NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
131 reportsClear category filter72,000 miles · Dec 21, 2023
Engine And Engine Cooling
The contact owns a 2003 Volkswagen Passat. The contact stated that while driving at an undisclosed speed, coolant leaked onto the front passenger’s side floorboard. The contact stated that the coolant leak was underneath the glove compartment area. The vehicle was taken to an independent mechanic, and the contact was advised to …
Read full complaint
The contact owns a 2003 Volkswagen Passat. The contact stated that while driving at an undisclosed speed, coolant leaked onto the front passenger’s side floorboard. The contact stated that the coolant leak was underneath the glove compartment area. The vehicle was taken to an independent mechanic, and the contact was advised to have the vehicle taken to the Volkswagen dealer. The contact visited the dealer and discussed the reoccurring failure and was informed that the heater coil was designed incorrectly, and the failure was due to the design of the heater coil. The contact was informed that the heater coil needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 72,000.
NHTSA ODI #11561345
124,675 miles · Jun 7, 2018
EngineEngine And Engine Cooling
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE PULLING OUT OF THE DRIVEWAY, THE CONTACT STATED THAT COOLANT WAS LEAKING FROM THE VEHICLE. THE LOW COOLANT WARNING INDICATOR ILLUMINATED AND AN ABNORMAL BEEPING SOUND WAS HEARD WHILE DRIVING VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND IT WAS DIAGNOSED …
Read full complaint
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE PULLING OUT OF THE DRIVEWAY, THE CONTACT STATED THAT COOLANT WAS LEAKING FROM THE VEHICLE. THE LOW COOLANT WARNING INDICATOR ILLUMINATED AND AN ABNORMAL BEEPING SOUND WAS HEARD WHILE DRIVING VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND IT WAS DIAGNOSED THAT THE COOLANT LEAK WAS DUE TO AN ENGINE FAILURE THAT WAS NOT REPAIRABLE. THE DEALER WAS NOT CONTACTED FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 124,675. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #11100442
100,000 miles · May 8, 2015
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING BELT NEEDED TO BE REPLACED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14E007000 (ENGINE AND…
Read full complaint
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING BELT NEEDED TO BE REPLACED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14E007000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10715327
83,000 miles · Apr 26, 2015
Engine And Engine Cooling
ENGINE LIGHTS COME ON. CAR AT TIMES START SHAKING - NOT CONSISTENTLY THOUGH. TOOK IT TO SHOP: FOUND OUT IGNITION COILS MISFIRES. THIS HAS OCCURRED 4 TIMES IN A 2 YEAR TIME SPAN. THE MOST RECENT 2 BEING A MONTH APART. THE MOST RECENT INCIDENT BURNED ALMOST ALL OF THE SPARK PLUGS. DID RESEARCH AND THIS WEBSITE DESCRIBES MY …
Read full complaint
ENGINE LIGHTS COME ON. CAR AT TIMES START SHAKING - NOT CONSISTENTLY THOUGH. TOOK IT TO SHOP: FOUND OUT IGNITION COILS MISFIRES. THIS HAS OCCURRED 4 TIMES IN A 2 YEAR TIME SPAN. THE MOST RECENT 2 BEING A MONTH APART. THE MOST RECENT INCIDENT BURNED ALMOST ALL OF THE SPARK PLUGS. DID RESEARCH AND THIS WEBSITE DESCRIBES MY SITUATION PERFECTLY: HTTP://WWW.VWPROBLEMS.COM/TRENDS/IGNITION-COIL/. *TR
NHTSA ODI #10712966
135,652 miles · Jul 14, 2012
Engine And Engine CoolingFuel/propulsion System
FUEL SUPPLY LINE BEGAN LEAKING AT MOUNTING POINT ON FIREWALL ABOVE CATALYTIC CONVERTER. BREAK/CRACK IN LINE WAS SIGNIFICANT AND POSED A HIGH PROBABILITY OF FIRE, AS ANY FUEL LEAK, BUT SUBSTANTIALLY MORE SO DUE TO THE LOCATION ABOVE THE CATALYTIC CONVERTER. *TR
NHTSA ODI #10465667
113,008 miles · May 8, 2012
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE CONTACT ALSO STATED THAT THE VEHICLE EMITTED A NOISE IN WHICH IT SOUNDED LIKE IT WAS LOW ON FUEL. THE VEHICLE HAD NOT BEEN TAKEN TO THE DEALER. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS NOT UNDER RECALL. TH…
Read full complaint
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE CONTACT ALSO STATED THAT THE VEHICLE EMITTED A NOISE IN WHICH IT SOUNDED LIKE IT WAS LOW ON FUEL. THE VEHICLE HAD NOT BEEN TAKEN TO THE DEALER. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS NOT UNDER RECALL. THE MANUFACTURER ALSO STATED THAT THEY WERE NOT RESPONSIBLE FOR REPAIRS. THE FAILURE AND CURRENT MILEAGES WERE 113,008.
NHTSA ODI #10457764
85,000 miles · Jan 24, 2012
Engine And Engine Cooling
AT A STOPLIGHT CAR BEGAN TO SHAKE AND SPUTTER, I MADE IT HOME WITH THE CAR SHAKING THE ENTIRE TIME. HAD TO REPLACE COILS. HAVE BROKEN DOWN TWICE AND HAD TO HAVE CAR TOWED SINCE THEN AND REPLACE COILS. NOT TOO MENTION THE OTHER SEVERAL TIMES COILS WERE REPLACED WITHOUT THE CAR ACTUALLY BREAKING DOWN. DUE TO THE COILS CONSTANT…
Read full complaint
AT A STOPLIGHT CAR BEGAN TO SHAKE AND SPUTTER, I MADE IT HOME WITH THE CAR SHAKING THE ENTIRE TIME. HAD TO REPLACE COILS. HAVE BROKEN DOWN TWICE AND HAD TO HAVE CAR TOWED SINCE THEN AND REPLACE COILS. NOT TOO MENTION THE OTHER SEVERAL TIMES COILS WERE REPLACED WITHOUT THE CAR ACTUALLY BREAKING DOWN. DUE TO THE COILS CONSTANTLY GOING BAD CAUSED THE CATALYTIC CONVERTER TO GO BAD, WHICH HAD TO BE REPLACED MAY 2011 ALONG WITH THE COILS AND O2 SENSOR. BUT TWO MONTHS LATER THE ENGINE LIGHT WAS ON AGAIN, ONCE AGAIN DUE TO THE COILS. THEY WERE REPLACED, AND ENGINE LIGHT ON AGAIN. THEY TOLD ME IT WOULD VOID THE WARRANTY ON THE CONVERTER DUE TO THE ISSUE WITH THE COIL PACKS! THE CAR NOW SMELLS LIKE IT IS BURNING WHEN ONLY DRIVING FOR 20-30 MINS. HAD TO GET A EMISSIONS WAIVER FROM THE DOT FOR 2 YEARS DUE TO THE PROBLEM SINCE IT WOULDN'T PASS INSPECTION. THERE IS OBVIOUSLY A PROBLEM WITH MORE THAN JUST THE COIL PACKS THEMSELVES. THEY HAVE BEEN REPLACED A DOZEN TIME, YET THERE IS STILL A PROBLEM. IT SEEMS TO ME THAT THE WHOLE HOUSING UNIT FOR THE COILS NEED TO BE REPLACED ALONG WITH THE WIRES, TOO PREVENT FIRE AND OTHER PROBLEMS WITH THE CARS. *TR
NHTSA ODI #10445093
Mileage unknown · Dec 7, 2011
Engine And Engine CoolingFire
OWNER DROVE THE 2003 VOLKSWAGEN PASSAT (2.8 V6 ENGINE) HOME AND PARKED IT. HE CAME BACK OUT TO THE DRIVEWAY APPROXIMATELY 2 HOURS LATER AND FOUND THE VEHICLE SMOKING. SMALL FIRE AT RIGHT FRONT FLOOR PAN/MINOR MELTING OF DASH PLASTICS CAUSED BY HEAT FROM RIGHT SIDE EXHAUST PIPE/CATALYTIC CONVERTER. HEAT SHIELD MELTED, RUBBER BODY…
Read full complaint
OWNER DROVE THE 2003 VOLKSWAGEN PASSAT (2.8 V6 ENGINE) HOME AND PARKED IT. HE CAME BACK OUT TO THE DRIVEWAY APPROXIMATELY 2 HOURS LATER AND FOUND THE VEHICLE SMOKING. SMALL FIRE AT RIGHT FRONT FLOOR PAN/MINOR MELTING OF DASH PLASTICS CAUSED BY HEAT FROM RIGHT SIDE EXHAUST PIPE/CATALYTIC CONVERTER. HEAT SHIELD MELTED, RUBBER BODY PLUG IGNITED AND CONSUMED, CARPET JUST ABOVE BODY PLUG WAS CHARRED. CAR JUST HAD RIGHT SIDE CATALYTIC CONVERTER AND PIPE REPLACED. *TR
NHTSA ODI #10438893
77,908 miles · Sep 9, 2011
Engine And Engine CoolingSuspension
I HAVE A 2003 VOLKSWAGEN PASSAT WITH 77,650 MILES WITH PROBLEMS WITH THE OILPUMP AND ENGINE PROBLEMS THAT IS UNKNOWN. THE AUTOMOBILE WILL STALL NOT START IT HASN'T BEEN DRIVEN IN OVER 6 MONTHS DUE TO THE RATTLING NOISE IN THE ENGINE AND I BELIEVE SLUGGED IS BUILD UP IN THE ENGINE BUT SINCE THEN I HAVE REPLACED TWO OILPUMPS IN TH…
Read full complaint
I HAVE A 2003 VOLKSWAGEN PASSAT WITH 77,650 MILES WITH PROBLEMS WITH THE OILPUMP AND ENGINE PROBLEMS THAT IS UNKNOWN. THE AUTOMOBILE WILL STALL NOT START IT HASN'T BEEN DRIVEN IN OVER 6 MONTHS DUE TO THE RATTLING NOISE IN THE ENGINE AND I BELIEVE SLUGGED IS BUILD UP IN THE ENGINE BUT SINCE THEN I HAVE REPLACED TWO OILPUMPS IN THE VEHICLE AND THE SENSORS. ENGINE OIL PRESSURE FAILURE AND DEFECTIVE COILS ON EACH CYLINDER. *TR
NHTSA ODI #10424540
78,000 miles · Aug 18, 2011
Engine And Engine Cooling
2003 VOLKSWAGEN PASSAT HAS HAD RECURRING PROBLEMS WITH IGNITION COILS OVER THE PAST TWO YEARS (HAVE ALREADY HAD TWO REPLACED AT PERSONAL EXPENSE, AS THEY WERE NOT UNDER RECALL/WARRANTY) MOST RECENT ISSUE WITH SUCH HAS OCCURRED THE PAST TWO WEEKS, BEGINNING WITH THE APPEARANCE OF THE CHECK ENGINE LIGHT ALONG WITH PERIODS OF MY VE…
Read full complaint
2003 VOLKSWAGEN PASSAT HAS HAD RECURRING PROBLEMS WITH IGNITION COILS OVER THE PAST TWO YEARS (HAVE ALREADY HAD TWO REPLACED AT PERSONAL EXPENSE, AS THEY WERE NOT UNDER RECALL/WARRANTY) MOST RECENT ISSUE WITH SUCH HAS OCCURRED THE PAST TWO WEEKS, BEGINNING WITH THE APPEARANCE OF THE CHECK ENGINE LIGHT ALONG WITH PERIODS OF MY VEHICLE RUNNING VERY ROUGH (A "RUMBLING" TYPE SENSATION, PARTICULARLY WHEN IDLING/WHILE STOPPED) THIS SOON ESCALATED INTO A TOTAL LOSS OF POWER WHILE DRIVING ON THE FREEWAY THE OTHER DAY, WHICH NECESSITATED IN ME HAVING TO ABRUPTLY PULL ONTO THE SHOULDER, SMOKE CAME OUT FROM UNDER THE HOOD FOR A MINUTE OR TWO. TOOK MY PASSAT TO A LOCAL REPAIR SHOP THE NEXT DAY, WHERE THEY READ THE ERROR CODE(S) FOR MY CHECK ENGINE LIGHT---TURNS OUT THERE ARE 10 IN ALL, 1 FOR EACH CYLINDER IN MY ENGINE (I HAVE A V6), 3 FOR EACH IGNITION COIL, AND 1 GENERAL ENGINE CODE. THIS WILL BE THE THIRD TIME I HAVE DEALT WITH THIS ISSUE IN A VERY SHORT TIME FRAME. I WILL BE CALLING THE DEALERSHIP FIRST THING IN THE MORNING BUT I DO NOT BELIEVE THERE IS ANY RECALL/WARRANTY OUT FOR THIS ISSUE STILL. I AM VERY UPSET AND DISPLEASED WITH VW AND THEIR LACK OF RELIABILITY/CREDIBILITY REGARDING THIS ISSUE. IT SEEMS THAT IT IS QUITE WIDESPREAD FROM WHAT I HAVE RESEARCHED AND READ AND I HOPE THAT SOMETHING WILL BE DONE ABOUT IT SOON, I CANNOT AFFORD TO KEEP PAYING FOR THIS AND CERTAINLY CANNOT AFFORD FOR THE SAFETY HAZARDS OF IT TO GET ANY WORSE, IM AFRAID AN ENGINE FIRE WILL BE NEXT!! *KB
NHTSA ODI #10420091
Official recalls
6Jun 13, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X3.
Apr 7, 2008
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Consequence & remedy
Consequence: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Aug 28, 2007
ON CERTAIN VEHICLES EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Consequence & remedy
Consequence: IF FUEL FLOW TO THE ENGINE IS INTERRUPTED, THE VEHICLE COULD STALL WITHOUT WARNING AND THUS PRESENT A POTENTIAL RISK OF CRASH.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 28, 20007. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834. THIS RECALL IS A SUPPLEMENT TO A PREVIOUS CAMPAIGN (PLEASE SEE 06V017).
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Jan 23, 2006
ON CERTAIN VEHICLES PRODUCED FROM SEPTEMBER 2002 - MARCH 2003, EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Consequence & remedy
Consequence: IF FUEL FLOW TO THE ENGINE IS INTERRUPTED, THE VEHICLE COULD STALL WITHOUT WARNING AND THUS PRESENT A POTENTIAL RISK OF CRASH.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834.
Jan 25, 2002
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA11002 · Engine Compartment Fire
Opened Jan 26, 2011 · Closed Feb 17, 2012
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Additional source detail variants (2)
Electrical System
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
PE10027 · Engine Compartment Fire
Opened Jul 26, 2010 · Closed Feb 7, 2011
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
Additional source detail variants (2)
Electrical System
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
Engine And Engine Cooling
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
PE07024 · Passenger/engine Compartment Fires
Opened May 10, 2007 · Closed Sep 28, 2007
Status: closed (inferred from source dates) · Electrical System:ignition
MANY OF THE FIRE REPORTS ALLEGE THAT THE VEHICLE FIRE WAS ATTRIBUTED TO IGNITION COIL FAILURE.VW PROVIDED ADDITIONAL DATA REGARDING ITS ANALYSIS OF VEHICLE FIRES AND A DETAILED DESCRIPTION OF THE THREE DIFFERENT ENGINES AND IGNITION SYSTEMS FOR THE SUBJECT VEHICLES.ODIFINDS THE NEED TO FURTHER INVESTIGATE THIS ISSUE.TO FACILITATE ACQUISITION AND ANALYSIS OF ADDITIONAL INFORMATION, THIS INVESTIGATIONHAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-014).
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration