2009 Volkswagen Routan

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE DRIVING APPROXIMATELY 15 MPH, THE STEERING WHEEL JERKED AND THE VEHICLE SHUT OFF. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 15V194000 (ELECTRICAL SYSTEM), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE VEHICLE WAS TAKEN BACK TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 74,000.

ON 6/21/15, I WAS DRIVING ON THE HIGHWAY WITH CRUISE CONTROL SET AT APPROXIMATELY 75MPH. I WAS NOT ACCELERATING, NOR HAD MY FOOT ON THE GAS OR BRAKE PETAL. WITHOUT ANY WARNING, THE GAS PETAL PUSHED TO THE FLOOR AND THE VEHICLE BEGAN ACCELERATING QUICKLY. I IMMEDIATELY TURNED ON MY HAZARDS AND TURNED OFF THE CRUISE, BUT THE VEHICLE CONTINUED TO ACCELERATE IN EXCESS OF 100MPH. I FEARED COLLIDING WITH OTHER DRIVERS ON THE TWO-LANED HIGHWAY, AND BEGAN BRAKING AGAINST THE CAR'S ACCELERATION, WHICH WAS QUITE DIFFICULT. I PUSHED THE BRAKE PETAL DOWN AS HARD AS I COULD, WHICH STOPPED FURTHER ACCELERATION; BUT DID NOT SLOW THE VEHICLE QUICKLY. THE VEHICLE CONTINUED TO REV UP AND TRIED RELENTLESSLY TO ACCELERATE AGAINST MY BEST EFFORTS TO BRAKE. I WAS ABLE TO MOVE THE VEHICLE TO THE GRAVEL SHOULDER. ONCE I WAS ABLE TO SLOW THE VEHICLE TO AROUND 20MPH, I TURNED OFF THE VEHICLE AND COASTED TO A STOP. THERE WAS A STRONG SMELL OF SMOKE FROM THE BRAKES. I BELIEVED THE PROBLEM WAS RELATED TO A CRUISE CONTROL MALFUNCTION OR A RELATED SENSOR. I DISCONTINUED USING THE CRUISE AT ANY TIME. HOWEVER, ON 7/9/15, THE SAME PROBLEM OCCURRED. THIS TIME, THE CRUISE WAS NOT SET, AND THE VEHICLE WAS TRAVELING AT APPROXIMATELY 50MPH IN HEAVY TRAFFIC DURING RUSH HOUR ON A THREE LANE FREEWAY. THE SAME STEPS NOTED ABOVE SLOWED THE VEHICLE AFTER IT BEGAN ACCELERATING OUT OF CONTROL, MAKING IT DIFFICULT TO NAVIGATE THROUGH THE SURROUNDING VEHICLES. THE GAS PETAL WAS AGAIN STUCK TO THE FLOOR AND COULD NOT BE PULLED UP. AFTER THE SECOND OCCURRENCE, THERE IS LIKELY SIGNIFICANT DAMAGE TO THE BRAKES AND/OR ENGINE. I CONTACTED A VOLKSWAGEN DEALERSHIP, THAT PLANS TO DIAGNOSE THE VEHICLE. I AM FEARFUL OF DRIVING THE VEHICLE TO THE DEALERSHIP, BUT WAS INSTRUCTED BY THE VW SALES MANAGER TO BRING THE VEHICLE IN FOR INSPECTION AND BE SURE TO TURN THE KEY TO "OFF" OR "ACCESSORY" SHOULD THE PROBLEM OCCUR AGAIN.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V194000 (ELECTRICAL SYSTEM); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE VIN WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

I DRIVING LAST MONTH 47 MPH AND MY DRIVING SLIDING DOOR OPEN AND MY 8 YEARS GIRLS WAS DEAR AND SHE SCARE WHEN THE DOOR OPEN WHEN I DRIVING ,, AND WHEN I STOP THE DOOR NOT WANT TO CLOSE AUTOMATIC..THAT SCARE ME AND MY WIFE... THE OTHER CONCERN IS MY TRANSMISION HARD SHIFFTING ,HARD SHIFFTING , I READY TAKE LIKE 5,6 TIME MY VAN TO CHECK MY TRANSMISSION AND MY SLIDING DOOR AND THE SAY IS NORMAL , AND MY SLIDING DOOR NOT FOUND ANYTIME , THEY SAY THE SLIDING DOOR RECALL WAS DONE READY,, THE OTHER BIG CONCERN IS THE GAS MILEAGE, ONLY 11 OR 12 GALLON FOR MILES THEY DID A LOT TEST AND NOT FOUND NOTHING ,,IS POSS TO 16 MPH FOR GALLON AND NEVER HAVE THAT,,.... THANKS.

THE ELECTRONIC DRIVER SIDE PASSENGER DOOR WILL NOT LATCH OPEN. THE DOOR WILL POWER OPEN THEN SLIDE BACK SHUT HITTING WHOEVER OR WHATEVER IS IN THE WAY. THIS IS AN INTERMITTENT PROBLEM. THE VAN WAS CHECKED BY OUR LOCAL DEALER SEVERAL TIMES OVER SEVERAL YEARS. THIS IS STILL AN ISSUE. THIS HAS LED TO MYSELF AND CHILDREN BEING HIT BY THE DOOR LEAVING BRUISES. IT ALMOST SMASHED MY 2 YEAR OLD DAYCARE CHILD'S LEG IN THE DOOR BUT I INTERVENED STOPPING THE DOOR PRIOR TO IT HITTING HER. I HAVE LOOKED ON THE INTERNET AND FOUND SEVERAL OTHER COMPLAINTS ALSO WITH NO REMEDY FROM VW.

I BOUGHT THIS ROUTAN APROX 8 MONTHS AGO,NOTHING BUT PROBLEMS,IT HAS SHUT DOWN IN CITY TRAFFIC AND HIGHWAY SPEEDS,I AM AWARE OF RECALL #28H1 FROM VW THAT 2 VW DEALERSHIPS DENY EVEN EXIST.THE DEALER I BOUGHT THIS FROM TEST AND DIAGNOSED IT AS A DEFECTIVE WINS MODULE { IGNITION SWITCH } AND CONTACTED A VW DEALERSHIP IN BARRE VERMONT AND SAID THEY WOULD ORDER A MODULE AND SCHEDULED A DATE TO INSTALL IT,A COUPLE OF DAYS BEFORE APPOINTMENT I MYSELF DECIDE TO BRING IN MYSELF AND CALLED TO VERIFY THE DATE AND TIME,THERE SERVICE DEPARTMENT ASKED ME FOR A RECALL NUMBER OF WHICH AT THE TIME I DID NOT HAVE BECAUSE MY SERVICE MANAGER WHERE I BOUGHT IT FROM SET THIS UP.AFTER TRACKING DOWN THE CORRECT SERVICE REP AT WALKER VW IN BARRE VERMONT SHE INFORMED ME THEY DID NOT ORDER THE PART AND THERE IS NO WINS MODULES AVAILABLE YET 06/01/15 EVEN THOUGH THIS RECALL WAS DATED IN MARCH OF 2014 ,STILL NO FIX WHATS UP WITH THAT ? I GUESS OUR LIVES AND THE LIVES OF OUR LOVED ONES DO NOT MATTER IT IS TIME FOR SOMEONE OR THE NHTSA TO IMPOSE SOME SERIOUS PREASURE ON VOLKSWAGON AND DEMAND THAT OUR VEHICLES BE REPAIRED CORRECTLY THEY SHOULD BE BROUGHT UP ON CHARGES FOR DECEIVEING THE PUBLIC.EVEN MY OWN DEALERSHIP HAS NOT BEEN TELLING ME EVERYTHING UNTIL I CORNER THEM OR CATCH THEM OFF GUARD, COME TO FIND OUT AFTER SQUEEZING IT OUT OF MY OWN LOCAL SERVICE MANAGER IS THAT A WINS MODULE HAD ALREADY BEEN REPLACED IN MY ROUTAN FOR THE PRIOR OWNER,PROBABLY TO PASIFY THE CUSTOMER.I AM AT THIS POINT LOOKING AT THE LEGAL GROUNDS WE ALL SHOULD HAVE AGAINST THESE CORPERATIONS LIKE VOLKSWAGON OR EVEN CHRYSLER SINCE THEY PRODUCED ROUTANS FOR VOLKSWAGON. I WOULD HATE TO TRADE THIS VEHICLE IN JUST FOR SOME OTHER SAP TO BE STUCK WITH A LEMON .ITS JUST NOT SAFE OR DEPENDABLE AND WE HAVE A LONG TRIP IN TWO DAYS 50/50 CHANCE WE MAKE IT DOWN AND BACK WITH KNOW PROBLEMS ???

2009 VOLKSWAGEN ROUTAN. CONSUMER WRITES IN REGARDS TO REPLACEMENTS OF TIRE VALVE STEMS. *SMD THE CONSUMER STATED WITHIN THE LAST TEN MONTHS, SHE HAD TO REPLACE THE VALVE STEMS AND TIRE SENSORS THREE TIMES DUE TO DISINTEGRATION OF THE VALVE STEMS, TWICE ON THE RIGHT FRONT TIRE. THE FIRST TIME THE INCIDENT HAPPENED, THE LOW TIRE PRESSURE LIGHT ILLUMINATED. THE CONSUMER STOPPED AND CHECKED THE TIRES. THE RIGHT FRONT TIRE APPEARED TO BE LOW. WHEN SHE ATTEMPTED TO ATTACH THE AIR HOSE, THE TIRE IMMEDIATELY WENT FLAT AND THE VALVE STEM SUCKED INTO THE TIRE. THE SECOND TIME, THE LOW TIRE LIGHT ILLUMINATED, SHE STOPPED AND OBSERVED THE RIGHT FRONT TIRE WAS LOW. THE TIRE WAS GOING FLAT, AS SHE APPROACHED THE SERVICE STATION. AAA REMOVED THE CAP TO THE VALVE STEM WHICH DISINTEGRATED IMMEDIATELY. THE SLOW LEAK RESULTED IN THE CONSUMER HAVING TO PURCHASE A NEW TIRE, VALVE AND TIRE SENSOR. THE THIRD TIME, THE TIRE LIGHT ILLUMINATED AGAIN. IT WAS DETERMINED THE VALVE STEM WAS LEAKING . THE CONSUMER WAS INFORMED THE REPLACEMENT OF THE VALVE STEMS WAS A FREQUENT OCCURRENCE, THE METAL VALVE STEMS WERE APPARENTLY INFERIOR TO TRADITIONAL RUBBER STEMS. *JB

THE FIRST INCIDENT WITH A "CLUNKING" NOISE OF THE TRANSMISSION BEGAN ON 7/10/2014 AT 51,496 MILES. WHEN SHIFTING FROM REVERSE TO DRIVE CAR MAKES A "CLUNKING" NOISE AND JERKS THE CAR FORWARD. IT WAS NOTED BY DEALERSHIP AFTER A TEST DRIVE NO FAULTS FOUND. ON 3/19/15 AT 58,611 MILES CAR RETURNED TO DEALERSHIP. SAME CLUNKING AND GRINDING NOISES. FAULTS: P0868, P1790 & P0944. PRESSURE READINGS TO LOW IN TCM CONTROL WIRES. TRANSMISSION TO BE REPLACED PER DEALERSHIP. FINDINGS: UNDER DRIVE CLUTCHES WORN OUT, SUNGEARS AND ASSEMBLY DAMAGED WITH METAL METAL FRAGMENTS. ON 4/30/2015 AND 59,215 MILES, CAR RETURNED TO DEALERSHIP FOR SAME GRINDING AND CLUNKING NOISES. DEALERSHIP PERFORMED ANOTHER "QUICK LEARN TEST." AS OF 5/19/2015 AND 60,001 MILES, TRANSMISSION IS STILL GRINDING AND CLUNKING ON OCCASION DURING ACCELERATION AND/OR TRANSMISSION SHIFT FROM REVERSE TO DRIVE. THE VEHICLE ALSO RANDOMLY "STALLS" WHILE AT STOPLIGHTS/STOP-SIGNS WITH NO NORMAL FREQUENCY. EVEN WITH A NEW TRANSMISSION, SAME ISSUES ARE STILL SURROUNDING THIS CAR. THANKS.

I WENT TO PASS A VEHICLE AT 65MPH AND THE ACCELERATOR PEDAL DID NOT RELEASE, THE VAN HIT 80-MPH BEFORE I POPPED IT IN NEUTRAL AND THEN BACK INTO DRIVE TO CORRECT THE ISSUE. HITTING THE BRAKES HAD NO EFFECT ON THE UNINTENDED ACCELERATION. THIS VEHICLE IS MECHANICALLY IDENTICAL TO CHRYSLER TOWN & COUNTRY AND DADGE GRAND CARAVAN, SEE OTHER IDENTICAL COMPLAINTS HERE: HTTP://FORUMS.EDMUNDS.COM/DISCUSSION/14835/DODGE/VOYAGER/DODGE-GRAND-CARAVAN-SUDDEN-ACCELERATION? *TR