Counts are not failure probabilities and are not adjusted for sales, age, mileage exposure or reporting. One report may name several categories. Comparison method and limitations.
TL* THE CONTACT OWNS A 2009 VOLKSWAGEN TOUAREG. WHILE DRIVING VARIOUS SPEEDS ON AN INCLINE, THE VEHICLE MALFUNCTIONED AND THE ENGINE INDICATOR ILLUMINATED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE STRUGGLED TO ACCELERATE ON THE INCLINE AND DECELERATED. NEMER MOTOR GROUP OF LATHAN, NEW YORK AND HACKELS FOREIGN CAR SERV…
Read full complaint
TL* THE CONTACT OWNS A 2009 VOLKSWAGEN TOUAREG. WHILE DRIVING VARIOUS SPEEDS ON AN INCLINE, THE VEHICLE MALFUNCTIONED AND THE ENGINE INDICATOR ILLUMINATED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE STRUGGLED TO ACCELERATE ON THE INCLINE AND DECELERATED. NEMER MOTOR GROUP OF LATHAN, NEW YORK AND HACKELS FOREIGN CAR SERVICES OF ALBANY, NEW YORK WERE NOTIFIED AND THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 17V151000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.
NHTSA ODI #11015388
70,250 miles · May 4, 2016
Engine
WHILE DRIVING AFTER REFILLING THE DIESEL EXHAUST FLUID WITH PEAK BRAND ISO 22241-1 COMPLIANT DEF THE NO START IN 450 MILE WARNING CAME ON. TAKE IT IN FOR SERVICE AND THE VW DEALERSHIP REPLACES THE PUMP, HEATER, AND CONTROLLER. BUT THEY FAILED AT FLUSHING OUT THE LINES AND INJECTOR FOR WITHIN 50 MILES OF BEING PICKED UP THE WAR…
Read full complaint
WHILE DRIVING AFTER REFILLING THE DIESEL EXHAUST FLUID WITH PEAK BRAND ISO 22241-1 COMPLIANT DEF THE NO START IN 450 MILE WARNING CAME ON. TAKE IT IN FOR SERVICE AND THE VW DEALERSHIP REPLACES THE PUMP, HEATER, AND CONTROLLER. BUT THEY FAILED AT FLUSHING OUT THE LINES AND INJECTOR FOR WITHIN 50 MILES OF BEING PICKED UP THE WARNING FOR NO RESTART WAS BACK ON AND A CHECK ENGINE LIGHT ALSO NOW.
Volkswagen Group of America Inc. (Volkswagen) is recalling certain 2007-2010 Touareg vehicles. The fuel filter flange may crack and allow fuel to leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will inspect and replace the fuel filter flange if cracks are found. A protective cover will be applied to the fuel filter to prevent oxidization cracks from forming. These repairs will be made free of charge. The recall began August 3, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for the recall is 20Z4.
VOLKSWAGEN IS RECALLING 14,416 MY 2007-2009 TOUAREG VEHICLES. THE FASTENING STRUTS ON THE ROOF EDGE SPOILER CAN CRACK, CAUSING THE SPOILER TO BECOME LOOSE AND POSSIBLY DETACH FROM THE VEHICLE WITHOUT WARNING, EVEN THOUGH INITIALLY THE SPOILER MAY FEEL SECURE.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE SPOILER COULD CAUSE INJURY BY STRIKING PERSONS OUTSIDE THE VEHICLE OR COULD BECOME AN OBSTACLE TO OTHER DRIVERS, POSSIBLY RESULTING IN A CRASH.
Remedy: DEALERS WILL INSTALL REINFORCEMENT WEDGES TO THE ROOF EDGE SPOILER FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2009. OWNER MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.
Fuel System, Other:delivery:fuel Pump
The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.
Illustration