2005 Volkswagen Jetta

AS EMPHASIS BY OTHER OWNERS OF THIS CAR (HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?5457990-CLASS-ACTION-AGAINST-VW-FOR-TIMING-CHAIN-PROBLEM), VOLKSWAGEN DESIGNED A FLAWED SYSTEM WHICH ALLOWS THE TIMING CHAIN TO FAIL PRE-MATURELY. IN FACT, DUE TO THE DESIGN OF THIS MOTOR, A TIMING CHAIN FAILURE WILL DIRECTLY AND IMMEDIATELY LEAD TO OTHER CATASTROPHIC ISSUES SUCH AS A BENT VALVE IN MY SITUATION. UPON REPLACEMENT OF THE MOTOR, I HAD THE EXACT SAME ISSUE HAPPEN LESS THAN 1 MONTH LATER (11/16/11). *TR

THE CAR INTERIOR HAS A CRAYON SMELL MOST NOTICEABLE ON HOT DAYS. I AM CONCERNED THAT I AM BREATHING IN POSSIBLY TOXIC FUMES FROM THE EVAPORATION OF CHEMICALS THAT WERE USED WHEN THE CAR WAS BUILT. AFTER TYPING INTO GOOGLE ONLY THE 2 WORDS "CRAYON SMELL" I GET MANY MANY HITS FOR VW CARS THAT HAVE THE EXACT SAME SMELL AS MINE, SO THIS IS A PROBLEM THAT AFFECTS A LARGE GROUP OF VW VEHICLES. *TR

2005 .5 MODEL YEAR VOLKSWAGEN JETTA TDI (TURBODIESEL) WITH AUTOMATIC (DSG) TRANSMISSION. ON SEVERAL OCCASIONS WHILE DRIVING CAR, THE TRANSMISSION WILL FOR NO REASON SHIFT INTO NEUTRAL, AND ALL TRANSMISSION INDICATOR LIGHTS 'PRNDS' WILL FLASH SIMULTANEOUSLY. SO FAR, IF ENGINE IS SHUT OFF AND THEN RESTARTED, THE TRANSMISSION WILL AGAIN FUNCTION NORMALLY. I BELIEVE THIS HAS HAPPENED 4 OR 5 TIMES NOW. ON ONE OCCASION, THE CAR WAS IN AN INTERSECTION WHEN IT BECAME IMMOVABLE WHICH PRESENTS A SAFETY HAZARD.I CAN SEE THAT THERE IS A MASSIVE AMOUNT OF INFO ON MANY VW INTERNET SITES ABOUT THIS ISSUE, IN FACT IF YOU SIMPLY GOOGLE 'VW DSG FLASHING PRNDS' OR 'VW DSG TRANSMISSION PROBLEMS' ANYONE CAN FIND IT. IT IS A COMMON PROBLEM. I SEE THAT HHTSA HAS BEGUN AN INVESTIGATION BASED ON THIS FOR 2007 THRU 2009 MODEL YEARS, OBVIOUSLY A PROBLEM ON 2005/2006 VW WITH DSG TRANSMISSION AS WELL. VW HAS INITIATED A NEW CUSTOMER SERVICE PROGRAM TO ADDRESS CUSTOMER CONCERNS RELATED TO CERTAIN DSG EQUIPPED MODELS BUT APPARENTLY MINE (AND MANY OTHERS) ARE NOT COVERED THEY SAY BY THIS PROGRAM- NEVERTHELESS A SAFETY ISSUE EXISTS WITH 2005 AND 2006 DSG EQUIPPED VW'S. I CALLED VW CUSTOMER SERVICE (NATIONAL) TODAY 11/3/11 AND REP SAID "I AM NOT AWARE OF THIS ISSUE' FOR THIS YEAR- SO THEY ARE EITHER LYING OR INCREDIBLY UNDERINFORMED. I HAD THE CAR TO VW DEALER FOR DIAGNOSIS, AND THEY STATED THAT A DIAGNOSTIC TEST SHOWED A MALFUNCTION IN A PART THAT CONTROLS TRANSMISSION OPERATION AND WAS CAUSING THE TRANSMISSION TO SHIFT INTO NEUTRAL BY ITSELF. THEIR RECOMMENDATION, "SPEND $2000 TO REPLACE THE PART, OR JUST GET A NEW TRANSMISSION = $4000. SINCE THERE IS OBVIOUSLY A SAFETY RELATED DESIGN FLAW THAT ALLOWS THE TRANSMISSION TO SHIFT ITSELF INTO NEUTRAL- I FEEL THE NHTSA SHOULD EXPAND THE INVESTIGATION TO INCLUDE ALL YEARS OF VW DSG TRANSMISSION EQUIPPED VEHICLES SOLD IN THE USA. *TR

3 OCT 2011: THIS VEHICLE'S FLYWHEEL ASSY FAILED AT APPROXIMATELY 85,000 MILES. FORTUNATELY, THE FAILURE OCCURRED WHILE I WAS AT A VERY LOW RATE OF SPEED IN A NON-CONGESTED AREA. AFTER THE EVENT, I HAVE COME TO REALIZE THAT THIS IS A KNOWN PROBLEM ON DSG TRANSMISSIONS AS INSTALLED ON A VARIETY OF VW MODELS. VW DOES NOT APPEAR TO BE INTERESTED IN DISCUSSING THIS ISSUE FOR MODEL YEARS 2005 / 2006. I AM ONE OF THE LUCKIER ONES AS I REGULARLY MAKE LONG DISTANCE - INTERSTATE TRIPS WITH FAMILY IN-TOW. VOLKSWAGEN SHOULD BE HELD ACCOUNTABLE TO ACCEPT FULL FINANCIAL RESPONSIBILITY TO NOT ONLY TAKE CARE OF CUSTOMERS WHO HAVE EXPERIENCED SUCH LOW-TIME FAILURES BUT, ALSO, EXPAND ANY RECALL THAT MAY BE IN-PLACE FOR LATER MODELS SO AS TO PREVENT POTENTIAL LIFE-THREATENING ACCIDENTS WITHIN THE OVERALL DRIVING POPULATION. I HAD BEEN DRIVING A "TIME BOMB" FOR ALMOST 5 YEARS AND, TO DATE, VOLKSWAGEN OF NORTH AMERICA HAS ONLY ISSUED A LIMITED RECALL FOR LATER MODELS, THE 2008-2010, I BELIEVE. THIS EPISODE WILL COST AT LEAST $3000.00 USD AND NONE OF IT IS COVERED BY VOLKSWAGEN. WHAT IS THE ROOT CAUSE OF THIS AND HOW DO I KNOW THAT MY REPLACEMENT DSG TRANSMISSION WILL NOT BE SUSCEPTIBLE TO THIS HAPPENING AGAIN CAUSING POTENTIAL VEHICLE, PROPERTY, AND PERSONAL DAMAGE IN THE FORM OF A VEHICLE "MISHAP".??? *TR

2005.5 VW JETTA, 2.5L 5 CYL ENGINE. CAR HAS BEEN MAINTAINED ACCORDING TO MANUFACTURER GUIDELINES. VEHICLE WAS OPERATING NORMALLY WHEN CHECK ENGINE LIGHT CAME ON. CHECK ENGINE LIGHT WAS LIT STEADY, NOT FLASHING. STARTED TO LOSE POWER AND WAS DIFFICULT TO MAINTAIN SPEED. PULLED OFF ROAD AND IDLE WAS VERY ROUGH. TURNED CAR OFF AND BACK ON AND IDLE WAS WORSE AND CHECK ENGINE LIGHT STILL LIT AND NOT FLASHING. VEHICLE STARTED TO MAKE GRINDING NOISE FROM DRIVER'S SIDE OF THE ENGINE COMPARTMENT. WAS DIFFICULT TO MOVE VEHICLE UNDER ITS OWN POWER AND HAD CAR TOWED TO REPAIR SHOP. REPAIR SHOP FOUND TROUBLE CODE P1340 AND AFTER MORE DIAGNOSTIC THAT TIMING WAS INCORRECT. CAM TIMING WAS VERY FAR OFF AND STRETCHED TIMING CHAIN SUSPECTED. COMPRESSION TEST REVEALED BENT VALVES AS WELL. LOCAL INDY MECHANIC AND LOCAL VW DEALER HAVE BOTH SEEN THIS ISSUE SEVERAL TIMES WITH 2005.5 AND 2006 MODEL JETTA AND RABBIT VEHICLES WITH THE 2.5L ENGINE, AND SEVERAL OTHER SIMILAR FAILURES ARE OUTLINED IN SEVERAL PLACES ONLINE. THE FAILURE OF THE TIMING CHAIN WAS VERY SUDDEN AND COULD HAVE CAUSED AN ACCIDENT. *TR

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN NEW JETTA. THE CONTACT WAS DRIVING 60 MPH WHEN THE POWER WINDOWS AND TURN SIGNALS FAILED TO WORK PROPERLY. THE CONTACT ALSO MENTIONED THAT THE EXTERIOR AND INTERIOR LIGHTING FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER WHO CONFIRMED THAT BOTH A WIRING AND CRASH HARNESS WAS NEEDED TO RESOLVE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED, AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 54,000 AND THE CURRENT MILEAGE WAS 69,000.

CAMSHAFT FAILURE CAUSING ALL ASSOCIATED/CONNECTING PARTS TO ALSO FAIL. NEVER DEVIATED FROM SPECIFIED MANUFACTURES REQUIRED OIL (505.01). THIS APPEARS TO BE A DESIGN PROBLEM, THAT IS COMMON ON ALL THESE DIESEL ENGINES (BRM), OF WHICH THE MANUFACTURE WILL NOT CORRECT AND THE OWNER IS REQUIRED TO CORRECT AT THEIR OWN EXPENSE AT A COST OF $2000 PLUS. *TR