No warning prior to failure. At highway speed, Dashboard Notice: SYSTEM FAULT - SERVICE NOW. All electrical systems stopped working, including: Lighting - No Headlight/Running Light control- No Turn Signals- 4-Way Flashers worked, then stopped working- No Windshield Wipers- No interior Windshield defogger- No Side Window…
Read full complaint
No warning prior to failure. At highway speed, Dashboard Notice: SYSTEM FAULT - SERVICE NOW. All electrical systems stopped working, including: Lighting - No Headlight/Running Light control- No Turn Signals- 4-Way Flashers worked, then stopped working- No Windshield Wipers- No interior Windshield defogger- No Side Window Control for manual traffic signals- Do not know if Brake Lights were working- Mechanic states that battery was not charging- Some Dashboard displays were not working - Cruise control stopped working -
NHTSA ODI #11527464
Mileage unknown · Aug 23, 2022
Fuel/propulsion System
A fuel smell is detected in my vehicle, as noted in Repair Available for Safety Recall 20Z4 – Fuel Pump FlangeCertain 2007-2010 MY Volkswagen Touareg / NHTSA Campaign Number: 17V151000.
NHTSA ODI #11480792
112,000 miles · Dec 23, 2020
Fuel/propulsion System
DRIVING ON THE INTERSTATE A FAULT LIGHT STARTED FLASHING "ENGINE FAULT SERVICE NOW" ALONG WITH THE GLOW PLUG LIGHT. I PUT THE TRANSMISSION INTO NEUTRAL AND MOVED INTO THE SLOW LANE. THE ENGINE IMMEDIATELY STOPPED. I PUT ON MY HAZARD LIGHTS AND WAS ABLE TO ALLOW IT TO ROLL IT A SAFE PLACE TO PULL OVER. THE DEALERSHIP SAID THE HI…
Read full complaint
DRIVING ON THE INTERSTATE A FAULT LIGHT STARTED FLASHING "ENGINE FAULT SERVICE NOW" ALONG WITH THE GLOW PLUG LIGHT. I PUT THE TRANSMISSION INTO NEUTRAL AND MOVED INTO THE SLOW LANE. THE ENGINE IMMEDIATELY STOPPED. I PUT ON MY HAZARD LIGHTS AND WAS ABLE TO ALLOW IT TO ROLL IT A SAFE PLACE TO PULL OVER. THE DEALERSHIP SAID THE HIGH PRESSURE FUEL PUMP FAILED (HPFP) WHICH CAUSED THE ENGINE TO IMMEDIATELY STOP. LUCKILY I WAS IN AN AREA WHERE I COULD ROLL TO A SAFE PLACE AND WASN'T PULLING A TRAILER LIKE WE OFTEN DO. I WAS ALSO LUCKY I WAS IN AN AREA WITH CELL RECEPTION. I HAD SPENT MOST OF THE DAY DRIVING IN A REMOTE AREA THAT WOULDN'T HAVE HAD RECEPTION.
NHTSA ODI #11384688
Mileage unknown · Oct 21, 2019
Fuel/propulsion System
STARTED WITH FAINT SMELL OF GAS OUTSIDE OF VEHICLE ON DRIVERS SIDE. THE GAS SMELL IS STRONGEST WHEN VEHICLE HAS BEEN PARKED FOR SOME TIME LIKE OVER NIGHT. DEVELOPED OVERTIME THAT THE GAS SMELL BEGAN TO BE SMELLED INSIDE OF THE VEHICLE. CURRENTLY THE GAS SMELL IS EXTREMELY STRONG BOTH INSIDE AND OUTSIDE OF VEHICLE.
NHTSA ODI #11270051
155,000 miles · Feb 18, 2019
Air BagsStructure
THE DASHBOARD ON THE PASSENGER SIDE OF THE VEHICLE IS CRACKING ALL THE WAY AROUND THE AIR BAG CONTAINER. I FEAR SAFETY AND I AM AFRAID THAT THE AIR BAG WILL POP OUT THROUGH THE CRACKS AND CAUSE AN INJURY OR NOT BE FUNCTIONAL IF NEEDED. THE CRACKS HAVE BEEN SPREADING SLOWLY OVER TIME REGARDLESS IF THE VEHICLE IS IN MOTION. CUR…
Read full complaint
THE DASHBOARD ON THE PASSENGER SIDE OF THE VEHICLE IS CRACKING ALL THE WAY AROUND THE AIR BAG CONTAINER. I FEAR SAFETY AND I AM AFRAID THAT THE AIR BAG WILL POP OUT THROUGH THE CRACKS AND CAUSE AN INJURY OR NOT BE FUNCTIONAL IF NEEDED. THE CRACKS HAVE BEEN SPREADING SLOWLY OVER TIME REGARDLESS IF THE VEHICLE IS IN MOTION. CURRENTLY THE CRACKS ARE CLOSING IN TO THE FULL LINE AROUND THE AIR BAG CONTAINER. I WONDER WHAT WILL HAPPEN WHEN THE CRACK LINE IS COMPLETE. WILL THE AIRBAG POP OUT ON ITS OWN AND CAUSE AN INJURY? I WAS TOLD THAT THE AIR BAG PRESSURE IS CAUSING THE CRACKS.
NHTSA ODI #11180940
Mileage unknown · Sep 4, 2018
Fuel/propulsion System
THE VEHICLE SMELLED LIKE GAS INSIDE & OUT WHETHER STILL, OR DRIVING, RUNNING OR OFF. THEN A FEW DAYS IN, FUEL, OR A GAS-SMELLING SUBSTANCE, BEGAN RAPIDLY LEAKING FROM THE UNDERSIDE OF THE CAR. I WAS TOLD IT WAS ALSO COOLANT.
NHTSA ODI #11124448
110,000 miles · Aug 15, 2017
EngineFuel/propulsion System
TL* THE CONTACT OWNS A 2009 VOLKSWAGEN TOUAREG. WHILE DRIVING VARIOUS SPEEDS ON AN INCLINE, THE VEHICLE MALFUNCTIONED AND THE ENGINE INDICATOR ILLUMINATED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE STRUGGLED TO ACCELERATE ON THE INCLINE AND DECELERATED. NEMER MOTOR GROUP OF LATHAN, NEW YORK AND HACKELS FOREIGN CAR SERV…
Read full complaint
TL* THE CONTACT OWNS A 2009 VOLKSWAGEN TOUAREG. WHILE DRIVING VARIOUS SPEEDS ON AN INCLINE, THE VEHICLE MALFUNCTIONED AND THE ENGINE INDICATOR ILLUMINATED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE STRUGGLED TO ACCELERATE ON THE INCLINE AND DECELERATED. NEMER MOTOR GROUP OF LATHAN, NEW YORK AND HACKELS FOREIGN CAR SERVICES OF ALBANY, NEW YORK WERE NOTIFIED AND THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 17V151000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.
NHTSA ODI #11015388
90,500 miles · Jul 8, 2017
Fuel/propulsion System
THERE IS AN OPEN, PENDING RECALL ON THE FUEL FILTER ASSEMBLY. IT IS NOTICED BY THE SMELL OF GASOLINE OUTSIDE AND POSSIBLY INSIDE THE CABIN, MOSTLY COMING FROM THE DRIVER'S SIDE REAR DOOR AS THE ASSEMBLY IS UNDER THE BACK SEAT ON THAT SIDE OF THE VEHICLE.
NHTSA ODI #11003786
Mileage unknown · Jun 26, 2016
Air BagsUnknown Or Other
THE DASH ON THE PASSENGER SIDE OF THE VEHICLE IS CRACKING ALL THE WAY AROUND THE AIRBAG CONTAINER. I FEAR THAT THE AIRBAG WILL BE ABLE TO COME LOSE AND POSSIBLY CAUSE INJURY OR BECOME NON FUNCTIONAL AND THUS UNSAFE WHEN IN NEED
NHTSA ODI #10876708
70,250 miles · May 4, 2016
Engine
WHILE DRIVING AFTER REFILLING THE DIESEL EXHAUST FLUID WITH PEAK BRAND ISO 22241-1 COMPLIANT DEF THE NO START IN 450 MILE WARNING CAME ON. TAKE IT IN FOR SERVICE AND THE VW DEALERSHIP REPLACES THE PUMP, HEATER, AND CONTROLLER. BUT THEY FAILED AT FLUSHING OUT THE LINES AND INJECTOR FOR WITHIN 50 MILES OF BEING PICKED UP THE WAR…
Read full complaint
WHILE DRIVING AFTER REFILLING THE DIESEL EXHAUST FLUID WITH PEAK BRAND ISO 22241-1 COMPLIANT DEF THE NO START IN 450 MILE WARNING CAME ON. TAKE IT IN FOR SERVICE AND THE VW DEALERSHIP REPLACES THE PUMP, HEATER, AND CONTROLLER. BUT THEY FAILED AT FLUSHING OUT THE LINES AND INJECTOR FOR WITHIN 50 MILES OF BEING PICKED UP THE WARNING FOR NO RESTART WAS BACK ON AND A CHECK ENGINE LIGHT ALSO NOW.
Volkswagen Group of America Inc. (Volkswagen) is recalling certain 2007-2010 Touareg vehicles. The fuel filter flange may crack and allow fuel to leak out.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will inspect and replace the fuel filter flange if cracks are found. A protective cover will be applied to the fuel filter to prevent oxidization cracks from forming. These repairs will be made free of charge. The recall began August 3, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for the recall is 20Z4.
VOLKSWAGEN IS RECALLING 14,416 MY 2007-2009 TOUAREG VEHICLES. THE FASTENING STRUTS ON THE ROOF EDGE SPOILER CAN CRACK, CAUSING THE SPOILER TO BECOME LOOSE AND POSSIBLY DETACH FROM THE VEHICLE WITHOUT WARNING, EVEN THOUGH INITIALLY THE SPOILER MAY FEEL SECURE.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE SPOILER COULD CAUSE INJURY BY STRIKING PERSONS OUTSIDE THE VEHICLE OR COULD BECOME AN OBSTACLE TO OTHER DRIVERS, POSSIBLY RESULTING IN A CRASH.
Remedy: DEALERS WILL INSTALL REINFORCEMENT WEDGES TO THE ROOF EDGE SPOILER FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2009. OWNER MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.
Fuel System, Other:delivery:fuel Pump
The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.
2009 Volkswagen Touareg Problems, Complaints & Recalls | Skip That Year
Illustration