IllustrationTL*THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. THE CONTACT STATED THAT SHE EXPERIENCED PREMATURE CLUTCH FAILURE. THE CLUTCH WAS REPLACED AT 34,000 MILES. THE CURRENT MILEAGE IS 34,489 AND FAILURE MILEAGE WAS 34,000. UPDATED 09/17/07 *TR
2003 Volkswagen Jetta
Owner reports · Recalls · Investigations
More warning signs than most Jetta years
Owner complaints for the 2003 Volkswagen Jetta are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jetta years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
790–25K
9225–50K
7650–75K
4875–100K
46100–150K
33150K+
374 reports with mileage · 81 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seats. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 97 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports70 fire reports76 injury reports
Power Train complaints
54 reports2003 VW JETTA AT 40K MILES TRANS HAD TO BE REPLACED IN FEB 06, JUNE 06 SAME SYMPTOMS, TOLD BY DEALER NOT TO BE CONCERNED THAT THE SENSORS TAKE TIME TO ADJUST TO NEW TRANS, EMISSIONS LIGHT ON DEALER SAYS NOT TO WORRY IF IT DOES NOT STAY ON, CONTINUE TO CALL,WITH SAME RESPONSE. DEC 06 CAR LOSES POWER ON INTERSTATE TAKES TWO WKS T…
Read full complaint
2003 VW JETTA AT 40K MILES TRANS HAD TO BE REPLACED IN FEB 06, JUNE 06 SAME SYMPTOMS, TOLD BY DEALER NOT TO BE CONCERNED THAT THE SENSORS TAKE TIME TO ADJUST TO NEW TRANS, EMISSIONS LIGHT ON DEALER SAYS NOT TO WORRY IF IT DOES NOT STAY ON, CONTINUE TO CALL,WITH SAME RESPONSE. DEC 06 CAR LOSES POWER ON INTERSTATE TAKES TWO WKS TO MAKE AN APPT TO GET INTO DEALER, TOLD IT IS NOW THE TRANSMISSION CONTROL MODULE, VW WILL NOT WARRANTY ALTHOUGH THIS PART WAS NOT CHKD WHEN TRANS REPLACED, TOLD THIS PART IS THE BRAIN TO TRANS IT TELLS TRANS WHEN TO SHIFT. DEALER AND VW OF NO HELP. LOOKED AT CONSUMER AFFAIRS ON THE INTERNET NOTICED HUGE AMOUNT OF PEOPLE HAVING SAME PROBLEMS AS I SAME YEAR SAME MODEL. THE ECM LIGHT STAYS ON AND IS NOT EMITTING SMOKE. *NM
DT*: THE CONTACT STATED WHEN THE SPEEDOMETER READ 70 MPH, THE VEHICLE WAS TRAVELING 97.3 MPH. THE DEALERSHIP DETERMINED THE GEAR BUSHING WAS BAD AND NEEDED TO BE REPLACED. THE PART NUMBER FOR THE GEAR WAS: 01M-409-187. THE PART NUMBER FOR THE BUSHING WAS: 095-409-190. THE DEALERSHIP INFORMED THE CONTACT, THE MANUFACTURER NEE…
Read full complaint
DT*: THE CONTACT STATED WHEN THE SPEEDOMETER READ 70 MPH, THE VEHICLE WAS TRAVELING 97.3 MPH. THE DEALERSHIP DETERMINED THE GEAR BUSHING WAS BAD AND NEEDED TO BE REPLACED. THE PART NUMBER FOR THE GEAR WAS: 01M-409-187. THE PART NUMBER FOR THE BUSHING WAS: 095-409-190. THE DEALERSHIP INFORMED THE CONTACT, THE MANUFACTURER NEEDED TO KEEP THE OLD GEAR AND BUSHING. THE CONTACT DID NOT AGREE AND WANTED THE OLD PARTS. *AK
2003 VW JETTA CLUTCH AND FLYWHEEL OUT AT 47,962 MILES. I AM AN EXPERIENCED MANUAL TRANSMISSION DRIVER. THIS IS NOT MY FAULT, AND THIS IS VERY PREMATURE FOR A CLUTCH FAILURE. THE DEALERSHIP WANTS $2088.00 PLUS TAX FOR PARTS AND LABOR. MY DEALERSHIP QUOTED ME AT $1400 BACK HOME, BUT IM STUCK IN COLORADO WAITING FOR THE CUSTOMER CA…
Read full complaint
2003 VW JETTA CLUTCH AND FLYWHEEL OUT AT 47,962 MILES. I AM AN EXPERIENCED MANUAL TRANSMISSION DRIVER. THIS IS NOT MY FAULT, AND THIS IS VERY PREMATURE FOR A CLUTCH FAILURE. THE DEALERSHIP WANTS $2088.00 PLUS TAX FOR PARTS AND LABOR. MY DEALERSHIP QUOTED ME AT $1400 BACK HOME, BUT IM STUCK IN COLORADO WAITING FOR THE CUSTOMER CARE TO GET BACK TO ME. EVERY INDEPENDENT MECHANIC I HAVE TALKED TO INCLUDING VW CERTIFIED; BUT NOT AFFILIATED HAVE TOLD ME THAT EVEN THE WORST CLUTCH -RIDER(WHICH I AM NOT) WOULD HAVE CLUTCH FAILURE AT ABOUT 100,000 MILES. VW IS TOO CHEAP TO SUBMIT A RECALL FOR THE CLUTCH ASSEMBLIES ON THEIR 2000-2004 VEHICLES. WITH THE VOLUME OF COMPLAINTS ALL OVER THE WEB AND EVEN ON THIS SITE, THERE IS NO DOUBT IN MY MIND THAT THERE IS A SERIOUS PROBLEM THAT NEEDS TO BE ADDRESSED, AND IM NOT JUST SPEAKING ABOUT THE EXTREMELY OUTRAGEOUS REPLACEMENT AND REPAIR COSTS. PLUS! THEY NOW USE NON- RE-SURFACE FLYWHEELS...*JB
DT*: THE CONTACT STATED WHILE DRIVING AT 35 MPH ON NORMAL ROAD CONDITION PROBLEMS WERE NOTICE WITH THE TRACTION BUTTON FOR THE ESP SYSTEM. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO DETERMINED THE BLACK BRAKE SWITCH FAILED. THE BRAKE LIGHT SWITCH HAS BEEN REPLACED FOR THE PURPLE BRAKE LIGHT SWITCH TWICE. THE BLACK BRAKE LIG…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING AT 35 MPH ON NORMAL ROAD CONDITION PROBLEMS WERE NOTICE WITH THE TRACTION BUTTON FOR THE ESP SYSTEM. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO DETERMINED THE BLACK BRAKE SWITCH FAILED. THE BRAKE LIGHT SWITCH HAS BEEN REPLACED FOR THE PURPLE BRAKE LIGHT SWITCH TWICE. THE BLACK BRAKE LIGHT SWITCH HAD A RECALL FOR 2002 MODEL BUT DOES NOT COVER THE 2003 MODELS. ADDITIONAL PROBLEMS ARE ASSOCIATED WITH THE BRAKE SWITCH, WHICH INCLUDES THE TRACTION BUTTON FOR THE ESP SYSTEM AND THE PARK POSITION LEVER WHICH LOCKS OFTEN. ALSO THE CONTACT ONCE BECAME STRANDED ON A HIGHWAY WHEN THE VEHICLE STALLED AND COULD NOT BE RESTARTED. THE VEHICLE WAS TOWED TO THE DEALERSHIP WHO REPLACED THE IGNITION COIL. ALL REPAIRS MADE BY THE DEALERSHIP HAS BEEN COVERED BY THE VEHICLE WARRANTY. THE CONTACT EXPRESSED CONCERN ABOUT BRAKE LIGHTS BECAUSE REPRESENTS SERIOUS SAFETY PROBLEM
DT*: THE CONTACT STATED THE VEHICLE WOULD NOT COME OUT OF PARK WHEN STARTED. THE DEALERSHIP REPLACED THE BRAKE LIGHT SWITCH HOWEVER THE PROBLEM STILL EXISTS. THE MANUFACTURER WAS ALERTED.
THE CLUTCH ON MY 03' VW JETTA HAS BEEN FAILING SINCE DAY ONE , I NOW HAVE 42,000 KMS. WHEN I BOUGHT THE CAR. REVERSE, SECOND GEAR AND THIRD GEAR ALL HAVE PROBLEMS. THIS PROBLEM HAS BEEN GOING ON WITH EVERY PERSON WITH A MANUAL JETTA, ESPECIALLY A 1.8T. I THINK VWOA SHOULD RECALL THE CLUTCH AND TRANSMISSION AND CORRECT THIS PROBL…
Read full complaint
THE CLUTCH ON MY 03' VW JETTA HAS BEEN FAILING SINCE DAY ONE , I NOW HAVE 42,000 KMS. WHEN I BOUGHT THE CAR. REVERSE, SECOND GEAR AND THIRD GEAR ALL HAVE PROBLEMS. THIS PROBLEM HAS BEEN GOING ON WITH EVERY PERSON WITH A MANUAL JETTA, ESPECIALLY A 1.8T. I THINK VWOA SHOULD RECALL THE CLUTCH AND TRANSMISSION AND CORRECT THIS PROBLEM. WE SPEND HARD EARNED MONEY ON OUR CARS AND DO NOT DESERVE A PROBLEM LIKE THIS ON BRAND NEW CARS. *JB
* 2003 VOLKSWAGEN JETTA WITH 38,116 MILES / ONE OWNER * VW CASE # 50260581 * REPAIR LOCATION: NORTH POINT VW, SHERWOOD, AR (501) 945-5353 THE PROBLEM THIS VEHICLE'S CLUTCH AND FLYWHEEL BOTH FAILED (COMPLETELY WORN) AT 38,116 MILES, WELL BEFORE THE AVERAGE EXPECTED LIFE... POSSIBLE MATERIAL DEFICIENCY. BACKGROUND ALL…
Read full complaint
* 2003 VOLKSWAGEN JETTA WITH 38,116 MILES / ONE OWNER * VW CASE # 50260581 * REPAIR LOCATION: NORTH POINT VW, SHERWOOD, AR (501) 945-5353 THE PROBLEM THIS VEHICLE'S CLUTCH AND FLYWHEEL BOTH FAILED (COMPLETELY WORN) AT 38,116 MILES, WELL BEFORE THE AVERAGE EXPECTED LIFE... POSSIBLE MATERIAL DEFICIENCY. BACKGROUND ALL SERVICE FOR THE VEHICLE HAS BEEN COMPLETED AND DOCUMENTED WITH VW. THIS VEHICLE HAS NOT BEEN SUBJECTED TO ANY EXTREME DRIVING IN ANY WAY. MANUFACTURER'S ASSISTANCE NONE. THE CLUTCH IS A WEAR ITEM AND THEREFORE NOT COVERED BY THE WARRANTY. ALTHOUGH THE LOCAL SERVICE MANAGER AGREES THAT A CLUTCH SHOULD NOT FAIL AT THIS LOW MILEAGE, NEITHER HE, OR THE VW HELP CENTER (800 411-6688) WOULD HELP IN THE $1,600 REPAIR. BOTTOM LINE AFTER DOING A GOOGLE SEARCH FOR "VW JETTA CLUTCH FAILURE", I NOTED NUMEROUS REPORTS OF PREMATURE VW CLUTCH FAILURE. IS THIS A "WEAK LINK" IN THIS VEHICLE? IS VW TRYING TO HIDE AN INFERIOR PART?
BLOWN CLUTCH ON NEW 2003 VW JETTA TDI 1.8. FIRST OCCURANCE IN AUGUST OF 04 WITH 26,000 MILES AND AGAIN NOW IN MAY OF 05 WITH 40,500 OR 14,000 MILES TO ANOTHER BLOWN CLUTCH. I AM NOT A TEENAGE DRIVER, I AM 23 WITH EXCELLENT DRIVING SKILLS AND HAVE DRIVEN CLUTCHES ALL MY ADULT DRIVING LIFE. THERE IS SOMETHING WRONG WITH THEIR …
Read full complaint
BLOWN CLUTCH ON NEW 2003 VW JETTA TDI 1.8. FIRST OCCURANCE IN AUGUST OF 04 WITH 26,000 MILES AND AGAIN NOW IN MAY OF 05 WITH 40,500 OR 14,000 MILES TO ANOTHER BLOWN CLUTCH. I AM NOT A TEENAGE DRIVER, I AM 23 WITH EXCELLENT DRIVING SKILLS AND HAVE DRIVEN CLUTCHES ALL MY ADULT DRIVING LIFE. THERE IS SOMETHING WRONG WITH THEIR CLUTCH SYSTEM. I HAVE FOUND TONS OF EVIDENCE IN BULLETIN BOARDS. VW IS BLAMING THIS ON POOR DRIVING SKILLS AND I BELIEVE THIS IS A SERIOUS DEFECT THAT OCCURS EVERY 20,000 MILES. CONSUMERS LIKE ME ARE GETTIGN RIPPED OFF ON THIS ONE LEFT AND RIGHT. YOU NEED TO DO SOMETHING. THIS IS NO ISOLATED INCIDENT!
NORMAL DRIVING CONDITIONS CLUTCH BURNED OUT AT 21,851 MILES NEED TO REPLACE CLUTCH
Official recalls
218V406000 · Air Bags:frontal:driver Side:inflator Module
Jun 13, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X3.
07V063000 · Exterior Lighting:brake Lights:switch
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA04010 · Driver Side Front Seat Overheats
Opened Mar 30, 2004 · Closed Oct 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.
PE03052 · Driver Seat Overheats/burns
Opened Nov 19, 2003 · Closed Mar 30, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.