IllustrationTHE STEERING WHEEL LOCKING DEVICE DOES NOT BLOCK THE STEERING WHEEL ANY MORE AFTER PARKING THE VEHICLE AND REMOVING THE KEY IGNITION LOCK. INSTEAD WHEN TURNING THE STEERING WHEEL THERE IS A PRONOUNCED RATTLING NOISE COMING FROM INSIDE THE STEERING WHEEL. THE WHEEL LOCKING MECHANISM DOES NOT WORK.
2005 Volkswagen Touareg
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Volkswagen Touareg do not stand out strongly from the model-year median of 27.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Touareg years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
325–50K
1050–75K
1275–100K
13100–150K
0150K+
58 reports with mileage · 17 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports1 injury reports
Steering complaints
4 reportsTHE STEERING LOCK AND WAS UNABLE TO OPEN OR MOVE. *TR
2005 VOLKSWAGEN TOUAREG. CONSUMER STATES WHEN HE INSERTS THE KEY INTO THE IGNITION TO START THE VEHICLE, IT DOES NOT START. THE CONSUMER STATED IF HE REMOVED THE KEY, PRESSED THE LOCK BUTTON AND THEN THE UNLOCK THE BUTTON ON THE KEY FOB, THEN TRY AGAIN, THE VEHICLE GENERALLY STARTED UP. WHEN THE VEHICLE DID NOT START, THE VEHIC…
Read full complaint
2005 VOLKSWAGEN TOUAREG. CONSUMER STATES WHEN HE INSERTS THE KEY INTO THE IGNITION TO START THE VEHICLE, IT DOES NOT START. THE CONSUMER STATED IF HE REMOVED THE KEY, PRESSED THE LOCK BUTTON AND THEN THE UNLOCK THE BUTTON ON THE KEY FOB, THEN TRY AGAIN, THE VEHICLE GENERALLY STARTED UP. WHEN THE VEHICLE DID NOT START, THE VEHICLE WOULD HAVE TO BE TOWED, AS THE TRANSMISSION WOULD NOT SHIFT OUT OF PARK. THE CONSUMER STATED THE VEHICLE HAS BEEN TO THE DEALER 12 TIMES TO CORRECT THE SAME ISSUE. TO DATE, THE ACCESS/START MODULE WAS REPLACED FOUR TIMES, THE STEERING COLUMN WAS REPLACED THREE TIMES, THE IGNITION SWITCH WAS REPLACED TWICE, THE J519 VEHICLE ELECTRICAL CONTROL UNIT AND BATTERY WERE ALSO REPLACED. *JB
MY 05 VW TOUAREG V8 HAS HAD A FAILED AIR BAG SENSOR, SUNROOF INSULATION, STEERING WHEEL SHAKE AT VARIED SPEEDS, AND A SERIOUS ALIGNMENT ISSUE SINCE THE FIRST DAY OF OWNERSHIP. AFTER 6 DIFFERENT TRIPS BACK TO THE DEALERSHIP, THEY CAN'T SEEM TO FIX THE SHAKING AND THE ALIGNMENT PROBLEM. THERE ARE MANY FORUMS AND BLOGS ON THE NET…
Read full complaint
MY 05 VW TOUAREG V8 HAS HAD A FAILED AIR BAG SENSOR, SUNROOF INSULATION, STEERING WHEEL SHAKE AT VARIED SPEEDS, AND A SERIOUS ALIGNMENT ISSUE SINCE THE FIRST DAY OF OWNERSHIP. AFTER 6 DIFFERENT TRIPS BACK TO THE DEALERSHIP, THEY CAN'T SEEM TO FIX THE SHAKING AND THE ALIGNMENT PROBLEM. THERE ARE MANY FORUMS AND BLOGS ON THE NET REGARDING A GENUINE DEFECT IN DESIGN OF THIS VEHICLE WHICH DOESN'T ALLOW IT TO DRIVE STRAIGHT. ALL OF THE LOANER TOUAREGS MODEL YEARS 06/07 HAVE HAD SIMILAR ALIGNMENT PROBLEMS, SO I DON'T THINK IT IS JUST MY VEHICLE IT IS A GREAT NUMBER OF THESE VEHICLES WITH THE SAME PROBLEMS. VW NEEDS TO STEP UP TO THE PLATE AND TAKE CARE OF THEIR CUSTOMERS. THIS IS NOT A CHEAP VEHICLE AND THE SUPPORT IS WORST THEN ANY COMPANY I'VE EVER DEALT WITH. THE CUSTOMER SERVICE REPRESENTATIVES ANSWER TO MY PROBLEM IS "I RECOMMEND YOU KEEP TAKING THE VEHICLE BACK TO ANY DEALERSHIP OF YOUR CHOICE UNTIL THE ISSUE IS RESOLVED UNDER THE MANUFACTURER'S WARRANTY PERIOD". THIS MEANS THAT FOR THE NEXT FIVE YEARS I HAVE TO TAKE THIS VEHICLE BACK TO THEM ON A WEEKLY BASIS FOR THEM TO TRY TO FIX A PROBLEM IN THEIR DESIGN. I JUST DON'T THINK IT IS FAIR TO A CONSUMER WHO COUGHS UP BIG BUCKS TO PURCHASE A VEHICLE AND THE VEHICLE IS FLAWED FROM THE FIRST DAY. *NM
Official recalls
217V583000 · Fuel System, Gasoline:delivery:fuel Pump
Sep 20, 2017
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2004-2007 Touareg vehicles. These gasoline-powered vehicles have a fuel filter flange that may crack, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will inspect the fuel filter flange for cracks, replacing the flange if cracks are found. If no cracks are found, a protective cover will be installed onto the filter flange. These repairs will be performed free of charge. The recall began March 9, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20Ai.
04V592000 · Seat Belts
Dec 15, 2004
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." ALL THREE REAR SEAT POSITIONS AND THE FRONT PASSENGER POSITION ARE EQUIPPED WITH SEAT BELT RETRACTORS THAT HAVE A LOCKING FEATURE WHICH CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) MODE TO AN AUTOMATIC LOCKING RETRACTOR (ALR) MODE FOR THE PURPOSES OF CHILD RESTRAINT INSTALLATION. THE BELT MAY DEACTIVATE THE ALR MODE WITH CERTAIN CHILD RESTRAINTS.
Consequence & remedy
Consequence: WHEN INVOLVED IN A CRASH, THE CHILD RESTRAINTS MAY NOT BE PROPERLY SECURED, INCREASING THE RISK OF INJURIES OR DEATH.
Remedy: DEALERS WILL PERMANENTLY INSTALL A 'CLIP' IN EACH OF THE TWO REAR OUTBOARD SEAT BELTS. THE CLIPS WILL PREVENT UNWANTED DEACTIVATION OF THE ALR MODE WITH CHILD SEAT INSTALLATIONS. THE RECALL BEGAN ON APRIL 11, 2005. OWNERS SHOULD CONTACT VW AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06022 · Srs Warning Light Illumination
Opened Jun 19, 2006 · Closed Oct 30, 2006
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window
MY 2004-05 (TO 11/2004) TOUAREG VEHICLES HAVE A POTENTIALLY FAULTY/LOOSE SIDE AIR BAG WIRING CONNECTOR THAT CAN CAUSE THE WIRING CIRCUIT RESISTANCE TO EXCEED THE DESIGN LIMIT AND ILLUMINATE THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG LIGHT.ON 02/2005, VW ISSUED A TECHNICAL SERVICE BULLETIN (TSB #69-05-02) TO ADDRESS THIS CONDITION BY REPLACING THE CONNECTOR WITH A DIRECT CONNECTION.VW'S TESTING HAS SHOWN THAT PROPER DEPLOYMENT OF THE SIDE AIR BAG IS NOT AFFECTED BY THE CONNECTOR FAULT.HOWEVER, THERE ARE A LARGE NUMBER OF WARRANTY CLAIMS DUE TO AIR BAG LIGHT (ABL) ILLUMINATION.VW IS PLANNING TO INITIATE A TOUAREG SERVICE PACK/ CUSTOMER SATISFACTION CAMPAIGN (CSC) IN DECEMBER 2006.VW WILL REPLACE THE SIDE AIR BAG WIRING CONNECTOR WITH A DIRECT CONNECTION ON ALL REMAINING UNCORRECTED VEHICLES BUILT PRIOR TO 11/2004.IN ADDITION, VW REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN OCTOBER AND NOVEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIR BAG MODULE.THIS ALSO MAY PRODUCE ABL ILLUMINATION THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.VW HAS NOT RECEIVED ANY ALLEGED SIDE AIR BAG NON-DEPLOYMENT REPORT.ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Air Bags:side/window
MY 2004-05 (TO 11/2004) TOUAREG VEHICLES HAVE A POTENTIALLY FAULTY/LOOSE SIDE AIR BAG WIRING CONNECTOR THAT CAN CAUSE THE WIRING CIRCUIT RESISTANCE TO EXCEED THE DESIGN LIMIT AND ILLUMINATE THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG LIGHT.ON 02/2005, VW ISSUED A TECHNICAL SERVICE BULLETIN (TSB #69-05-02) TO ADDRESS THIS CONDITION BY REPLACING THE CONNECTOR WITH A DIRECT CONNECTION.VW'S TESTING HAS SHOWN THAT PROPER DEPLOYMENT OF THE SIDE AIR BAG IS NOT AFFECTED BY THE CONNECTOR FAULT.HOWEVER, THERE ARE A LARGE NUMBER OF WARRANTY CLAIMS DUE TO AIR BAG LIGHT (ABL) ILLUMINATION.VW IS PLANNING TO INITIATE A TOUAREG SERVICE PACK/ CUSTOMER SATISFACTION CAMPAIGN (CSC) IN DECEMBER 2006.VW WILL REPLACE THE SIDE AIR BAG WIRING CONNECTOR WITH A DIRECT CONNECTION ON ALL REMAINING UNCORRECTED VEHICLES BUILT PRIOR TO 11/2004.IN ADDITION, VW REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN OCTOBER AND NOVEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIR BAG MODULE.THIS ALSO MAY PRODUCE ABL ILLUMINATION THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.VW HAS NOT RECEIVED ANY ALLEGED SIDE AIR BAG NON-DEPLOYMENT REPORT.ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags
MY 2004-05 (TO 11/2004) TOUAREG VEHICLES HAVE A POTENTIALLY FAULTY/LOOSE SIDE AIR BAG WIRING CONNECTOR THAT CAN CAUSE THE WIRING CIRCUIT RESISTANCE TO EXCEED THE DESIGN LIMIT AND ILLUMINATE THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG LIGHT.ON 02/2005, VW ISSUED A TECHNICAL SERVICE BULLETIN (TSB #69-05-02) TO ADDRESS THIS CONDITION BY REPLACING THE CONNECTOR WITH A DIRECT CONNECTION.VW'S TESTING HAS SHOWN THAT PROPER DEPLOYMENT OF THE SIDE AIR BAG IS NOT AFFECTED BY THE CONNECTOR FAULT.HOWEVER, THERE ARE A LARGE NUMBER OF WARRANTY CLAIMS DUE TO AIR BAG LIGHT (ABL) ILLUMINATION.VW IS PLANNING TO INITIATE A TOUAREG SERVICE PACK/ CUSTOMER SATISFACTION CAMPAIGN (CSC) IN DECEMBER 2006.VW WILL REPLACE THE SIDE AIR BAG WIRING CONNECTOR WITH A DIRECT CONNECTION ON ALL REMAINING UNCORRECTED VEHICLES BUILT PRIOR TO 11/2004.IN ADDITION, VW REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN OCTOBER AND NOVEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIR BAG MODULE.THIS ALSO MAY PRODUCE ABL ILLUMINATION THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.VW HAS NOT RECEIVED ANY ALLEGED SIDE AIR BAG NON-DEPLOYMENT REPORT.ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE05042 · Exterior Door Handle Malfunction
Opened Aug 11, 2005 · Closed Dec 21, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
VW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) DATED JUNE 10, 2005, DESCRIBING A CONDITION OF EXTERIOR DOOR HANDLE STICKS IN THE OPENED POSITION AFTER THE DOOR IS OPENED.VW DESCRIBED THE CAUSE OF THE PROBLEM TO BE A POTENTIAL FOR INCREASED FRICTION BETWEEN THE DOOR HANDLE AND THE LOCK CYLINDER HOUSING . . . BECAUSE SOME GUIDE NUBS THAT WERE MOLDED INTO THE PLASTIC DOOR HANDLE . . . WERE SLIGHTLY HIGHER THAN SPECIFIED.IN ADDITION TO THE TSB, VW HAS INTRODUCED PRODUCTION CHANGES (LUBRICATION, DELETION OF THE GUIDE NUBS, INTRODUCTION OF A LOW FRICTION GUIDE SURFACE ON THE LOCK CYLINDER HOUSING) TO ADDRESS THE PROBLEM.VW REPORTS THAT THE FAILURE OCCURS PREDOMINANTLY IN THE VERY EARLY LIFE STAGE OF THE VEHICLE.ODI EXAMINATION OF VW'S WARRANTY DATA SHOWS FEWER CLAIMS AS THE VEHICLE AGES.THE ONE INJURY RESULTED WHEN THE UNLATCHED DOOR HIT THE OCCUPANT'S HAND.A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTINUE TO MONITOR COMPLAINTS ANDRESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.