WHEN THAT HAPPENED. I COULD SEEN…
Read full complaint
1996 VOLVO 850 WAGON TAILGATE HYDRAULIC HINGE JACK. JACK REPEATEDLY FAILED TO HOLD UP THE TAILGATE WHEN TEMPERSTURE DROPS BELOW 52 DEGREE, OR WHILE PARKED IN UPHILL POSITION. ON DECEMBER 18, 2003, IT ALMOST FELL ON MY 5 AND 3 YEARS OLD; I AM THANKFUL THAT I STILL HAD A TALL LARGE BOX IN THE WAY WHEN THAT HAPPENED. I COULD SEEN SERVE INJURIES OR FATALITIES MAY OCCUR TO THE LITTLE ONES JUST HAPPEN TO STAND IN THE WAY. IT LANDED ON ME SEVERAL TIMES AFTERWARD, THUS MY TRACKING OF THE TAILGATE OPERATION. NOTICE SHOULD BE SEND TO PARENTS TO NOT ALLOW THEIR LITTLE ONES STANDING BEHIND THE CAR WHILE THE GATE IS UP.
HAIRLINE CRACK IN CIRCUIT BOARD ON VEHICLE COMPUTER MAKES ABS AND TRACS BRAKING SYSTEM INOPERATIVE. THIS IS AN INTERMITTENT PROBLEM AND GOES OFF IF THE VEHICLE IS STOPPED AND RE-STARTED. I TALKED TO AN INDEPENDENT VOLVO REPAIR SHOP AND HE INDICATED THAT HE HAS REPLACED TEN COMPUTER THIS YEAR IN BOISE, IDAHO THIS YEAR ON VARIOU…
Read full complaint
HAIRLINE CRACK IN CIRCUIT BOARD ON VEHICLE COMPUTER MAKES ABS AND TRACS BRAKING SYSTEM INOPERATIVE. THIS IS AN INTERMITTENT PROBLEM AND GOES OFF IF THE VEHICLE IS STOPPED AND RE-STARTED. I TALKED TO AN INDEPENDENT VOLVO REPAIR SHOP AND HE INDICATED THAT HE HAS REPLACED TEN COMPUTER THIS YEAR IN BOISE, IDAHO THIS YEAR ON VARIOUS VOLVO MODELS, YEARS 1993 TO 1998.*AK
SEAT HEATERS WERE REPLACED DUE TO RECALL, BUT HEATERS MALFUNCTIONED AFTER REPLACEMENT. DEALER WON'T TAKE RESPONSIBILITY. *LA THE CONSUMER RECEIVED RECALL 02V314000. THE DRIVER AND PASSENGER SEAT HEATERS WERE FULLY FUNCTIONAL AND THE CONSUMER HAD NO PROBLEMS. ONCE THE DEALER DID THE RECALL REPAIRS THE SEAT HEATERS NO LONGER…
Read full complaint
SEAT HEATERS WERE REPLACED DUE TO RECALL, BUT HEATERS MALFUNCTIONED AFTER REPLACEMENT. DEALER WON'T TAKE RESPONSIBILITY. *LA THE CONSUMER RECEIVED RECALL 02V314000. THE DRIVER AND PASSENGER SEAT HEATERS WERE FULLY FUNCTIONAL AND THE CONSUMER HAD NO PROBLEMS. ONCE THE DEALER DID THE RECALL REPAIRS THE SEAT HEATERS NO LONGER FUNCTIONED. THE CONSUMER INFORMED THE DEALER OF THE PROBLEM. THE DEALER INDICATED THAT ONLY THE WIRING WAS RE-ROUTED, THEREFORE THEY WERE NOT RESPONSIBLE. *NM
BAD ABS MODULE. *LA
THE DASHBOARD IS SEPARATING FROM THE FRAME. CONSUMER IS CONCERNED THAT THE AIR BAG WILL DEPLOY INADVERTENTLY.*AK
DRIVER'S SIDE DOOR HINGE MADE NOISES. TOOK VEHICLE TO SHOP & WAS INFORMED THAT HINGES WOULD NEED TO BE WELDED BACK ON. *LA
FUEL SYSTEM, GASOLINE STORAGE SMELL OF FUEL FUMES PRESENT AT ALL TIMES WHILE OPERATING VEHICLE WHEN FILLING TANK, FUEL LEAKS FROM TOP OF FUEL TANK ASSEMBLY JUST AS TANK BECOMES COMPLETELY FULL. *JB
CONSUMER NOTICED AN ODD SMELL INSIDE OF VEHICLE WHILE TRAVELING. CONSUMER PULLED VEHICLE OVER AND NOTICED SMOKE COMING FROM UNDER HOOD AND A FIRE. FIRE DEPARTMENT WAS CALLED AND PUT FIRE OUT. *AK
THE FUEL TANK SPLIT AT THE SEAM OVER THE EXHAUST PIPE. MANUFACTURER AND THE DEALER HAVE BEEN NOTIFIED OF THE PROBLEM. *AK
Official recalls
204V368000 · Fuel System, Gasoline:storage
Jul 30, 2004
ON CERTAIN PASSENGER VEHICLES, AFTER PROLONGED EXPOSURE TO HEAT, THE FUEL TANK MAY SEEP OR LEAK FUEL AT THE POINTS WHERE THE HEAT SHIELD IS ATTACHED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: VOLVO WILL INSPECT THE FUEL TANK AND REPLACE IT IF ANY EVIDENCE OF FUEL SEEPAGE OR LEAKAGE IS FOUND. ALL VEHICLES WILL RECEIVE NEW REINFORCEMENT BUSHINGS AT THE HEAT SHIELD ATTACHMENT POINTS TO PREVENT FUTURE LEAKS. THIS RECALL WILL BE CONDUCTED AS A SAFETY RECALL IN THE HOT WEATHER STATES OF ALABAMA, ARKANSAS, ARIZONA, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, AND UTAH, AND AS A SERVICE RECALL IN THE OTHER 33 STATES AND THE DISTRICT OF COLUMBIA. THE RECALL BEGAN ON SEPTEMBER 24, 2004. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
02V314000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2002
ON SOME SEDANS AND STATION WAGONS EQUIPPED WITH SEAT HEATERS, IT IS POSSIBLE THAT EXCESSIVE COMPRESSION OF THE SEAT CUSHION COULD CAUSE DAMAGE TO THE ELECTRICAL WIRING OF THE SEAT HEATER.
Consequence & remedy
Consequence: IF THIS OCCURS, THE DAMAGE COULD RESULT IN A SHORT CIRCUIT THAT COULD CAUSE A FIRE.
Remedy: DEALERS WILL DISCONNECT THE EXISTING WIRES AND INSTALL A NEW ELECTRONIC THERMOSTAT AND CABLE HARNESS. OWNER NOTIFICATION BEGAN ON FEBRUARY 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA03008 · Fuel Tank Leaks
Opened Jun 11, 2003 · Closed Jul 28, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
THIS ENGINEERING ANALYSIS WAS OPENED ON JUNE 11, 2003, BASED ON 54 REPORTS OF FUEL TANK LEAKS.THE SUBJECT VEHICLES WERE 1993 THROUGH 1996 MODEL YEAR (MY) 850 VEHICLES. MODEL 850 WAS ALSO PRODUCED IN MY 1997 AND WAS INCLUDED IN THIS INVESTIGATION. ANALYSIS OF THE DATA REVEALS TWO DISTINCT ISSUES. FIRST, THE 1994 THROUGH 1997 MY VEHICLES STAND OUT BY ACCOUNTING FOR 95 PERCENT OF THE REPORTED LEAKS.THESE VEHICLES SHARE THE SAME FUEL TANK DESIGN (PN 9142618). THE 1993 MY VEHICLE USES A DIFFERENT FUEL TANK DESIGN (PN 9141101).SECONDLY, THE FAILURES OCCURRED PREDOMINANTLY IN HOT CLIMATES, E.G., CALIFORNIA, ARIZONA, TEXAS, FLORIDA, GEORGIA, LOUISIANA, ETC.TESTING OF FUEL TANKS FROM CONSUMER VEHICLES AT THE VEHICLE RESEARCH AND TEST CENTER CONFIRMED LEAKS THROUGH CRACKS IN THE FUEL TANK WALL AT A HEAT SHIELD MOUNTING ATTACHMENT IN THE 1994 THROUGH 1997 MY FUEL TANKS (PN9142618). DETAILS OF THE TESTS ARE AVAILABLE IN TEST REPORT VRTC-DCD3060.VOLVO WILL CONDUCT A SAFETY RECALL ON ALL MY 1994 THROUGH 1997 VEHICLES ORIGINALLY SOLD OR REGISTERED IN THE FOLLOWING 17 HOT STATES: CA, AZ, NM, TX, LA, MS, AL, GA, SC, FL, NC, TN, AR, OK, UT, NV, AND HI.ALL 1994 THROUGH 1997 MY VEHICLES IN ALL OTHER STATES WILL BE REMEDIED UNDER A SERVICE CAMPAIGN.THE REMEDY FOR BOTH THE RECALL AND SERVICE CAMPAIGN IS TO INSTALL A NEW BUSHING AT EACH HEAT SHIELD ATTACHMENT POINT (3 PER TANK).ALSO, ALL TANKS (VEHICLES IN ALL STATES) WILL BE INSPECTED FOR FUEL SEEPAGE AT THE HEAT SHIELD ATTACHMENT POINTS AND VOLVO WILL REPLACE ANY TANK SHOWING SIGNS OF FUEL SEEPAGE.THE NEW BUSHINGS WILL PREVENT HEAT SHIELD STRESSES FROM BEING TRANSFERRED TO THE THREE HEAT SHIELD MOUNTING ATTACHMENTS ON THE FUEL TANK.THE SAFETY RECALL IS FILED UNDER NHTSA SAFETY RECALL NUMBER 04V368.THIS INVESTIGATION IS CLOSED.
PE03003 · Fuel Tank Leaks
Opened Jan 16, 2003 · Closed Jun 11, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
THE OFFICE OF DEFECTS INVESTIGATION OPENED THISINVESTIGATION ON JANUARY 16, 2003.THE BASIS FOR OPENING THE INVESTIGATION WAS 15 CONSUMER REPORTS ALLEGING GASOLINE LEAKING FROM THE FUEL STORAGE TANK.VOLVO PROVIDED 43 ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION, 4 OF WHICH WERE DUPLICATES OF THE 15 ODI REPORTS. THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
EA02019 · Seat Fires
Opened Aug 22, 2002 · Closed Dec 18, 2002
Status: closed (inferred from source dates) · Electrical System; Seats:front Assembly:seat Heater/cooler
VOLVO IS CONDUCTING A SAFETY RECALL BASED ON ITS ANALYSIS OF COMPLAINTS AND TECHNICAL INFORMATION DEVELOPED DURING ITS INVESTIGATION.VOLVO'SSURVEY OF VEHICLES ROUTINELY BROUGHT IN FOR MAINTENANCE AT EAST-COAST DEALERSHIPS PRODUCED EVIDENCE THAT BARE METAL WIRES (THAT PROVIDE SUPPORT FOR THE SEAT BOTTOM) CAN CONTACT THE THERMOSTAT AND ELECTRICAL WIRESIN OR BENEATH THE SEAT CUSHION.THIS CAN RESULT IN AN ELECTRICAL SHORT.VOLVO CONFIRMED IN TESTING THAT IF SUCH A CONDITION IS PRESENT, THE SHORT TO THE WIRE SEAT SUPPORT COULD CAUSE BURNING OF THE SEAT CUSHION WITHOUT ACTIVATING (OPENING) THE SEAT HEATER FUSE.VOLVO WILL REPLACE THE ENTIRE THERMOSTAT ASSEMBLY WITH AN ELECTRONIC TIMER DELAY UNIT.
Additional source detail variants (2)
Electrical System
VOLVO IS CONDUCTING A SAFETY RECALL BASED ON ITS ANALYSIS OF COMPLAINTS AND TECHNICAL INFORMATION DEVELOPED DURING ITS INVESTIGATION.VOLVO'SSURVEY OF VEHICLES ROUTINELY BROUGHT IN FOR MAINTENANCE AT EAST-COAST DEALERSHIPS PRODUCED EVIDENCE THAT BARE METAL WIRES (THAT PROVIDE SUPPORT FOR THE SEAT BOTTOM) CAN CONTACT THE THERMOSTAT AND ELECTRICAL WIRESIN OR BENEATH THE SEAT CUSHION.THIS CAN RESULT IN AN ELECTRICAL SHORT.VOLVO CONFIRMED IN TESTING THAT IF SUCH A CONDITION IS PRESENT, THE SHORT TO THE WIRE SEAT SUPPORT COULD CAUSE BURNING OF THE SEAT CUSHION WITHOUT ACTIVATING (OPENING) THE SEAT HEATER FUSE.VOLVO WILL REPLACE THE ENTIRE THERMOSTAT ASSEMBLY WITH AN ELECTRONIC TIMER DELAY UNIT.
Seats:front Assembly:seat Heater/cooler
VOLVO IS CONDUCTING A SAFETY RECALL BASED ON ITS ANALYSIS OF COMPLAINTS AND TECHNICAL INFORMATION DEVELOPED DURING ITS INVESTIGATION.VOLVO'SSURVEY OF VEHICLES ROUTINELY BROUGHT IN FOR MAINTENANCE AT EAST-COAST DEALERSHIPS PRODUCED EVIDENCE THAT BARE METAL WIRES (THAT PROVIDE SUPPORT FOR THE SEAT BOTTOM) CAN CONTACT THE THERMOSTAT AND ELECTRICAL WIRESIN OR BENEATH THE SEAT CUSHION.THIS CAN RESULT IN AN ELECTRICAL SHORT.VOLVO CONFIRMED IN TESTING THAT IF SUCH A CONDITION IS PRESENT, THE SHORT TO THE WIRE SEAT SUPPORT COULD CAUSE BURNING OF THE SEAT CUSHION WITHOUT ACTIVATING (OPENING) THE SEAT HEATER FUSE.VOLVO WILL REPLACE THE ENTIRE THERMOSTAT ASSEMBLY WITH AN ELECTRONIC TIMER DELAY UNIT.
PE02029 · Passenger Compartment Fires
Opened Mar 7, 2002 · Closed Aug 22, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
PE99040 · Inadvertent Side Air Bag Deployment
Opened Jun 7, 1999 · Closed Oct 27, 1999
Status: closed (inferred from source dates) · Air Bags:side/window
No summary supplied.
PE97045 · Engine Compartment Fire
Opened Oct 23, 1997 · Closed Feb 13, 1998
Status: closed (inferred from source dates) · Engine And Engine Cooling
ODI HAS RECEIVED FOUR OWNER COMPLAINTS OF VOLVO 850 ENGINE COMPARTMENT FIRES, ALL INVOLVING 1996 MODEL YEAR VEHICLES.TABLE 1 SHOWS THE DISTRIBUTION OF FIRE INCIDENTS KNOWN TO ODI AND VOLVO BY MODEL YEAR AND INCIDENT YEAR FOR ALL 1993-97 VOLVO 850 VEHICLES.VOLVO HAS CLASSIFIED MOST OF THE FIRES AS OCCURRING FROM UNDETERMINED CAUSES.IN THOSE FEW CASES WHERE PROBABLE OR POSSIBLE CAUSES WERE IDENTIFIED, NO COMMON DEFECT PATTERN OR TREND HAS BEEN IDENTIFIED.THIS INVESTIGATION IS CLOSED, BUT ODI WILL CONTINUE TO MONITOR THE ISSUE THROUGH 11998 WITH QUARTERLY REPORTS FROM VOLVO.