IllustrationTHROTTLE CABLE MELTS THEN IT JAMS, USUALLY IN A HIGH REVVING POSITION. I HAVE GONE THROUGH 3 NEW THROTTLE CABLES, EACH TIME THEY MELT AND STICK. *JB
1992 Volkswagen Passat
Owner reports · Recalls · Investigations
Fewer warning signs than most model years
Owner complaints for the 1992 Volkswagen Passat are lower than the model-year median of 110.
About this comparison →How this year compares
Owner complaints by model year
Compare all Passat years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 39 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports1 fire reports1 injury reports
What owners actually said
39 reportsWHILE DRIVING 65 MPH HEATER CORE BLEW OUT. AS A RESULT WHITE STEAM FILLED THE PASSENGER COMPARTMENT WHICH IMPAIRED THE VISIBILITY OF THE DRIVER. *AK *NM
HEAT EXCHANGER (CORE) LEAKED WHILE DRIVING, STEAMING UP THE VEHICLE INTERIOR TO IMPAIR VISIBILITY. HOT COOLANT LEAKED INTO PASSENGER'S FOOT AREA. THIS IS VERY SIMILAR TO THE ALREADY ISSUED RECALL # 96V115000. MY CAR IS 1992 VW PASSAT: [XXX]. *JB INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S…
Read full complaint
HEAT EXCHANGER (CORE) LEAKED WHILE DRIVING, STEAMING UP THE VEHICLE INTERIOR TO IMPAIR VISIBILITY. HOT COOLANT LEAKED INTO PASSENGER'S FOOT AREA. THIS IS VERY SIMILAR TO THE ALREADY ISSUED RECALL # 96V115000. MY CAR IS 1992 VW PASSAT: [XXX]. *JB INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
WHILE DRIVING GAS AND FUMES BEGAN EMITTING FROM VENTS CAUSING WINDOWS TO FOG ELIMINATING CONSUMER'S VISIBILITY. DEALER DIAGNOSED THAT HAD A BROKEN HEATER CORE. TS
HEATING SYSTEM SMELLS OF ANTIFREEZE WHEN USING FRONT VENTS AND DEFROST. 2 - 3 FAN SELECTION USED AND HEATER SET TO MEDIUM WARM SETTING ANTIFREEZE FUMES STARTED TO BLOWOUT, WHICH FOGGED FRONT WINDOW AND BREATHING IN HAZMAT ANTIFREEZE.*AK
THE ENGINE VALVES AND TIMING BELT FAILED WHILE DRIVING CAUSING THE VEHICLE TO SHUT DOWN. *MJS
THE ELECTRONIC CONTROL MODULE IN THE TRANSMISSION FAILED. *MJS
WHEN IT'S COLD VEHICLE WILL START FAST AND RUN WELL. BUT AFTER CAR HAS BEEN WARMED UP, PARKED AND STARTED AGAIN, IT'S HARD TO START. THEN, WHEN GOING DOWN THE STREET AND SLOWING DOWN, VEHICLE WILL STALL. THIS IS VERY UNSAFE. VEHICLE HAS BEEN REPAIRED ON SEVERAL OCCASIONS, HOWEVER CONTINUES TO EXPERIENCE PROBLEMS. *AK
THERE IS FUEL LEAKING INTO THE ENGINE COMPARTMENT. DEALER HAS SEEN VEHICLE. THERE HAVE BEEN MANY OTHER PROBLEMS WITH THIS VEHICLE, INCLUDING: -AUTOMATIC ACCELERATION, THROTTLE STICKS WHEN ACCELERATING -HEATER CORE EXPLODED -BRAKE PEDAL GOES TO THE FLOOR -CV JOINTS BAD -TRUNK LATCH WILL NOT …
Read full complaint
THERE IS FUEL LEAKING INTO THE ENGINE COMPARTMENT. DEALER HAS SEEN VEHICLE. THERE HAVE BEEN MANY OTHER PROBLEMS WITH THIS VEHICLE, INCLUDING: -AUTOMATIC ACCELERATION, THROTTLE STICKS WHEN ACCELERATING -HEATER CORE EXPLODED -BRAKE PEDAL GOES TO THE FLOOR -CV JOINTS BAD -TRUNK LATCH WILL NOT OPEN -OIL LEAK -TRANSMISSION FAILURES -EXHAUST PROBLEMS -STARTING PROBLEMS, IGNITION -FRESH AIR CONTROL DOES NOT WORK -STEERING WHEEL LOST SCREWS *AK *ML
THE AIR CONDITIONING WORKS FINE ON THIS VEHICLE. BUT WHEN THE HEAT IS TURNED ON HEAT CONTROL SWITCH MELTS FROM THE INSIDE OUT, CAUSING DAMAGE TO THE DASH PANEL. DEALER HAS NOT BEEN CONTACTED. *AK
Official recalls
192V131000 · Vehicle Speed Control
Sep 15, 1992
THE VENTURI TUBE LOCATED IN THE THROTTLE VALVE HOUSING CAN BECOME LOOSE AND FALL AGAINST THE THROTTLE PLATE.
Consequence & remedy
Consequence: THE VENTURI TUBE CAN PARTIALLY BLOCK THE THROTTLE PLATEAND PREVENT IT FROM RETURNING TO ITS FULL IDLE POSITION, RESULTING IN UNWANTEDENGINE SPEED WHEN THE VEHICLE IS PLACED IN A FORWARD OR REVERSE GEAR.
Remedy: REPLACE THE PRESS-FIT VENTURI TUBE WITH A THREAD TYPE TUBE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.