IllustrationOWN A 2005 VW JETTA, BROUGHT INTO DEALERSHIP TODAY WITH 106K MILES ON IT AND NOW THEY ARE SAYING THE TIMING CHAIN HAS JUMPED. THIS SOUNDS LIKE IT IS A COMMON PROBLEM, SO WHY ISN'T THERE A RECALL. *TR
2005 Volkswagen Jetta
Owner reports · Recalls · Investigations
More warning signs than most Jetta years
Owner complaints for the 2005 Volkswagen Jetta are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jetta years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
390–25K
2725–50K
4050–75K
3575–100K
46100–150K
19150K+
206 reports with mileage · 42 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports14 fire reports7 injury reports
Equipment complaints
3 reportsTL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT STATED THERE WAS A BURNING WAX ODOR EMITTING FROM THE AIR CONDITIONING VENT. THE VEHICLE WAS TAKEN TO THE DEALER WHO INSPECTED THE VEHICLE AND REPLACED THE CARPET. THE ODOR RETURNED AND THE VEHICLE WAS TAKEN BACK TO THE DEALER BUT NOT REPAIRED. THE CONTACT STATED THAT THE…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT STATED THERE WAS A BURNING WAX ODOR EMITTING FROM THE AIR CONDITIONING VENT. THE VEHICLE WAS TAKEN TO THE DEALER WHO INSPECTED THE VEHICLE AND REPLACED THE CARPET. THE ODOR RETURNED AND THE VEHICLE WAS TAKEN BACK TO THE DEALER BUT NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE WOULD ONLY OCCUR DURING SUMMER MONTHS. THE MANUFACTURER WAS CONTACTED AND OFFERED $1500 TOWARD THE PURCHASE OF A NEW VEHICLE. THE VEHICLE WAS NO REPAIRED. THE FAILURE MILEAGE WAS 60,000.
I OWN A 2005 VOLKSWAGEN NEW JETTA 2.5 WHICH JUST HAD AN INCIDENT OF THE AIRBAG FAULT LIGHT GOING ON. I TOOK MY VEHICLE TO THE DEALERSHIP TO BE SERVICED AND WAS INFORMED THAT I NEEDED TO REPLACE THE SEAT BELT BUCKLE WHICH WAS THE REASON FOR THE LIGHT. MY CAR IS CURRENTLY AT 58,00 MILES AND MY WARRANTY WAS ONLY EXTENDED TO 50,000 …
Read full complaint
I OWN A 2005 VOLKSWAGEN NEW JETTA 2.5 WHICH JUST HAD AN INCIDENT OF THE AIRBAG FAULT LIGHT GOING ON. I TOOK MY VEHICLE TO THE DEALERSHIP TO BE SERVICED AND WAS INFORMED THAT I NEEDED TO REPLACE THE SEAT BELT BUCKLE WHICH WAS THE REASON FOR THE LIGHT. MY CAR IS CURRENTLY AT 58,00 MILES AND MY WARRANTY WAS ONLY EXTENDED TO 50,000 MILES, LEAVING ME TO SHOULDER THE COSTS OF A NEW SEAT BELT BUCKLE. THE SEATBELT'S INNER ELECTRICAL CIRCUITS HAVE BURNED OUT, BUT THERE ARE NO OTHER DEFECTS WITH THE BUCKLE. BECAUSE THE CIRCUIT HAS BURNED OUT, THE PASSENGER AIRBAG SYSTEM IS CONSIDERED UNSTABLE AND MAY NOT FUNCTION PROPERLY DURING AN ACCIDENT. I FEEL THAT IN NO WAY SHOULD I BE HELD ACCOUNTABLE FOR WHAT APPEARS TO BE A MANUFACTURER DEFECT REGARDLESS OF MY VEHICLE'S WARRANTY STATUS. AFTER DOING RESEARCH ON THE INTERNET, I HAVE FOUND THAT MANY VOLKSWAGEN OWNERS HAVE HAD THIS SAFETY ISSUE BUT STRANGELY VOLKSWAGEN HAS NOT ISSUED A RECALL ON THIS DEFECT. ALTHOUGH I CANNOT FIND ANY INCIDENTS OF ACCIDENT REGARDING THIS DEFECT, I FEEL THAT A PROACTIVE APPROACH AND INVESTIGATION IS BETTER THAN SOMEONE LOSING THEIR LIFE OR LOVED ONE FROM THIS DEFECT. *TR
Official recalls
407V442000 · Exterior Lighting:headlights
Sep 24, 2007
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.
Consequence & remedy
Consequence: NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.
07V063000 · Exterior Lighting:brake Lights:switch
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
05V305000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Jul 5, 2005
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.5L GASOLINE ENGINE, A FUEL SUPPLY LINE CLAMP LOCATED IN THE ENGINE COMPARTMENT MAY NOT BE POSITIONED PROPERLY AND COULD CAUSE A FUEL LEAK.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE POSITION OF THE ENGINE COMPARTMENT FUEL SUPPLY LINE CLAMP AND, IF NECESSARY, REPLACE THE CLAMP. THE RECALL BEGAN ON JULY 11, 2005. OWNERS MAY CONTACT VW AT 1-800-822-8987.
04V586000 · Fuel System, Diesel
Dec 15, 2004
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
Remedy: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.