NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
27 reportsClear category filter150,000 miles · Aug 30, 2018
Exterior Lighting
DRIVING HELLO ALL STATE ROUTE AFTER DARK AT 55 MI./H THE HEADLIGHTS WENT OUT COMPLETELY AND THEN CAME BACK ON IN A SHORT MATTER OF SECONDS. HAD THE ROAD NOT BEEN STRAIGHT AT THAT SECTION I COULD HAVE VERY EASILY COLLIDED WITH TREES OR GUARDRAILS. THE 1ST TIME THIS HAPPENED WAS 2012-08-01. I HAD THE LOCAL VOLKSWAGEN EXPERT GARAGE…
Read full complaint
DRIVING HELLO ALL STATE ROUTE AFTER DARK AT 55 MI./H THE HEADLIGHTS WENT OUT COMPLETELY AND THEN CAME BACK ON IN A SHORT MATTER OF SECONDS. HAD THE ROAD NOT BEEN STRAIGHT AT THAT SECTION I COULD HAVE VERY EASILY COLLIDED WITH TREES OR GUARDRAILS. THE 1ST TIME THIS HAPPENED WAS 2012-08-01. I HAD THE LOCAL VOLKSWAGEN EXPERT GARAGE REPLACED THE HEADLIGHTS STOCK. THE NEXT TIME THAT OCCURRED WAS JULY 2018. THIS IS A SEVERE SAFETY HAZARD I HAVE NOT SOUGHT ANY REPAIRS YET.
NHTSA ODI #11123561
220,185 miles · Aug 10, 2017
Electrical SystemExterior LightingFuel/propulsion System
MY CAR GOT HACKED MY CHARLIE MILLER AND CHRIS VALASEK WAS SEEN OVER AT MY NEIGHBORS HOUSE ON 4/29/2017 AND MY EX BOSS CHRIS STUTZ JR IS IN CHARGE OF ALL THE BREAK IN OF MY HOUSE AND CARS EDWARDSVILLE POLICE WILL NOT DO ANYTHING BECAUSE THE POLICE ARE FRIEND OF THEM I HOPE I DON'T GET KILLED OVER THESE HACKS BUT IF THAT'S WHAT I…
Read full complaint
MY CAR GOT HACKED MY CHARLIE MILLER AND CHRIS VALASEK WAS SEEN OVER AT MY NEIGHBORS HOUSE ON 4/29/2017 AND MY EX BOSS CHRIS STUTZ JR IS IN CHARGE OF ALL THE BREAK IN OF MY HOUSE AND CARS EDWARDSVILLE POLICE WILL NOT DO ANYTHING BECAUSE THE POLICE ARE FRIEND OF THEM I HOPE I DON'T GET KILLED OVER THESE HACKS BUT IF THAT'S WHAT IT WILL TAKE TO DO ANYTHING ABOUT IT
NHTSA ODI #11014091
Mileage unknown · Aug 24, 2009
Exterior Lighting
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 50 MPH ON NORMAL ROAD CONDITIONS; THE BRAKE WARNING LIGHT INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND THE FAILURE WAS CONTRIBUTED TO THE BRAKE LIGHT SWITCH. THE VEHICLE WAS…
Read full complaint
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 50 MPH ON NORMAL ROAD CONDITIONS; THE BRAKE WARNING LIGHT INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND THE FAILURE WAS CONTRIBUTED TO THE BRAKE LIGHT SWITCH. THE VEHICLE WAS REPAIRED; HOWEVER, ON A SEPARATE OCCASION THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR THE IDENTICAL FAILURE. NHTSA CAMPAIGN ID NUMBER 07V063000, EXTERIOR LIGHTING,BRAKE LIGHTS; SWITCH WAS REPAIRED PER THE RECALL. THE FAILURE RECURRED AFTER THE RECALL REMEDY WAS PERFORMED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 95,000.
NHTSA ODI #10281535
Mileage unknown · Jan 5, 2009
Exterior Lighting
I HAVE BEEN PULLED OVER BY POLICE MULTIPLE TIMES OVER THE YEARS WITH THIS VEHICLE DUE TO REAR LIGHTS NOT WORKING PROPERLY. AT ONE POINT, BOTH OF MY TAIL LIGHTS WERE NOT FUNCTIONING -- THIS WAS VERY DANGEROUS. I HAVE REPLACED THEM EACH TIME AND THEY SEEM TO GO OUT QUITE FREQUENTLY. I HAVE NOTICED TAIL LIGHTS BEING OUT ON CARS …
Read full complaint
I HAVE BEEN PULLED OVER BY POLICE MULTIPLE TIMES OVER THE YEARS WITH THIS VEHICLE DUE TO REAR LIGHTS NOT WORKING PROPERLY. AT ONE POINT, BOTH OF MY TAIL LIGHTS WERE NOT FUNCTIONING -- THIS WAS VERY DANGEROUS. I HAVE REPLACED THEM EACH TIME AND THEY SEEM TO GO OUT QUITE FREQUENTLY. I HAVE NOTICED TAIL LIGHTS BEING OUT ON CARS WITH THE SAME MAKE AND MODEL AS MINE. *TR
NHTSA ODI #10253851
84,000 miles · Nov 10, 2008
Electrical SystemEngine And Engine CoolingExterior Lighting
I HAVE HAD 27 THINGS BREAK OR FAIL ON MY 03VW JETTA 1.8T. I BOUGHT THE CAR USED IN 01/06 WITH 32,000 MILES. AFTER BUYING THE CAR THE FIRST FIVE MINS THE WINDOW SHATTERED. FIRST TWO MONTHS 2 TIRES BLEW OUT, FRONT RIM CRACKED, BACK TIRES OUT OF ALIGNMENT. DEALER PAID TO FIX RIM BROKE 2 WEEKS LATER THE DEALER PAID FO USED SET OF S…
Read full complaint
I HAVE HAD 27 THINGS BREAK OR FAIL ON MY 03VW JETTA 1.8T. I BOUGHT THE CAR USED IN 01/06 WITH 32,000 MILES. AFTER BUYING THE CAR THE FIRST FIVE MINS THE WINDOW SHATTERED. FIRST TWO MONTHS 2 TIRES BLEW OUT, FRONT RIM CRACKED, BACK TIRES OUT OF ALIGNMENT. DEALER PAID TO FIX RIM BROKE 2 WEEKS LATER THE DEALER PAID FO USED SET OF SIMILAR RIMS. EVERY LIGHT INSIDE AND OUT WENT OUT BY 05/06 DRIVER SEAT WONT RAISE UP CARGO NET IN TRUNK FALLS APART DEALER WONT COVER. GAS AND TRUNK RELEASE BUTTONS FELL DOWN INSIDE OF DOOR. RADIO STOPPED WORKING FRONT DOOR SPEAKERS ARE SHORTING OUT. DRIVER WINDOW SWITCH GOES UP WHEN YOU PUSH DOWN AND DOWN WHEN YOU PUSH DOWN HAVE TO FIDDLE WITH IT FOR IT TO GO UP. EXHAUST HANGER BROKE CAUSING CHATTER. SWAYBAR BUSHING FELL OUT CAUSING GRINDING AND SHAKING WHEN EVER MOVING. NOT COVER BY WARRANTY ALL THESE HAPPENED BY 05/07. NOW ITS 10/08 AND I HAVE 84,000 MILES. CURRENT PROBLEMS ARE REAR SPOILER BRAKE LIGHT HANGS DOWN(DEALER JUST GLUED IT IN PLACE LASTED ABOUT 4 MONTHS) CAM AND CRANK SEALS LEAKING OIL CAUSE ODOR INSIDE OF CABIN. IF I DRIVE FOR MORE THEN AN HOUR I GET SICK AND LIGHT-HEADED. SEAT, CARGO NET IN TRUNK, IS STILL BROKEN. RADIO STILL ISN'T FIXED SO I JUST WENT AND BOUGHT AN AFTER MARKET. SPEAKERS STILL SHORTENING OUT ONLY WHEN ITS COLD OUT. KEYLESS ENTRY ONLY WORKS WITHIN 4FT OF THE CAR. IN THE WINTER THE CAR ONLY GETS 18MPG ON THE HIGHWAY AND ABOUT 14 IN THE CITY AND THE CAR IS PARKED IN A HEATED UNDERGROUND GARAGE. *TR
NHTSA ODI #10248367
70,000 miles · Jan 23, 2008
Exterior Lighting
BRAKE LIGHT SWITCH FAILED CAUSING BRAKES LIGHTS TO STAY ILLUMINATED EVEN WHEN THE CAR IS TURNED OFF AND THE KEY REMOVED. *TR
NHTSA ODI #10215738
Mileage unknown · Nov 14, 2007
Exterior Lighting
THE FRONT HEADLIGHT LENSES HAVE OXIDIZED/DETERIORATED AND HAS DIFFUSED THE LIGHT TO THE POINT IT IS UNSAFE TO DRIVE AT NIGHT. I HAD THE LENSES POLISHED TWO YEARS AGO, AND NOW THEY NEED POLISHING AGAIN. I DON'T FEEL THAT I SHOULD HAVE TO BEAR THE BURDEN OF A SAFETY ISSUE LIKE THIS. *TR
NHTSA ODI #10208938
Mileage unknown · Sep 17, 2007
Exterior Lighting
MAY OF 2004, VEHICLE BEGINS "LUNGING" WHEN PRESSING THE ACCELERATOR. ACCORDING TO DEALERSHIP FINDINGS THERE WAS A TSB ON THIS ISSUE AND SOFTWARE WAS OUTDATED AND UPDATED BY DEALERSHIP. THIS SEEMED TO HAVE CORRECTED THE PROBLEM UNTIL OCTOBER 2004 WHEN THE "LUNGING" BEGAN OCCURRING AGAIN. ACCORDING TO DEALERSHIP, A BRAKE LIGHT SWI…
Read full complaint
MAY OF 2004, VEHICLE BEGINS "LUNGING" WHEN PRESSING THE ACCELERATOR. ACCORDING TO DEALERSHIP FINDINGS THERE WAS A TSB ON THIS ISSUE AND SOFTWARE WAS OUTDATED AND UPDATED BY DEALERSHIP. THIS SEEMED TO HAVE CORRECTED THE PROBLEM UNTIL OCTOBER 2004 WHEN THE "LUNGING" BEGAN OCCURRING AGAIN. ACCORDING TO DEALERSHIP, A BRAKE LIGHT SWITCH CODE WAS FOUND IN THE ABS SECTION OF THE COMPUTER AND THE SWITCH WAS REPLACED TO RESOLVE THE ISSUE. MARCH OF 2005, "LUNGING" SYMPTOMS RETURNED. DEALERSHIP CLAIMED THEY COULD NOT FIND A PROBLEM THIS TIME. REPORTED SAME ISSUE AGAIN SEPTEMBER OF 2005, ISSUE NOT DIAGNOSED ONCE AGAIN. BRAKE AND TAIL LIGHTS HAVE BEEN REPLACED AT LEAST 6 TIMES UP TO JANUARY 2006. DEALERSHIP COULD NOT FIND ANY ISSUES, BUT SWAPPED CIRCUIT BOARDS FROM ONE SIDE TO THE OTHER AND CHECKED RESISTANCE OF THE CIRCUITS. SWAPPED BULB SOCKETS AND CLAIMED ISSUE RESOLVED. REPORTED SAME "LUNGING" ISSUE AS ABOVE, AGAIN FEBRUARY OF 2006. DEALERSHIP CLAIMED THROTTLE BODY EXTREMELY DIRTY. ISSUE RESOLVED FOR BRIEF STINT. JUNE OF 2006 TAIL LIGHTS CONTINUE TO BURN OUT. DEALERSHIP CLAIMS NO ISSUE FOUND. MAY OF 2007, BRAKE LIGHT SWITCH REPLACED UNDER RECALL CAMPAIGN. LIGHT BULBS HAVE NOT BURNED OUT SINCE THIS REPLACEMENT. VW OF AMERICA, INC. REFUSES TO PAY FOR SERVICE CHARGES INCURRED TO SWAP CIRCUIT BOARDS EVEN THOUGH IT IS CLEARLY DUE TO FAULTY BRAKE LIGHT SWITCH REPLACEMENT BACK IN OCTOBER OF 2004 (SAME DEFECTIVE SWITCH WAS USED AS REPLACEMENT). THERE IS A CLEAR LINE LEADING TO THE SWITCH BEING THE CAUSE OF ALMOST ALL LISTED PROBLEMS. ONCE THE RECALL WAS COMPLETE, THE ISSUES HAVE CEASED. *JB
NHTSA ODI #10203227
5,000 miles · Jul 22, 2007
Electrical SystemEngine And Engine CoolingEquipmentCrash
I HAVE OWNED A VOLKSWAGEN JETTA (TURBO - 2003) AND HAVE HAD ONE HORRIBLE PROBLEM AFTER ANOTHER. WITHOUT FAIL, I HAVE TAKEN MY VEHICLE IN FOR RANDOM MECHANICAL REPAIRS EVERY FEW MONTHS SINCE PURCHASING THE VEHICLE. I FOUND OUT THE CAR WAS MANUFACTURED IN MEXICO AND THAT VW WAS AWARE OF HOW BAD THEIR CAR'S MANUFACTURED IN MEXICO…
Read full complaint
I HAVE OWNED A VOLKSWAGEN JETTA (TURBO - 2003) AND HAVE HAD ONE HORRIBLE PROBLEM AFTER ANOTHER. WITHOUT FAIL, I HAVE TAKEN MY VEHICLE IN FOR RANDOM MECHANICAL REPAIRS EVERY FEW MONTHS SINCE PURCHASING THE VEHICLE. I FOUND OUT THE CAR WAS MANUFACTURED IN MEXICO AND THAT VW WAS AWARE OF HOW BAD THEIR CAR'S MANUFACTURED IN MEXICO WERE. IF THAT IS THE CASE, HOW CAN SO MANY CAR OWNERS WITH SO MANY MECHANICAL ISSUES CONTINUE TO SELL IN THIS COUNTRY? I WOULD LIKE TO REPORT VW FOR LACKLUSTER PERFORMANCE AND FOR CONTINUING MANUFACTURE IN AN AREA WELL KNOWN FOR ITS BELOW AVERAGE STANDARDS AND FOR CONTINUING TO BLEED THE CONSUMER WHEN IT IS FULLY AWARE OF THE ISSUE. *TR
NHTSA ODI #10197150
63,180 miles · Dec 11, 2006
Exterior Lighting
DT*: THE CONTACT STATED WHILE TRAVELING 45 MPH, THE REAR BRAKE LIGHTS STAYED ILLUMINATED WITHOUT DEPRESSING THE BRAKE PEDAL. THERE WAS A NHTSA RECALL #04V096000, REGARDING EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE YEAR. UPDATED 08/1/07 *TR
NHTSA ODI #10175748
Official recalls
2Jun 13, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X3.
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA04010 · Driver Side Front Seat Overheats
Opened Mar 30, 2004 · Closed Oct 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.
PE03052 · Driver Seat Overheats/burns
Opened Nov 19, 2003 · Closed Mar 30, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.
Illustration