IllustrationA fuel smell is detected in my vehicle, as noted in Repair Available for Safety Recall 20Z4 – Fuel Pump FlangeCertain 2007-2010 MY Volkswagen Touareg / NHTSA Campaign Number: 17V151000.
2009 Volkswagen Touareg
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Touareg years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 14 of 19 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Fuel/propulsion System complaints
8 reportsDRIVING ON THE INTERSTATE A FAULT LIGHT STARTED FLASHING "ENGINE FAULT SERVICE NOW" ALONG WITH THE GLOW PLUG LIGHT. I PUT THE TRANSMISSION INTO NEUTRAL AND MOVED INTO THE SLOW LANE. THE ENGINE IMMEDIATELY STOPPED. I PUT ON MY HAZARD LIGHTS AND WAS ABLE TO ALLOW IT TO ROLL IT A SAFE PLACE TO PULL OVER. THE DEALERSHIP SAID THE HI…
Read full complaint
DRIVING ON THE INTERSTATE A FAULT LIGHT STARTED FLASHING "ENGINE FAULT SERVICE NOW" ALONG WITH THE GLOW PLUG LIGHT. I PUT THE TRANSMISSION INTO NEUTRAL AND MOVED INTO THE SLOW LANE. THE ENGINE IMMEDIATELY STOPPED. I PUT ON MY HAZARD LIGHTS AND WAS ABLE TO ALLOW IT TO ROLL IT A SAFE PLACE TO PULL OVER. THE DEALERSHIP SAID THE HIGH PRESSURE FUEL PUMP FAILED (HPFP) WHICH CAUSED THE ENGINE TO IMMEDIATELY STOP. LUCKILY I WAS IN AN AREA WHERE I COULD ROLL TO A SAFE PLACE AND WASN'T PULLING A TRAILER LIKE WE OFTEN DO. I WAS ALSO LUCKY I WAS IN AN AREA WITH CELL RECEPTION. I HAD SPENT MOST OF THE DAY DRIVING IN A REMOTE AREA THAT WOULDN'T HAVE HAD RECEPTION.
STARTED WITH FAINT SMELL OF GAS OUTSIDE OF VEHICLE ON DRIVERS SIDE. THE GAS SMELL IS STRONGEST WHEN VEHICLE HAS BEEN PARKED FOR SOME TIME LIKE OVER NIGHT. DEVELOPED OVERTIME THAT THE GAS SMELL BEGAN TO BE SMELLED INSIDE OF THE VEHICLE. CURRENTLY THE GAS SMELL IS EXTREMELY STRONG BOTH INSIDE AND OUTSIDE OF VEHICLE.
THE VEHICLE SMELLED LIKE GAS INSIDE & OUT WHETHER STILL, OR DRIVING, RUNNING OR OFF. THEN A FEW DAYS IN, FUEL, OR A GAS-SMELLING SUBSTANCE, BEGAN RAPIDLY LEAKING FROM THE UNDERSIDE OF THE CAR. I WAS TOLD IT WAS ALSO COOLANT.
TL* THE CONTACT OWNS A 2009 VOLKSWAGEN TOUAREG. WHILE DRIVING VARIOUS SPEEDS ON AN INCLINE, THE VEHICLE MALFUNCTIONED AND THE ENGINE INDICATOR ILLUMINATED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE STRUGGLED TO ACCELERATE ON THE INCLINE AND DECELERATED. NEMER MOTOR GROUP OF LATHAN, NEW YORK AND HACKELS FOREIGN CAR SERV…
Read full complaint
TL* THE CONTACT OWNS A 2009 VOLKSWAGEN TOUAREG. WHILE DRIVING VARIOUS SPEEDS ON AN INCLINE, THE VEHICLE MALFUNCTIONED AND THE ENGINE INDICATOR ILLUMINATED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE STRUGGLED TO ACCELERATE ON THE INCLINE AND DECELERATED. NEMER MOTOR GROUP OF LATHAN, NEW YORK AND HACKELS FOREIGN CAR SERVICES OF ALBANY, NEW YORK WERE NOTIFIED AND THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 17V151000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.
THERE IS AN OPEN, PENDING RECALL ON THE FUEL FILTER ASSEMBLY. IT IS NOTICED BY THE SMELL OF GASOLINE OUTSIDE AND POSSIBLY INSIDE THE CABIN, MOSTLY COMING FROM THE DRIVER'S SIDE REAR DOOR AS THE ASSEMBLY IS UNDER THE BACK SEAT ON THAT SIDE OF THE VEHICLE.
AS I WAS DRIVING, THE VEHICLE SUDDENLY FLASHED A SYSTEM MALFUNCTION ON THE DASH AND STATED SERVICE NEEDED TO BE PERFORMED IMMEDIATELY. AS I WAS PULLING OVER TO SIDE, THE VEHICLE INSTANTLY STALLED OUT AND TURNED OFF. MY STEERING WAS COMPROMISED AND I HAD NO ABILITY TO TURN THE VEHICLE BACK ON OR MOVE THE SHIFTER INTO NEUTRAL TO G…
Read full complaint
AS I WAS DRIVING, THE VEHICLE SUDDENLY FLASHED A SYSTEM MALFUNCTION ON THE DASH AND STATED SERVICE NEEDED TO BE PERFORMED IMMEDIATELY. AS I WAS PULLING OVER TO SIDE, THE VEHICLE INSTANTLY STALLED OUT AND TURNED OFF. MY STEERING WAS COMPROMISED AND I HAD NO ABILITY TO TURN THE VEHICLE BACK ON OR MOVE THE SHIFTER INTO NEUTRAL TO GET OUT OF TRAFFIC. I TOWED THE VEHICLE TO THE DEALER WHO AFTER INSPECTION DID NOT IMMEDIATELY KNOW THE REASON. THEY REACHED OUT TO VW OF AMERICA WHO CONFIRMED WITH THEM AN ENTIRE FUEL SYSTEM REPLACEMENT WAS IN ORDER AS A RESULT OF A FAILED FUEL PUMP. THIS WOULD HAVE BEEN A MUCH MORE DANGEROUS SITUATION IF I WAS ON A MAJOR HIGHWAY OR GOING AT A FASTER SPEED. THE FACT THAT IT WAS DAYLIGHT OUT AND ON A STRAIGHT FLAT ROAD GREATLY ASSISTED ME IN STAYING SAFE. IF THIS HAD OCCURRED ON A BUSY INTERSECTION OR HIGH SPEED ROADS OR CURVES THE OUTCOME COULD HAVE BEEN MUCH DIFFERENT. *TR
MY VEHICLE'S ENGINE STUMBLED (MIS-FIRED), THEN THE ENGINE LINE CAME ON AND AS I COASTED TO THE SIDE OF THE ROAD THE ENGINE SHUT OFF. THE VEHICLE WOULD TURN OVER BUT NOT START. I THEN HAD IT TOWED TO THE DEALER. THE DEALER TOLD ME THAT THE ENTIRE FUEL SYSTEM NEEDS TO BE REPLACED. I UNDERSTAND THAT THERE IS AN EXISTING NTHSA I…
Read full complaint
MY VEHICLE'S ENGINE STUMBLED (MIS-FIRED), THEN THE ENGINE LINE CAME ON AND AS I COASTED TO THE SIDE OF THE ROAD THE ENGINE SHUT OFF. THE VEHICLE WOULD TURN OVER BUT NOT START. I THEN HAD IT TOWED TO THE DEALER. THE DEALER TOLD ME THAT THE ENTIRE FUEL SYSTEM NEEDS TO BE REPLACED. I UNDERSTAND THAT THERE IS AN EXISTING NTHSA ISSUE OPEN ON VOLKSWAGEN DIESELS. MY VEHICLE IS A 2009 VOLKSWAGEN TOUAREG TDI (TURBO DIESEL INJECTION). *TR
Official recalls
217V151000 · Fuel System, Gasoline
Mar 8, 2017
Volkswagen Group of America Inc. (Volkswagen) is recalling certain 2007-2010 Touareg vehicles. The fuel filter flange may crack and allow fuel to leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will inspect and replace the fuel filter flange if cracks are found. A protective cover will be applied to the fuel filter to prevent oxidization cracks from forming. These repairs will be made free of charge. The recall began August 3, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for the recall is 20Z4.
09V248000 · Structure:body
Jul 2, 2009
VOLKSWAGEN IS RECALLING 14,416 MY 2007-2009 TOUAREG VEHICLES. THE FASTENING STRUTS ON THE ROOF EDGE SPOILER CAN CRACK, CAUSING THE SPOILER TO BECOME LOOSE AND POSSIBLY DETACH FROM THE VEHICLE WITHOUT WARNING, EVEN THOUGH INITIALLY THE SPOILER MAY FEEL SECURE.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE SPOILER COULD CAUSE INJURY BY STRIKING PERSONS OUTSIDE THE VEHICLE OR COULD BECOME AN OBSTACLE TO OTHER DRIVERS, POSSIBLY RESULTING IN A CRASH.
Remedy: DEALERS WILL INSTALL REINFORCEMENT WEDGES TO THE ROOF EDGE SPOILER FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2009. OWNER MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA11003 · High-Pressure Fuel Pump Failure
Opened Feb 7, 2011 · Closed Mar 27, 2015
Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump
The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.
Fuel System, Other:delivery:fuel Pump
The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.