IllustrationTHE HEATED SEAT ON THE PASSENGER SIDE OF OUR 2003 VW JETTA TDI GOT VERY HOT ON MY RIGHT LEG, I REACHED DOWN TO FEEL THE SEAT AND IT BURNT MY HAND. WE TURNED ON THE LIGHTS AND THE SEAT HAD A BURNED HOLE WITH SMOKE COMING OUT OF IT. HAD I BEEN WEARING MY COAT IT COULD HAVE CAUGHT FIRE BEFORE I FELT THE INTENSE HEAT. *TR
2003 Volkswagen Jetta
Owner reports · Recalls · Investigations
More warning signs than most Jetta years
Owner complaints for the 2003 Volkswagen Jetta are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jetta years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
790–25K
9225–50K
7650–75K
4875–100K
46100–150K
33150K+
374 reports with mileage · 81 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seats. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 97 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports70 fire reports76 injury reports
Seats complaints
100 reportsI USE MY HEATED SEATS ALMOST DAILY IN THE WINTER MONTHS. I USED IT THIS MORNING FOR ABOUT 20 MINUTES AS I DROVE FROM HOME TO THE GYM, THEN ANOTHER 10 MINUTES AS I DROVE FROM THE GYM TO THE STORE. WHEN I GOT INTO MY CAR AFTER THE STORE, IT WAS STILL ON THE SAME SETTING (5), I HAD DRIVEN ABOUT 50 YARDS IN THE PARKING LOT, WHEN I…
Read full complaint
I USE MY HEATED SEATS ALMOST DAILY IN THE WINTER MONTHS. I USED IT THIS MORNING FOR ABOUT 20 MINUTES AS I DROVE FROM HOME TO THE GYM, THEN ANOTHER 10 MINUTES AS I DROVE FROM THE GYM TO THE STORE. WHEN I GOT INTO MY CAR AFTER THE STORE, IT WAS STILL ON THE SAME SETTING (5), I HAD DRIVEN ABOUT 50 YARDS IN THE PARKING LOT, WHEN I FELT A SHARP PAIN IN MY LEFT UPPER LEG/BUTT. I MOVED SLIGHTLY, THEN BEGAN TO SMELL SMOKE. I FELT AROUND WITH MY HAND AND FELT THE "HOT" WIRE AND THE HOLE IN MY SEAT. IT TOOK ME A MOMENT TO REALIZE WHAT IT WAS, AND THEN I IMMEDIATELY TURNED DOWN THE HEATED SEAT TO OFF, THEREBY PREVENTING FURTHER DAMAGE AND PAIN. LUCKILY THERE WAS LIMITED DAMAGE TO MY CLOTHING AND I WAS NOT SERIOUSLY INJURED, BUT HAD I BEEN DRIVING ON THE HIGHWAY, OR NOT BEEN ABLE TO FIGURE OUT WHAT WAS CAUSING THE PAIN SO QUICKLY, THERE COULD HAVE BEEN MORE SEVERE CONSEQUENCES INCLUDING INJURY. *TR
I TURNED ON THE DRIVER'S SEAT HEATER TO 5 (HIGHEST SETTING) ON MY 2003 VW JETTA TDI WHEN LEAVING MY HOUSE AT 7 AM. I USED THIS REGULARLY TO WARM THE SEAT FOR A FEW MINUTES ON COLD MORNINGS, THEN WOULD TURN IT OFF (LOWER SETTINGS NEVER PRODUCED NOTICEABLE HEAT). WITHIN ONE MINUTE I FELT A BURNING/ELECTRICAL SENSATION IN MY UPPER …
Read full complaint
I TURNED ON THE DRIVER'S SEAT HEATER TO 5 (HIGHEST SETTING) ON MY 2003 VW JETTA TDI WHEN LEAVING MY HOUSE AT 7 AM. I USED THIS REGULARLY TO WARM THE SEAT FOR A FEW MINUTES ON COLD MORNINGS, THEN WOULD TURN IT OFF (LOWER SETTINGS NEVER PRODUCED NOTICEABLE HEAT). WITHIN ONE MINUTE I FELT A BURNING/ELECTRICAL SENSATION IN MY UPPER LEFT THIGH. I WAS DRIVING ON A MOUNTAIN ROAD AND THE PAIN MADE ME JUMP IN MY SEAT AND NEARLY LOSE CONTROL OF THE CAR. I PULLED OVER AND TURNED OFF THE SEAT HEATER (HAVING HEARD OF PROBLEMS WITH THE HEATER). THE LEATHER SEAT HAD A BLISTER ABOUT THE SIZE OF A CIGARETTE BURN BUT HAD NOT BURNED COMPLETELY THROUGH. WHILE I STOPPED THE HEATER BEFORE IT BURNED THROUGH THE SEAT (AND MY PANTS), THE REAL DANGER WAS IN A POSSIBLE ACCIDENT FROM THE BURN/SHOCK THAT CAUSED ME TO MOMENTARILY LOSE CONTROL OF THE CAR. THE SEAT HEATER IS NO LONGER SAFE TO OPERATE. MY UNDERSTANDING FROM READING SIMILAR POSTS HERE AND ELSEWHERE IS THAT THE WIRING IS NOW BROKEN IN THE SEAT (AND MANY HAVE HAD IT BREAK IN THE SAME SPOT). IF I HAD NOT GUESSED THE SOURCE OF THE PROBLEM QUICKLY, OR IF SOMEONE WERE TO UNKNOWINGLY USE THE HEAT SETTER IN THE FUTURE, IT COULD LEAD TO A SERIOUS ACCIDENT, PERSONAL INJURY, AND CAR FIRE. SIMILARLY, THIS POSES A SERIOUS RISK FOR OTHER DRIVERS OF THESE VEHICLES WHO MAY NOT BE AWARE OF THE PROBLEM AND REACT TOO LATE. I REQUEST THAT THE NHTSA URGE VW OF AMERICA TO ISSUE A RECALL ON THIS DANGEROUS AND PERVASIVE PROBLEM (MANY REPORTS HERE AND ELSEWHERE, SUCH AS TDICLUB.COM AND VWVORTEX.COM). VW HAS ISSUED A RECALL ON THIS PROBLEM IN CANADA BUT NOT IN THE U.S. THEY ALSO HAVE A VOLUNTARY REPAIR FOR PASSATS OF SIMILAR YEARS, BUT NOT JETTAS OR GOLFS. THANK YOU. *TR
THE HEATED SEATS IM MY 2003 VW JETTA STARTED TO CATCH ON FIRE. *TR
DRIVERS SIDE HEAT SEATER FAILED ABOUT 2 MONTHS AGO. IT GOT HOTTER THAN NORMAL WHEN ON SETTING #3, I TURNED IT OFF, AND FROM THAT POINT ON IT DIDN'T WORK. TWO DAYS AGO, I HAD THE DRIVERS SIDE SEAT HEATER REPLACED AT THE KAISERSLAUTERN, GERMANY VW DEALERSHIP. WHILE DRIVING HOME FROM WORK, THE SEAT BECAME EXTREMELY HOT WHILE ONL…
Read full complaint
DRIVERS SIDE HEAT SEATER FAILED ABOUT 2 MONTHS AGO. IT GOT HOTTER THAN NORMAL WHEN ON SETTING #3, I TURNED IT OFF, AND FROM THAT POINT ON IT DIDN'T WORK. TWO DAYS AGO, I HAD THE DRIVERS SIDE SEAT HEATER REPLACED AT THE KAISERSLAUTERN, GERMANY VW DEALERSHIP. WHILE DRIVING HOME FROM WORK, THE SEAT BECAME EXTREMELY HOT WHILE ONLY ON SETTING #2. IT WAS SO HOT, THAT I SMELLED SOMETHING BURNING, AND COULD NOT SIT DOWN WHILE DRIVING BECAUSE OF THE EXTREME PAIN TO MY BUTTOCKS. I REACHED DOWN WITH MY HAND TO CONFIRM THE HEAT AND ALSO BURNED MY HAND. NOTE THAT I WAS ONLY RUNNING THE SEAT HEATER ON LEVEL 2 OF 5 FOR APPROXIMATELY 5 MINUTES. UPON INSPECTION OF THE SEAT, THERE IS NOW A HARDENED PLASTIC FEELING AREA WHERE THE LEATHER ON THE SEAT WAS THE HOTTEST. HAD I NOT IMMEDIATELY TURNED OFF THE HEATER, IT IS VERY LIKELY THAT THE ENTIRE SEAT WOULD HAVE CAUGHT ON FLAMES. ADDITIONALLY, SINCE THIS OCCURRED WHILE DRIVING AND I WAS UNABLE TO PROPERLY SIT IN THE SEAT, AN ACCIDENT COULD MOST CERTAINLY HAVE OCCURRED ON THE SPOT. I IMMEDIATELY SPOKE WITH THE DEALERSHIP AND THEY SAID THEY WILL REPLACE THE HEATER BUT NOT THE SEAT. THEY SAY THE DAMAGE TO THE SEAT IS NOT EXTREME ENOUGH TO REPLACE THE ENTIRE THING. HOWEVER, I FEEL IT IS THEIR OBLIGATION TO REPLACE IT BECAUSE THE DAMAGE WAS CAUSED BY THEIR INSTALLATION OF A FACTORY ITEM THAT HAS ALREADY FAILED ONCE. *TR
HAD THE DRIVER'S SIDE HEAT SEATER ON. FELT A SHOCKING SENSATION AND SMELLED SMOKE. PULLED OVER, TURNED OFF HEAT SEATER AND EXITED CAR. THERE IS A HOLE BURNED IN THE SEAT AND IT TOOK OVER 5 MINUTES FOR IT TO STOP SMOKING. *TR
1. 2003 JETTA WAGON PASSENGER HEATED SEAT GOT EXTREMLY HOT AND THEN QUIT WORKING. *TR
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THERE WAS A RECALL ON THE HEATING SWITCH FOR THE SEATS IN HER DAUGHTER'S VEHICLE. THE FAILURE WAS REPLACED WITH A NEW SWITCH, BUT THE SWITCH FAILED A FEW MONTHS LATER. THE SWITCH BURNED THROUGH THE LEATHER SEAT AND WOULD NOT SHUT OFF. THE FAILURE OCCURRED W…
Read full complaint
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THERE WAS A RECALL ON THE HEATING SWITCH FOR THE SEATS IN HER DAUGHTER'S VEHICLE. THE FAILURE WAS REPLACED WITH A NEW SWITCH, BUT THE SWITCH FAILED A FEW MONTHS LATER. THE SWITCH BURNED THROUGH THE LEATHER SEAT AND WOULD NOT SHUT OFF. THE FAILURE OCCURRED WHILE DRIVING 55 MPH. THE CONTACT'S DAUGHTER SUSTAINED BLISTERS, A SCAR, AND MINOR BURNS. A POLICE REPORT WAS FILED. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 60,000 AND FAILURE MILEAGE WAS 50,000.
DRIVER'S ELECTRIC SEAT HEATER ELEMENT IN 2003 JETTA CAUGHT FIRE BURNING HOLE IN LEATHER SEAT AND BURNING DRIVER. *JB
TL*- THE CONTACT STATED THAT THE 2003 VOLKSWAGEN JETTA STATION WAGON, CAUGHT ON FIRE. THE CONTACT STATED THAT WHILE DRIVING 20-25 MPH THE DRIVER'S SIDE SEAT CAUGHT ON FIRE WHILE THE SEAT HEATER WAS OPERATING. THE SEAT SUSTAINED A HOLE THE DIAMETER OF A PENCIL. THE SEAT BURNED PASSENGER BUTTOCKS, BUT DIDN'T CATCH HIS CLOT…
Read full complaint
TL*- THE CONTACT STATED THAT THE 2003 VOLKSWAGEN JETTA STATION WAGON, CAUGHT ON FIRE. THE CONTACT STATED THAT WHILE DRIVING 20-25 MPH THE DRIVER'S SIDE SEAT CAUGHT ON FIRE WHILE THE SEAT HEATER WAS OPERATING. THE SEAT SUSTAINED A HOLE THE DIAMETER OF A PENCIL. THE SEAT BURNED PASSENGER BUTTOCKS, BUT DIDN'T CATCH HIS CLOTHING ON FIRE. *AK
Official recalls
218V406000 · Air Bags:frontal:driver Side:inflator Module
Jun 13, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X3.
07V063000 · Exterior Lighting:brake Lights:switch
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA04010 · Driver Side Front Seat Overheats
Opened Mar 30, 2004 · Closed Oct 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.
PE03052 · Driver Seat Overheats/burns
Opened Nov 19, 2003 · Closed Mar 30, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.