NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
73 reportsMileage unknown · May 30, 2008
Electrical SystemFire
TL*THE CONTACT OWNS A 1993 VOLVO 850. AFTER DRIVING APPROXIMATELY 55 MPH, THE CONTACT PARKED THE VEHICLE. TWO MINUTES LATER, THE HOOD BURST INTO FLAMES. THERE WERE NO WARNING INDICATORS PRIOR TO THE FAILURE. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND A POLICE REPORT WAS FILED. THE CONTACT WAS INFORMED THAT THE CAUSE OF…
Read full complaint
TL*THE CONTACT OWNS A 1993 VOLVO 850. AFTER DRIVING APPROXIMATELY 55 MPH, THE CONTACT PARKED THE VEHICLE. TWO MINUTES LATER, THE HOOD BURST INTO FLAMES. THERE WERE NO WARNING INDICATORS PRIOR TO THE FAILURE. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND A POLICE REPORT WAS FILED. THE CONTACT WAS INFORMED THAT THE CAUSE OF THE FIRE WAS ELECTRICAL. THERE WERE NO INJURIES. IT HAS NOT YET BEEN DETERMINED IF THE VEHICLE WAS DESTROYED. THE CONTACT WAS ONLY COVERED FOR LIABILITY INSURANCE. THE VEHICLE WAS TOWED TO HIS RESIDENCE. THE CURRENT AND FAILURE MILEAGES WERE UNAVAILABLE.
NHTSA ODI #10229332
Mileage unknown · Oct 23, 2006
Engine And Engine Cooling
1993 VOLVO 850GLT ENGINE STALLS WITHOUT WARNING. NEWSPAPER AD SAID 1999 THROUGH 2001, C70,S60,S80,V70 & V70XC. THE 850 WAS NEVER MENTIONED. HAVE HAD THE CAR SINCE 1998 & IT HAS HAPPENED FOUR TIMES. REAL SCARY, CAN IT BE FIXED? *NM
NHTSA ODI #10171591
200 miles · Mar 15, 2006
Electrical SystemEngine And Engine Cooling
GOOD EVENING;THIS IS MORE OF A QUESTION ABOUT A POTENTIAL VEHICLE THAT I WOULD LIKE TO PURCHASE. I AM INTERESTED IN PURCHASING A 1993 VOLVO 850 4 DOOR. SEDAN ,AUTO/A/C,4 CYL,LOADED. I WENT TO TEST DRIVE THE CAR AND THE ENGINE CHECK LIGHTS STAYED ON WHILE I DROVE THE CAR. WHEN I RETURNED TO THE LOT THE CAR STALLED,BUT RESTARTED R…
Read full complaint
GOOD EVENING;THIS IS MORE OF A QUESTION ABOUT A POTENTIAL VEHICLE THAT I WOULD LIKE TO PURCHASE. I AM INTERESTED IN PURCHASING A 1993 VOLVO 850 4 DOOR. SEDAN ,AUTO/A/C,4 CYL,LOADED. I WENT TO TEST DRIVE THE CAR AND THE ENGINE CHECK LIGHTS STAYED ON WHILE I DROVE THE CAR. WHEN I RETURNED TO THE LOT THE CAR STALLED,BUT RESTARTED RIGHT AWAY. THE USED CAR DEALER SAID THE CAR WAS LOW ON FUEL THAT'S WHY THE LIGHTS STAYED ON? I DOUBT THIS VERY MUCH!!ARE THERE ANY RECALLS ON THESE CARS FOR THIS PROBLEM?IF SO I WOULD LIKE MORE INFORMATION. THANK YOU! JM *JB
NHTSA ODI #10152813
50,000 miles · Aug 3, 2005
Fuel System, Gasoline
I HAVE A 1993 VOLVO 850. IT HAS BEEN STALLING WHILE DRIVING AT HIGH SPEEDS, LOW SPEEDS, FOR OVER 10 YEARS. NO ONE HAS EVER FIXED THE PROBLEM. SINCE YOU ARE INVESTIGATING CURRENT VOLVO MODELS FOR THIS SAME PROBLEM, YOU SHOULD CONSIDER INVESTIGATING THE OLDER MODELS. *NM
NHTSA ODI #10131485
Mileage unknown · Nov 16, 2004
Air Bags
SRS LIGHT IS ON. BROUGHT TO LOVERING VOLVO AND THEY ADVISED THE WHOLE SYSTEM NEEDS TO BE REPLACED AT A COST OF $1200. IN READING PAST COMPLAINTS LISTED ON THIS SIGHT, I SEE QUITE A FEW ARIBAG PROBLEMS, ONE BEING THAT THE WIRES ARE CROSSED FROM PRODUCTION AND THAT CAUSED THE FAILURE. I ALSO SEE MANY COMPLAINTS THAT AIRBAGS ARE…
Read full complaint
SRS LIGHT IS ON. BROUGHT TO LOVERING VOLVO AND THEY ADVISED THE WHOLE SYSTEM NEEDS TO BE REPLACED AT A COST OF $1200. IN READING PAST COMPLAINTS LISTED ON THIS SIGHT, I SEE QUITE A FEW ARIBAG PROBLEMS, ONE BEING THAT THE WIRES ARE CROSSED FROM PRODUCTION AND THAT CAUSED THE FAILURE. I ALSO SEE MANY COMPLAINTS THAT AIRBAGS ARE DEPLOYING FOR NO REASON....IS THIS BECAUSE OF THIS WIRING??? I THINK VOLVO NEEDS TO LOOK AT THIS ISSUE. RIGHT NOW I AM DRIVING WITHOUT AIRBAGS BECAUSE OF THE COST. I WONDER HOW MANY OTHER PEOPLE ARE DOING THE SAME!! VOLVO NEEDS TO LOOK INTO THIS ISSUE ASAP BEFORE A LAWSUIT ARISES!!*AK
NHTSA ODI #10100022
121,000 miles · Aug 5, 2004
Electrical System
THE ENGINE WILL CEASE SUDDENLY WHILE DRIVING. I HAVE TAKEN THE CAR TO A VOLVO DEALERSHIP TO BE FIXED, BUT THE PROBLEM IS STILL OCCURRING.*AK
NHTSA ODI #10086281
150,000 miles · Sep 2, 2003
EquipmentPower Train
FAILED TRANSMISSION AFTER 45,000 MILES. EXTENDED WARRANTY REPLACED IT. FAILED CONTROL SWITCH FOR AIR CONDITIONING A/C AND EVAPORATOR UNIT AT 135,000. *AK
NHTSA ODI #10037093
Mileage unknown · Aug 16, 2003
Electrical System
1993 VOLVO 850 GLT HAS BEEN JUST "TURNING OFF" DURING DRIVING, 20-60 MPH. NEVER AT IDLE. YOU MUST COAST TO THE SIDE OF THE ROAD, TURN THE KEY OFF AND RESTART THE CAR. I HAVE HAD IT TO THE DEALER TWICE AND MY LOCAL GARAGE TWICE AND THE PROBLEM IS STILL NOT CORRECTED. THIS IS A VERY UNSAFE CONDITION THAT ALMOST CREATED AN ACCIDENT…
Read full complaint
1993 VOLVO 850 GLT HAS BEEN JUST "TURNING OFF" DURING DRIVING, 20-60 MPH. NEVER AT IDLE. YOU MUST COAST TO THE SIDE OF THE ROAD, TURN THE KEY OFF AND RESTART THE CAR. I HAVE HAD IT TO THE DEALER TWICE AND MY LOCAL GARAGE TWICE AND THE PROBLEM IS STILL NOT CORRECTED. THIS IS A VERY UNSAFE CONDITION THAT ALMOST CREATED AN ACCIDENT THIS PAST WEEK. I RESEARCHED THE INTERNET TO SEE IF OTHERS ARE HAVING THE SAME PROBLEM AND I FOUND MANY SIMILAR COMPLAINTS.*AK
NHTSA ODI #10032928
Mileage unknown · May 21, 2003
Service Brakes, Hydraulic
NAR 05/21/2003. *MR DEFECTIVE ANTILOCK BRAKE PUMP. *CB
NHTSA ODI #10021565
Mileage unknown · Dec 26, 2002
Fuel System, DieselStructureVisibility
CONSUMER STATED THE WINDSHILED BLADES WERE REPLACED, THE GASOLINE TANK WAS LEAKING, AND THE HOOD LATCHES WERE ADJUSTED.*JB
NHTSA ODI #568577
NHTSA investigations
2EA03008 · Fuel Tank Leaks
Opened Jun 11, 2003 · Closed Jul 28, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
THIS ENGINEERING ANALYSIS WAS OPENED ON JUNE 11, 2003, BASED ON 54 REPORTS OF FUEL TANK LEAKS.THE SUBJECT VEHICLES WERE 1993 THROUGH 1996 MODEL YEAR (MY) 850 VEHICLES. MODEL 850 WAS ALSO PRODUCED IN MY 1997 AND WAS INCLUDED IN THIS INVESTIGATION. ANALYSIS OF THE DATA REVEALS TWO DISTINCT ISSUES. FIRST, THE 1994 THROUGH 1997 MY VEHICLES STAND OUT BY ACCOUNTING FOR 95 PERCENT OF THE REPORTED LEAKS.THESE VEHICLES SHARE THE SAME FUEL TANK DESIGN (PN 9142618). THE 1993 MY VEHICLE USES A DIFFERENT FUEL TANK DESIGN (PN 9141101).SECONDLY, THE FAILURES OCCURRED PREDOMINANTLY IN HOT CLIMATES, E.G., CALIFORNIA, ARIZONA, TEXAS, FLORIDA, GEORGIA, LOUISIANA, ETC.TESTING OF FUEL TANKS FROM CONSUMER VEHICLES AT THE VEHICLE RESEARCH AND TEST CENTER CONFIRMED LEAKS THROUGH CRACKS IN THE FUEL TANK WALL AT A HEAT SHIELD MOUNTING ATTACHMENT IN THE 1994 THROUGH 1997 MY FUEL TANKS (PN9142618). DETAILS OF THE TESTS ARE AVAILABLE IN TEST REPORT VRTC-DCD3060.VOLVO WILL CONDUCT A SAFETY RECALL ON ALL MY 1994 THROUGH 1997 VEHICLES ORIGINALLY SOLD OR REGISTERED IN THE FOLLOWING 17 HOT STATES: CA, AZ, NM, TX, LA, MS, AL, GA, SC, FL, NC, TN, AR, OK, UT, NV, AND HI.ALL 1994 THROUGH 1997 MY VEHICLES IN ALL OTHER STATES WILL BE REMEDIED UNDER A SERVICE CAMPAIGN.THE REMEDY FOR BOTH THE RECALL AND SERVICE CAMPAIGN IS TO INSTALL A NEW BUSHING AT EACH HEAT SHIELD ATTACHMENT POINT (3 PER TANK).ALSO, ALL TANKS (VEHICLES IN ALL STATES) WILL BE INSPECTED FOR FUEL SEEPAGE AT THE HEAT SHIELD ATTACHMENT POINTS AND VOLVO WILL REPLACE ANY TANK SHOWING SIGNS OF FUEL SEEPAGE.THE NEW BUSHINGS WILL PREVENT HEAT SHIELD STRESSES FROM BEING TRANSFERRED TO THE THREE HEAT SHIELD MOUNTING ATTACHMENTS ON THE FUEL TANK.THE SAFETY RECALL IS FILED UNDER NHTSA SAFETY RECALL NUMBER 04V368.THIS INVESTIGATION IS CLOSED.
PE03003 · Fuel Tank Leaks
Opened Jan 16, 2003 · Closed Jun 11, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
THE OFFICE OF DEFECTS INVESTIGATION OPENED THISINVESTIGATION ON JANUARY 16, 2003.THE BASIS FOR OPENING THE INVESTIGATION WAS 15 CONSUMER REPORTS ALLEGING GASOLINE LEAKING FROM THE FUEL STORAGE TANK.VOLVO PROVIDED 43 ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION, 4 OF WHICH WERE DUPLICATES OF THE 15 ODI REPORTS. THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
Illustration