1993 Volkswagen Passat

THE LEFT FOG LIGHT STARTED SMOKING, AND THEN ON FIRE. I WAS SITTING INSIDE THE VEHICLE, CLEANING IT. THE LIGHTS WERE ON, INCLUDING THE FOG LIGHTS. I SMELLED BURNING PLASTIC, AND DIDN'T THINK MUCH OF IT AT FIRST, IT GOT WORSE, SO I GOT OUT OF THE CAR AND SAW SMOKE COMING FROM AROUND THE RIGHT SIDE OF THE BUMPER. I GOT UNDER THERE TO SEE WHAT'S GOING ON, AND SECONDS LATER A PIECE OF BURNING PLASTIC WITH THE BULB STILL IN IT FELL INTO THE INSIDE OF THE BUMBER, APPARENTLY IT SEPARATED FROM THE MAIN UNIT OF THE LIGHT. I HAD TO STUFF IT WITH SNOW TO STOP THE FIRE. THERE WAS NO SERIOUS DAMAGE TO THE VEHICLE BEYOUND THE LIGHT ITSELF. LATER ON I PURCHASED A PAIR OF USED FOG LIGHTS FROM EBAY TO REPLACE MINE. WHEN TRYING TO REPLACE THEM, IT TURNED OUT THAT THE LEFT LIGHT ON MY VEHICLE WAS ALSO BURNT, AND THE PIECE WITH THE BULB FELL OUT OF IT TOO. THE LIGHTS I BOUGHT ALSO TIRNED OUT TO BE DAMAGED IN SIMILAR WAY, BUT JUST MELTED. THE REASON I MARK PROPERTY DAMAGE ON THIS FORM, IS BECAUSE TO REPLACE ONE OF THE UNITS COSTS $135, WITHOUT ANY GUARANTEE THAT THIS SAME THING WILL NOT HAPPEN AGAIN. I BELIEVE THAT THIS IS AN OBVIOUS AND HAZARDOUS DESIGN FLAW, AND VW SHOULD REPLACE THE UNITS WITH FIRE PROOF ONES. VW SHOUD ALSO PAY FOR THAT, NOT I.*AK

IGNITION : FOR THE LAST 9 MONTHS, INTERMITTENTLY, CAR WILL CONTINUE TO RUN AFTER THE IGNITION IS TURNED OFF AND KEY IS REMOVED... BEEN TO 3 VW DEALERSHIPS 5 TIMES TOTAL. ABS BRAKES NEVER WORKED SINCE NEW, WOULDN'T STOP ON SNOW OR ICE LIKE OTHER ABS BRAKE SYSTEMS .. AFTER MANY COMPLAINTS FOR 4 YEARS VW FIXED SOME OF THE ABS PROBLEMS BUT ABS WARNING LIGHT STILL COMES ON SOMETIMES. ALSO, PEDAL INTERMITTENTLY WILL GO TO FLOOR, AND SNOW AND ICE PERFORMANCE IS MUCH WORSE THAN OUR OTHER ABS PASSATS . SEAT BELTS: LAP BELT BUCKLE SEEMS LIKELY TO CAUSE INJURY IN AN ACCIDENT . AIR CONDITIONER : $150 SWITCH IN DASH HAS FAILED 3 TIMES (COMMON ON 1993-94 PASSATS). SUNROOF: SMALL PART BREAKS ON TRACK REQUIRES REPLACEMENT OF ENTIRE EXPENSIVE SUNROOF MECHANISM ... (SEEMS TO HAPPEN MANY 1993-94 PASSATS). FOG LIGHTS: CORRADO AND PASSAT LENSES FOG UP OR FILL UP WITH WATER AND THEN CRACK FROM HEAT. VW AND HELLA REDESIGNED LENS ON CORRADO MODEL BUT NOT ON PASSAT $26 TO $50 PER LENS, 11 LENSES SO FAR. *AK