2005 Volkswagen Jetta

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WOULD OCCUR INTERMITTENTLY. THE ENGINE WOULD ALSO MISFIRE AND THE VEHICLE WOULD JERK AND DECELERATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN ADVISED THE CONTACT THAT THE B VALVE, THE GLOW PLUG AND THE GLOW PLUG HARNESS WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE CONTINUED AFTER THE REPAIR. THE VEHICLE WAS TAKEN TO A SECOND DEALER FOR DIAGNOSTICS WHERE THE TECHNICIANS STATED THAT THE DIRECT SHIFT GEARBOX UNIT WOULD HAVE TO BE REPLACED. THE CONTACT REFERENCED A RECALL FOR THE 2009-2010 MODELS UNDER NHTSA CAMPAIGN ID NUMBER: 09V333000 (POWER TRAIN:AUTOMATIC TRANSMISSION) BUT WAS ADVISED BY THE MANUFACTURER THAT THE RECALL DID NOT INCLUDE THE 2005 MODEL VEHICLES. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 118,000. UPDATED 04/02/12*LJ

2005 .5 MODEL YEAR VOLKSWAGEN JETTA TDI (TURBODIESEL) WITH AUTOMATIC (DSG) TRANSMISSION. ON SEVERAL OCCASIONS WHILE DRIVING CAR, THE TRANSMISSION WILL FOR NO REASON SHIFT INTO NEUTRAL, AND ALL TRANSMISSION INDICATOR LIGHTS 'PRNDS' WILL FLASH SIMULTANEOUSLY. SO FAR, IF ENGINE IS SHUT OFF AND THEN RESTARTED, THE TRANSMISSION WILL AGAIN FUNCTION NORMALLY. I BELIEVE THIS HAS HAPPENED 4 OR 5 TIMES NOW. ON ONE OCCASION, THE CAR WAS IN AN INTERSECTION WHEN IT BECAME IMMOVABLE WHICH PRESENTS A SAFETY HAZARD.I CAN SEE THAT THERE IS A MASSIVE AMOUNT OF INFO ON MANY VW INTERNET SITES ABOUT THIS ISSUE, IN FACT IF YOU SIMPLY GOOGLE 'VW DSG FLASHING PRNDS' OR 'VW DSG TRANSMISSION PROBLEMS' ANYONE CAN FIND IT. IT IS A COMMON PROBLEM. I SEE THAT HHTSA HAS BEGUN AN INVESTIGATION BASED ON THIS FOR 2007 THRU 2009 MODEL YEARS, OBVIOUSLY A PROBLEM ON 2005/2006 VW WITH DSG TRANSMISSION AS WELL. VW HAS INITIATED A NEW CUSTOMER SERVICE PROGRAM TO ADDRESS CUSTOMER CONCERNS RELATED TO CERTAIN DSG EQUIPPED MODELS BUT APPARENTLY MINE (AND MANY OTHERS) ARE NOT COVERED THEY SAY BY THIS PROGRAM- NEVERTHELESS A SAFETY ISSUE EXISTS WITH 2005 AND 2006 DSG EQUIPPED VW'S. I CALLED VW CUSTOMER SERVICE (NATIONAL) TODAY 11/3/11 AND REP SAID "I AM NOT AWARE OF THIS ISSUE' FOR THIS YEAR- SO THEY ARE EITHER LYING OR INCREDIBLY UNDERINFORMED. I HAD THE CAR TO VW DEALER FOR DIAGNOSIS, AND THEY STATED THAT A DIAGNOSTIC TEST SHOWED A MALFUNCTION IN A PART THAT CONTROLS TRANSMISSION OPERATION AND WAS CAUSING THE TRANSMISSION TO SHIFT INTO NEUTRAL BY ITSELF. THEIR RECOMMENDATION, "SPEND $2000 TO REPLACE THE PART, OR JUST GET A NEW TRANSMISSION = $4000. SINCE THERE IS OBVIOUSLY A SAFETY RELATED DESIGN FLAW THAT ALLOWS THE TRANSMISSION TO SHIFT ITSELF INTO NEUTRAL- I FEEL THE NHTSA SHOULD EXPAND THE INVESTIGATION TO INCLUDE ALL YEARS OF VW DSG TRANSMISSION EQUIPPED VEHICLES SOLD IN THE USA. *TR

3 OCT 2011: THIS VEHICLE'S FLYWHEEL ASSY FAILED AT APPROXIMATELY 85,000 MILES. FORTUNATELY, THE FAILURE OCCURRED WHILE I WAS AT A VERY LOW RATE OF SPEED IN A NON-CONGESTED AREA. AFTER THE EVENT, I HAVE COME TO REALIZE THAT THIS IS A KNOWN PROBLEM ON DSG TRANSMISSIONS AS INSTALLED ON A VARIETY OF VW MODELS. VW DOES NOT APPEAR TO BE INTERESTED IN DISCUSSING THIS ISSUE FOR MODEL YEARS 2005 / 2006. I AM ONE OF THE LUCKIER ONES AS I REGULARLY MAKE LONG DISTANCE - INTERSTATE TRIPS WITH FAMILY IN-TOW. VOLKSWAGEN SHOULD BE HELD ACCOUNTABLE TO ACCEPT FULL FINANCIAL RESPONSIBILITY TO NOT ONLY TAKE CARE OF CUSTOMERS WHO HAVE EXPERIENCED SUCH LOW-TIME FAILURES BUT, ALSO, EXPAND ANY RECALL THAT MAY BE IN-PLACE FOR LATER MODELS SO AS TO PREVENT POTENTIAL LIFE-THREATENING ACCIDENTS WITHIN THE OVERALL DRIVING POPULATION. I HAD BEEN DRIVING A "TIME BOMB" FOR ALMOST 5 YEARS AND, TO DATE, VOLKSWAGEN OF NORTH AMERICA HAS ONLY ISSUED A LIMITED RECALL FOR LATER MODELS, THE 2008-2010, I BELIEVE. THIS EPISODE WILL COST AT LEAST $3000.00 USD AND NONE OF IT IS COVERED BY VOLKSWAGEN. WHAT IS THE ROOT CAUSE OF THIS AND HOW DO I KNOW THAT MY REPLACEMENT DSG TRANSMISSION WILL NOT BE SUSCEPTIBLE TO THIS HAPPENING AGAIN CAUSING POTENTIAL VEHICLE, PROPERTY, AND PERSONAL DAMAGE IN THE FORM OF A VEHICLE "MISHAP".??? *TR

I HAVE A 2005 NEW JETTA AND AT AROUND 60,000 MILES IT SHIFTS HARD FROM 1ST TO 2ND GEAR AND 2ND TO 3RD GEAR. IT ALSO DOWNSHIFTS ABRUPTLY. THE HARD JERKING SCARES ME WHEN DRIVING BECAUSE IT CAN CAUSE AN ACCIDENT. AT SOME POINT VW HAS TO REALIZE THIS IS A SERIOUS SAFETY HAZARD. I GOT THE RECALL LETTER ABOUT THE VALVE BODY AND WHEN I TOOK IT TO A VW DEALER FOR SERVICE I WAS TOLD THAT MY CAR DIDN'T HAVE A VALVE BODY ISSUE. THEY SAID I NEEDED A NEW TRANSMISSION. COST $6,000. I CONTACTED VW BY PHONE AND WAS TOLD THERE WAS NOTHING THEY COULD DO. NOW AT CLOSE TO 70,000 MILES THE JERKING HAS WORSEN AND I HAVE BECOME VERY CONCERNED ABOUT THE SAFETY OF THIS CAR WHILE I'M DRIVING IT. *TR

I PURCHASED A 2005 NEW JETTA AUTOMATIC TRANSMISSION IN JULY OF 2010. IT CURRENTLY HAS 72,000 MILES. 3 ISSUES. ONE, WHEN THE CAR IS FIRST STARTED UP, A CLANGING NOISE OCCURS AND LASTS FOR APPROX 30 SECONDS, THEN IT SOUNDS LIKE A VENT CLOSES AND THE SOUND GOES AWAY. TWO, THE RIGHT FRONT HEADLIGHT WILL NOT TURN OFF SOMETIMES WHEN I PULL ALONG SIDE A CURB. I HAVE TO RESTART THE CAR, BACK THE CAR UP, THEN PULL THE CAR FORWARD TO GET IT TO TURN OFF. THE THIRD ITEM OCCURS INTERMITTENTLY NOT ALWAYS AND INVOLVES SHIFTING OF GEARS. WHEN THE CAR IS GOING APPROXIMATELY 20 TO 30 MILES PER HOUR, IT SEEMS TO BOUNCE BACK AND FORTH BETWEEN 2ND AND 3RD GEAR A LITTLE ROUGH BUT NOT JERKY AND SOMETIMES WHEN COASTING THROUGH AN INTERSECTION THE CAR SEEMS TO HESITATE WHEN I AM READY TO PUSH ON THE GAS. BUT THEN, AFTER A COUPLE SECONDS, ENGAGES INTO GEAR WITH A LUNGE. I RECENTLY TOOK THE CAR TO A TRANSMISSION SHOP FOR ANALYSIS AND THE MAN SAID HE COULD NOT PRODUCE ANY CODES. I TOLD HIM I HAD RECEIVED THE LETTER ABOUT THE TRANSMISSION'S VALVE BODY WARRANTY EXTENSION. HE DROVE THE CAR AND SAID THE CAR DEFINITELY LUNGES AND TOLD ME TO GET IT TO A VW DEALERSHIP FOR A CHECK UP AS HE WAS NOT AN AUTHORIZED VW TECH. I TOOK THE CAR TO THE NEAREST DEALERSHIP WHICH IS 2 HOURS AWAY FROM MY HOME. THEY DROVE THE CAR 3 SEPARATE TIMES TRYING TO PRODUCE THE SCENARIO I DESCRIBED BUT COULD NOT. THE TECH TOLD ME IT SOUNDED LIKE I WAS DESCRIBING THE VALVE BODY ISSUE AND HE WOULD TELL THE SERVICE ADVISOR THAT HE HAD FELT THE PROB AND THAT MY CAR NEEDED A NEW VALVE BODY. WHEN I PICKED UP MY CAR, THE CAR WOULD NOT DRIVE ABOVE 20 MPH WITHOUT THE ENGINE ROARING AND THE SHIFTING HARD INTO GEAR EVERYTIME. ME AND MY DAUGHTER HAD PULLED OUT INTO A VERY BUSY 40 MPH TRAFFIC. IT WAS SCARY. AT ONE POINT THE CAR WOULD NOT GO INTO ANY GEAR! I RETURNED THE CAR TO THE DEALERSHIP AND TOLD THEM SOMETHING WAS SERIOUSLY WRONG. NEXT DAY, THEY TOLD ME MY CAR NEEDS A NEW TRANSMISSION AT MY COST OF $5000. WHAT HAPPEN? *TR

JETTA 2005.5 SEDAN (AUTOMATIC) HARD SHIFTED BETWEEN 2ND & 3TH GEARS, DISPLAYING SHUDDERING AND HESITATION DURING ACCELERATION IN TRAFFIC. SINCE OCTOBER 2010 HARD SHIFTING HAS CONTINUED DAILY AND FREQUENCY OF SHIFTING HESITATION ISSUE HAS WORSENED. HARD SHIFTING WITH HESITATION UP BETWEEN 3TH AND 4TH, AND ALSO HARD SHUDDERING DOWNSHIFT BETWEEN 3RD AND 2ND. DEALER HOOKED VEHICLE TO COMPUTER ON FEB 14, 2011 AND STATED TRANSMISSION HAS NO ERRORS. DEALER WOULD NOT TEST DRIVE FOR LONGER THAN 4 MILES, DEALER STATED HARD SHIFT DID NOT OCCUR IN THAT 4 MILE PERIOD, TEST WAS NOT AT FREEWAY SPEEDS, OWNER WAS NOT IN THE VEHICLE. DEALER STATES VEHICLE IS NOT ELIGIBLE FOR VALVE FIX. VEHICLE SHIFTING FAILURE IS HAZARDOUS AND DANGEROUS HIGHWAY CONDITION.