NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
23 reportsClear category filter130,000 miles · May 27, 2008
Air BagsElectrical SystemEngine And Engine Cooling
RADIO NOT FUNCTIONING, AIR CONDITIONING UNIT WORKS INTERMITTENTLY, AIRBAG MALFUNCTION RECOGNIZED, OPERATION UNIT IN STEERING WHEEL MALFUNCTIONS, NO COMMUNICATIONS WITH BRAKE CONTROL UNIT, BRAKE LIGHT SWITCH CAUSES DRIVERS SIDE BRAKE LIGHT TO MALFUNCTION. HORN NOT FUNCTIONING NEARLY CAUSED 2 ACCIDENTS WITHIN A MONTH. I DROVE OVE…
Read full complaint
RADIO NOT FUNCTIONING, AIR CONDITIONING UNIT WORKS INTERMITTENTLY, AIRBAG MALFUNCTION RECOGNIZED, OPERATION UNIT IN STEERING WHEEL MALFUNCTIONS, NO COMMUNICATIONS WITH BRAKE CONTROL UNIT, BRAKE LIGHT SWITCH CAUSES DRIVERS SIDE BRAKE LIGHT TO MALFUNCTION. HORN NOT FUNCTIONING NEARLY CAUSED 2 ACCIDENTS WITHIN A MONTH. I DROVE OVER AN ISLAND TO AVOID ONE COLLISION FROM THE OTHER NON-ATTENTIVE DRIVER AND ENDED UP SCRAPING THE TRANSMISSION PAN. COST OF REPLACEMENT: $550. AFTER THOUSANDS OF DOLLARS IN REPAIRS AND DIAGNOSTICS, VW DEALERSHIPS STILL UNABLE TO FIX ANY OF THE ABOVE! *TR
NHTSA ODI #10229048
7,000 miles · Dec 6, 2007
Air BagsElectrical SystemEquipment
I'VE SPENT OVER $8000 TOWARDS VW DEALERSHIP ATTEMPTS AT FIXING THE HORN, RADIO, HOMELINK, CLIMATE CONTROL (A/C AND HEAT) REAR PASSENGER SIDE WINDOW, HEATED SEATS, DASHBOARD PANEL LIGHTS, AND DEFROSTER FLAP. VW REPLACED ABS AND BRAKE LIGHT MODULE, BUT ONLY FIXED THE HORN. VW STATED THEY ARE NOT RESPONSIBLE EVEN AFTER I PAID FOR T…
Read full complaint
I'VE SPENT OVER $8000 TOWARDS VW DEALERSHIP ATTEMPTS AT FIXING THE HORN, RADIO, HOMELINK, CLIMATE CONTROL (A/C AND HEAT) REAR PASSENGER SIDE WINDOW, HEATED SEATS, DASHBOARD PANEL LIGHTS, AND DEFROSTER FLAP. VW REPLACED ABS AND BRAKE LIGHT MODULE, BUT ONLY FIXED THE HORN. VW STATED THEY ARE NOT RESPONSIBLE EVEN AFTER I PAID FOR THEM TO FIX THE ABOVE PROBLEMS AND THEY ARE STILL UNABLE TO DETERMINE THE CAUSE OF THE PROBLEMS. I REQUEST REIMBURSEMENT FROM VOLKSWAGEN FOR THE REPAIR ATTEMPTS AND RELATED EXPENSES. CURRENT VEHICLE MILEAGE: 127,000. *TR
NHTSA ODI #10211082
42,000 miles · Nov 29, 2007
Air BagsStructure
I HAVE A 2003 VW PASSAT. I'VE HAD TWO LEAKS INTO THE FRONT RIGHT FLOORBOARD IN THE PAST SIX MONTHS FROM EITHER A SUNROOF DRAIN LINE OR A AIR CONDITIONER. THE LEAKS HAVE PRODUCED SO MUCH WATER THAT IT HAS GONE TO RIGHT BACK FLOORBOARD. THE PLASTIC ON THE INTERIOR IS WORN OFF. THE ASHTRAY FELL APART. THEY CAN'T SEEM TO GET THE AL…
Read full complaint
I HAVE A 2003 VW PASSAT. I'VE HAD TWO LEAKS INTO THE FRONT RIGHT FLOORBOARD IN THE PAST SIX MONTHS FROM EITHER A SUNROOF DRAIN LINE OR A AIR CONDITIONER. THE LEAKS HAVE PRODUCED SO MUCH WATER THAT IT HAS GONE TO RIGHT BACK FLOORBOARD. THE PLASTIC ON THE INTERIOR IS WORN OFF. THE ASHTRAY FELL APART. THEY CAN'T SEEM TO GET THE ALIGNMENT RIGHT SO I KEEP GOING THROUGH TIRES AND THE TIRES I DO HAVE SOUND UNEVEN WHEN I ROTATE THEM, MAKING ME THINK THERE'S A PROBLEM. HOVE REPLACED THE HEADLIGHTS THREE TIMES IN 1 AND 1/2 YEARS. THERE'S A DEFECT INVESTIGATION INTO FIRES IN THE ENGINE AND A RECALL ON OIL SLUDGE. THIS CAR IS AN ACCIDENT WAITING TO HAPPEN AND IT'S VERY POORLY ENGINEERED. ONE THING AFTER ANOTHER. VW HAS ON A BUNCH OF RECALLS ALREADY ON THIS MODEL, TO MANY FOR ME TO FEEL SAFE WITH. I'M ABANDONING THE CAR TODAY, TRADING IT IN FOR SOMETHING ELSE. WILL NEVER BUY A VW AGAIN. NO CAR SHOULD HAVE THIS MANY ISSUES. AND THE ISSUES CONTINUE TO ROLL IN. NOW THE AIRBAG LIGHT JUST CAME ON...ANOTHER THING TO HAVE TO WORRY ABOUT!!! *TR
NHTSA ODI #10210280
59,000 miles · Dec 12, 2006
Air Bags
AIRBAG FAULT - BAD MODULE - AIRBAGS WILL NOT DEPLOY IN ACCIDENT - 2003 VW PASSAT. *JB
NHTSA ODI #10175923
44,500 miles · Apr 4, 2006
Air BagsElectrical SystemPower Train
CAR HAD TROUBLE STARTING, ELECTRICAL PROBLEMS, LURCHING WHILE DRIVING AND ULTIMATELY TRANSMISSION AND AIR BAG FAILURE. *NM
NHTSA ODI #10154566
32,915 miles · Dec 28, 2005
Air Bags
DRIVING A 2003 VW PASSAT GLX WAGON ON A ROAD UNDER CONSTRUCTION AND THE PASSENGER SIDE CURTAIN AIRBAGS DEPLOYED FOR NO APPARENT REASON. LUCKILY, THIS SHOCKING INCIDENT DIDN'T CAUSE US TO GET IN AN ACCIDENT, BUT IT DID FILL THE CAR WITH SMOKE AND WE HAD TO PULL OVER IMMEDIATELY AND GET OUR 2 YEAR OLD DAUGHTER OUT OF HER CAR SEAT.…
Read full complaint
DRIVING A 2003 VW PASSAT GLX WAGON ON A ROAD UNDER CONSTRUCTION AND THE PASSENGER SIDE CURTAIN AIRBAGS DEPLOYED FOR NO APPARENT REASON. LUCKILY, THIS SHOCKING INCIDENT DIDN'T CAUSE US TO GET IN AN ACCIDENT, BUT IT DID FILL THE CAR WITH SMOKE AND WE HAD TO PULL OVER IMMEDIATELY AND GET OUR 2 YEAR OLD DAUGHTER OUT OF HER CAR SEAT. I BROUGHT THE CAR TO A VW DEALERSHIP (KING VOLKSWAGEN, GAITHERSBURG, MD) AND THEY CHARGED ME $100 TO LOOK AT IT AND THEN TOLD ME THAT THE CAR SUSTAINED DAMAGE TO THE UNDERCARRIAGE. THEY TOLD ME THAT THE CAR PROBABLY HIT A CURB AT 35 MPH AND CAME TO A SUDDEN STOP. I WAS A PASSENGER IN THE CAR AT THE TIME AND I KNOW THAT THE CAR WAS NOT SLOWED DOWN AT ALL, AND WE DIDN'T EVEN NOTICE HITTING ANYTHING. BECAUSE THIS ROAD WAS UNDER CONSTRUCTION WE MAY HAVE BRUSHED A MAN HOLE COVER THAT WAS STICKING UP INTO THE ROAD, BUT NOT HARD ENOUGH TO SLOW THE CAR DOWN OR TO CAUSE ANY SERIOUS DAMAGE. I LOOKED AT THE IMPACT POINT IN THE UNDERCARRIAGE AND IT IS JUST A SMALL DENT TO A METAL CUP. I TOOK THE CAR TO MY MECHANIC AND HE WAS SHOCKED THAT THIS SMALL DENT WOULD HAVE CAUSED THE AIRBAGS TO BLOW. THE CAR DOES NOT REQUIRE ANY REPAIRS EXCEPT FOR THE REPLACEMENT OF THE AIRBAGS. I COMPLAINED TO VW CORPORATE AND THEY HAD ME BRING THE CAR BACK TO THE DEALER TO TAKE PICTURES AND READINGS FROM THE AIRBAG SENSOR. THEY SENT THAT INFORMATION TO VW CORPORATE AND CORPORATE CALLED ME BACK AND SAID THAT THIS WAS CONSIDERED TO BE AN ACCIDENT THAT WAS MY FAULT. *NM
NHTSA ODI #10146226
Mileage unknown · Sep 20, 2005
Air BagsCrashInjury
I WAS INVOLVED IN A AUTOMOBILE CRASH WHEN ANOTHER VEHICLE PULLED OUT IN FRONT OF ME. I WAS THE ONLY PERSON IN MY CAR AT THE TIME OF THE CRASH. I WAS TRAVELING THE POSTED SPEED LIMIT AND THE OTHER DRIVER RECEIVED A CITATION AND WAS AT FAULT. I WAS DRIVING A 2003 VW PASSAT. THE CAR HAD EXTENSIVE FRONT END DAMAGE MOSTLY TO THE DRIV…
Read full complaint
I WAS INVOLVED IN A AUTOMOBILE CRASH WHEN ANOTHER VEHICLE PULLED OUT IN FRONT OF ME. I WAS THE ONLY PERSON IN MY CAR AT THE TIME OF THE CRASH. I WAS TRAVELING THE POSTED SPEED LIMIT AND THE OTHER DRIVER RECEIVED A CITATION AND WAS AT FAULT. I WAS DRIVING A 2003 VW PASSAT. THE CAR HAD EXTENSIVE FRONT END DAMAGE MOSTLY TO THE DRIVERS SIDE. THE CAR WAS CONSIDERED A TOTAL INSURANCE LOSS BY THE OTHER DRIVES INSURANCE COMPANY. THE PASSENGER SIDE AIR BAG DEPLOYED BUT THE DRIVERS SIDE AIRBAG DID NOT. SINCE THE DAMAGE TO THE FRONT END OF THE CAR WAS EXTENSIVE BOTH AIR BAGS SHOULD HAVE DEPLOYED. I RECEIVED MINOR INJURIES BECAUSE OF THE CRASH, BUT IF I HAD BEEN TRAVELING AT A HIGHER RATE OF SPEED MY INJURIES MAY HAVE BEEN MUCH WORSE. *NM
NHTSA ODI #10137107
47,000 miles · Jul 25, 2005
Air BagsElectrical SystemFuel System, Gasoline
I PURCHASE A NEW 2003 VOLKSWAGEN PASSAT FROM BURLINGTON VOLKSWAGEN 2 YEARS AGO AND HAVE TAKEN IT BACK TO THE DEALERSHIP AT LEAST 7 TIMES SINCE THEN FOR A MYRIAD OF PROBLEMS, FROM AIRBAG LIGHTS COMING ON TO CHECK ENGINGE LIGHT TO THE LATEST OF THE CAR SHUTTING OFF IN THE MIDDLE OF THE ROAD.
NHTSA ODI #10129949
41,000 miles · Oct 1, 2004
Air Bags
2003 VOLKSWAGEN PASSAT STATION WAGON, VIN NO. [XXX]; HILE DRIVING IN GREENSBORO NC NEAR THE INTERSECTION OF ELM, MCGEE AND GORRELL STREETS I MISJUDGED A CURVE AND SCRAPED THE RIGHT SIDE WHEELS AGAINST A CURB. BOTH TIRES SUSTAINED SIDEWALL DAMAGE. THERE WAS NO CONTACT WITH THE BODY OR UNDERCARRAIGE OF THE CAR. THE TWO RIGHT …
Read full complaint
2003 VOLKSWAGEN PASSAT STATION WAGON, VIN NO. [XXX]; HILE DRIVING IN GREENSBORO NC NEAR THE INTERSECTION OF ELM, MCGEE AND GORRELL STREETS I MISJUDGED A CURVE AND SCRAPED THE RIGHT SIDE WHEELS AGAINST A CURB. BOTH TIRES SUSTAINED SIDEWALL DAMAGE. THERE WAS NO CONTACT WITH THE BODY OR UNDERCARRAIGE OF THE CAR. THE TWO RIGHT SIDE WHEELS SUSTAINED MINOR COSMETIC DAMAGE ONLY AND THE IMPACT WAS INSUFFICIENT TO AFFECT THE ALIGNMENT OF THE AUTOMOBILE. THE AUTOMOBILE CONTINUED FORWARD THROUGH THE CURVE AND THERE WAS NO LOSS OF CONTROL FROM THE IMPACT. HOWEVER, UPON CONTACT WITH THE CURB THE RIGHT SIDE CURTAIN AND SIDE IMPACT AIRBAGS FIRED UNNECESSARILY. BUT FOR THE FIRING OF THE AIRBAGS THIS WOULD HAVE BEEN A MINOR EVENT WITH ONLY TIRE DAMAGE TO BE REPAIRED. FORTUNATELY, THE PASSENGER SEAT WAS UNOCCUPIED OR THE OCCUPANT COULD HAVE BEEN INJURED. I HAVE PHOTOGRAPHS OF THE TIRES AND WHEELS. I BELIEVE THE AUTMOBILE CONTAINS A SIGNIFICANT DEFECT CAUSING THE SIDE AIRBAG SYSTEM TO DEPLOY WHEN NOT NEEDED FOR OCCUPANT PROTECTION (IE - IN THE ABSENCE OF ANY CONTACT WITH THE STRUCTURE OF THE CAR), AND IN CIRCUMSTANCES PART OF ORDINARY DRIVING - THE IMPACT WITH THE CURB WAS LESS THAN THAT EXPERIENCED WITH SOME POTHOLES. THUS FAR, VW HAS REFUSED TO TAKE ANY RESPONSIBILITY FOR CORRECTION OF THIS DEFECT.*AK THE AUTOMOBILE HAS NOT YET BEEN REPAIED, AND PRESUMABLY, EVENT DATA IS STILL STORED IN THE CONTROL MODULE. UPDATED 07/24/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10093422
15,000 miles · Jan 29, 2004
Air Bags
I HAVE A 2003 PASSAT SEDAN. THE DRIVER SIDE AIRBAG AND DRIVER SIDE CURTAIN AIRBAG DEPLOYED WHEN THE CAR SLID TO A STOP WHILE TURNING IN AN ICY PARKING LOT. THERE WAS A SLIGHT IMPACT AT ABOUT 5 MPH WHEN THE THE CAR HIT A SNOW COVERED CONCRETE PARKING BLOCK AT ABOUT THE JACK POINT NEAR THE REAR DRIVER-SIDE WHEEL. NOBODY WAS…
Read full complaint
I HAVE A 2003 PASSAT SEDAN. THE DRIVER SIDE AIRBAG AND DRIVER SIDE CURTAIN AIRBAG DEPLOYED WHEN THE CAR SLID TO A STOP WHILE TURNING IN AN ICY PARKING LOT. THERE WAS A SLIGHT IMPACT AT ABOUT 5 MPH WHEN THE THE CAR HIT A SNOW COVERED CONCRETE PARKING BLOCK AT ABOUT THE JACK POINT NEAR THE REAR DRIVER-SIDE WHEEL. NOBODY WAS INJURED WHEN THE AIRBAGS DEPLOYED. THERE WAS NO DAMAGE DONE TO THE CAR - EXCEPT TO THE INTERIOR AS A RESULT OF THE AIRBAGS BEING DEPLOYED. IT WILL COST $3600 TO RE-INSTALL THE TWO AIRBAGS AND A LOT OF OTHER PARTS. THAT IS RIDICULOUS FOR A 5 MPH IMPACT THAT CAUSED NO DAMAGE! I AM HOPING THIS WILL BE SEEN AS A DEFECTIVE AIRBAG DEPOLYMENT AND COVERED UNDER THE WARRANTY. IF NOT, VW NEEDS TO IMPROVE THEIR AIRBAG ENGINEERING BEFORE I'D CONSIDER BUYING ANOTHER VOLKSWAGEN. *AK
NHTSA ODI #10055179
Official recalls
6Jun 13, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X3.
Apr 7, 2008
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Consequence & remedy
Consequence: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Aug 28, 2007
ON CERTAIN VEHICLES EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Consequence & remedy
Consequence: IF FUEL FLOW TO THE ENGINE IS INTERRUPTED, THE VEHICLE COULD STALL WITHOUT WARNING AND THUS PRESENT A POTENTIAL RISK OF CRASH.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 28, 20007. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834. THIS RECALL IS A SUPPLEMENT TO A PREVIOUS CAMPAIGN (PLEASE SEE 06V017).
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Jan 23, 2006
ON CERTAIN VEHICLES PRODUCED FROM SEPTEMBER 2002 - MARCH 2003, EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Consequence & remedy
Consequence: IF FUEL FLOW TO THE ENGINE IS INTERRUPTED, THE VEHICLE COULD STALL WITHOUT WARNING AND THUS PRESENT A POTENTIAL RISK OF CRASH.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834.
Jan 25, 2002
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA11002 · Engine Compartment Fire
Opened Jan 26, 2011 · Closed Feb 17, 2012
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Additional source detail variants (2)
Electrical System
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
PE10027 · Engine Compartment Fire
Opened Jul 26, 2010 · Closed Feb 7, 2011
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
Additional source detail variants (2)
Electrical System
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
Engine And Engine Cooling
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
PE07024 · Passenger/engine Compartment Fires
Opened May 10, 2007 · Closed Sep 28, 2007
Status: closed (inferred from source dates) · Electrical System:ignition
MANY OF THE FIRE REPORTS ALLEGE THAT THE VEHICLE FIRE WAS ATTRIBUTED TO IGNITION COIL FAILURE.VW PROVIDED ADDITIONAL DATA REGARDING ITS ANALYSIS OF VEHICLE FIRES AND A DETAILED DESCRIPTION OF THE THREE DIFFERENT ENGINES AND IGNITION SYSTEMS FOR THE SUBJECT VEHICLES.ODIFINDS THE NEED TO FURTHER INVESTIGATE THIS ISSUE.TO FACILITATE ACQUISITION AND ANALYSIS OF ADDITIONAL INFORMATION, THIS INVESTIGATIONHAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-014).
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration