Seats. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 97 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

25 crash reports70 fire reports76 injury reports

Electrical System complaints

97 reports

Clear category filter

56,000 miles · Dec 23, 2013

Electrical SystemPower Train

THE REAR O2 SENSOR ON MY 2003 VOLKSWAGEN JETTA FAILED CAUSING THE MIL INDICATOR TO ILLUMINATE. THE SENSOR HAD TO BE REPLACED, AND IS NOT COVERED UNDER THE EXTENDED WARRANTY FOR EMISSIONS. *TR

NHTSA ODI #10557097

61,000 miles · Dec 23, 2013

Electrical System

MY 2003 VOLKSWAGEN JETTA HAS EXPERIENCED A COIL PACK FAILURE CAUSING A REDUCTION IN POWER, AND THE ENGINE TO MISFIRE. ACCORDING TO THE VOLKSWAGEN DEALER, THE HOUSING OF THE COIL PACK WAS CRACKED WHICH ALLOWED MOISTURE TO AFFECT ITS OPERATION. THE DEALER ALSO STATED THAT THERE IS NO RECALL OR REPLACEMENT PROGRAM FOR 4 CYLINDER EN…

Read full complaint

NHTSA ODI #10557087

94,000 miles · Oct 10, 2013

Electrical SystemEngine

Read full complaint

ALL WARNING INDICATORS (ABS, CEL, AIRBAG, ECP, BATTERY AND OTHER INSTRUMENT DASH PANEL LIGHTS) WOULD FLICKER REPETITIVELY UNTIL THE CAR LOST ALL POWER. AFTER INSPECTION OF THE ENGINE COMPARTMENT IT WAS FOUND THAT THE ALTERNATOR CABLE THAT ATTACHES TO THE FUSE BOX LOCATED ON TOP OF THE BATTERY WAS MELTING THE FUSE BOX AND CAUSING POWER DISTRIBUTION PROBLEMS. THE VOLKSWAGEN DEALER RECOMMENDED THAT THEY BOTH BE REPLACED AS THE CABLE COULD HAVE BECOME HIGH RESISTANCE THEREBY CAUSING EXCESSIVE HEAT AT THE FUSE BOX. I HAD THE ALTERNATOR CABLE REPLACED WITH AN OEM PART AND THE FUSE BOX WITH AN AFTERMARKET PART. ON 10-9-13 WITH 104K MILES WHILE DRIVING TO WORK AT 6AM IN THE MORNING, THE EXACT SAME SYMPTOMS WERE EXPERIENCED AGAIN. LUCKILY I WAS ON A SIDE ROAD AND WAS TOWED TO A DEALER WHICH SAID THAT ALL OEM PARTS SHOULD BE USED AND THAT THIS IS COMMON AS THEY HAD JUST REPLACED THE ALTERNATOR CABLE ON ANOTHER JETTA OF THE SAME GENERATION. I REQUESTED THE DEALER CHECK THE ENTIRE ELECTRICAL SYSTEM INCLUDING THE ALTERNATOR BECAUSE THE PARTS THAT WERE INSTALLED LAST YEAR SHOULD NOT GO BAD IN 1 YEAR, THE DEALER SAID THERE WAS NO OTHER ISSUE. I AM NOT THE ONLY ONE EXPERIENCING A MELTING FUSE BOX. AT THE LINKS BELOW ARE OTHERS WHO HAVE EXPERIENCED THE SAME THING, EVEN ACROSS OTHER VW MODELS. THERE SEEMS TO BE A SERIOUS PROBLEM OF MELTING OF FUSE BOXES WHICH CAN OCCUR AT ANY TIME THE VEHICLE IS IN OPERATION. (WITH PICTURES) HTTP://FORUMS.FOURTITUDE.COM/SHOWTHREAD.PHP?4562591 HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?4682918-WHY-S-MY-FUSE-BOX-MELTING HTTP://NEWBEETLE.ORG/FORUMS/QUESTIONS-ISSUES-CONCERNS-PROBLEMS-NEW-BEETLE/28982-BATTERY-FUSE-BOX-MELTING-04-NEW-BEETLE.HTML HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?4705261-BATTERY-LIGHT-FLICKERING-ON-ACCELERATION HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?4829541-BURNT-BLACK-CABLE-FUSE-BOX-ON-TOP-OF-BATTERY. *TR

NHTSA ODI #10547473

40,000 miles · Sep 21, 2013

Electrical System

REAR PASSENGER DOORS FAIL TO RESPOND TO KEY FOB. STAY LOCKED/ UNLOCKED.

NHTSA ODI #10544779

145,000 miles · Jun 10, 2013

Electrical SystemEngineFire

THE CAR WAS PARKED FOR TWO DAYS WITHOUT BEING DRIVEN. WHILE IT WAS PARKED, NEIGHBORS RAN OVER TO REPORT IT WAS SMOKING UNDER THE HOOD. WE SAW THAT THERE WERE FLAMES COMING OUT FROM UNDERNEATH THE FRONT OF THE CAR. FIRE DEPARTMENT CAME, BUT FIRE HAD ALREADY EXTINGUISHED ITSELF. FIRE DEPARTMENT DISCONNECTED THE BATTERY GROUND …

Read full complaint

NHTSA ODI #10515974

153,000 miles · Mar 1, 2013

Electrical SystemSeatsInjury

Read full complaint

BOTH FRONT SEATS, THE BOTTOM RIGHT SIDE BOLSTER BURNED. THE HEATED FRONT SEATS WILL OVER HEAT, THE FAILURE APPEARS TO BE CONFINED TO THE RIGHT BOLSTER ON THE BOTTOM SECTION OF THE SEAT. THE HEATING ELEMENTS GET HOT ENOUGH TO BURN THROUGH THE SEAT MATERIAL. BEING THE SIDE OF THE SEAT I WAS ABLE TO SHIFT MY LEG AWAY AND POWER OFF THE HEATED SEAT. IF LEFT ON THE SEATS WILL START TO SMOKE. I CONSIDER THIS A SAFETY ISSUE, I HAVEN'T TRIED , BUT IT SEEMS AS THOUGH THE SEAT COULD CATCH ON FIRE IF LEFT ON. THE LOCAL DEALER'S SERVICE REP SAID JUST UNPLUG IT THE OPTION. *TR

NHTSA ODI #10500938

120,000 miles · Jan 30, 2012

Electrical SystemSeatsFire

Read full complaint

DRIVER'S SEAT HEATER MALFUNCTIONED. RIGHT SIDE OF SEAT HAS SMALL BURN MARKS, IS DISCOLORED, HAS EXPOSED ELEMENTS, AND SEAT FOAM IS MELTED. TWO PAIRS OF PANTS OBTAINED SINGE MARKS ON SEPARATE OCCASIONS. I DRIVE THE CAR TO AND FROM THE CITY VIA INTERSTATE FOR 40 MINUTES EACH WAY. SEAT HEATERS ARE TYPICALLY ON FOR ABOUT 20 MINUTES. BEGINNING IN NOVEMBER WHEN I USED THE SEAT HEATERS I COULD SMELL A SLIGHT BURNING SMELL. SINCE IT WAS THE BEGINNING OF THE WINTER SEASON I FIGURED IT WAS JUST HEATED DUST ON MY SEATS FROM BEING INACTIVE ALL SUMMER. THE FINAL TIME I USED THE SEAT HEATERS (1/26/12) THE SMELL GOT SO BAD THAT I HAD TO OPEN THE SUN ROOF FOR AIR. I ALSO NOTICED THE SEATS GOT HOTTER THAN USUAL AND WONDERED IF MY SEAT BACK WAS HEATING AT ALL. AS WAS USUAL WHEN THE SEAT WAS HOT ENOUGH I WOULD MANUALLY TURN OFF THE SEAT HEATER. I DID NOT KNOW WHAT WAS HAPPENING UNTIL ONE DAY WHEN I NOTICED BROWN MARKS ON THE RIGHT SIDE OF MY PANTS. I THEN LOOKED AT THE SEAT AND SAW THE DAMAGE TO THE SEAT. THE DRIVER'S SEAT ELEMENT WAS REPLACED IN MAY 2006, THE PASSENGER SEAT AUGUST 2006, DUE TO PREVIOUS RECALL/WARRANTY SERVICE.

NHTSA ODI #10446433

122,000 miles · Jan 24, 2012

Electrical SystemFireInjury

Read full complaint

HOLA MI HIJA TUVO UNA EXPERIENCIE TERRIBLE CON SU AUTO.ELLA SE DIRIGIA A LA UNIVERSIDAD EN SU AUTO Y DE MOMENTO COMENZO A SALIR HUMO PR EL AREA DONDE ESTA EL GUIA Y EL CONTA MILLA MAS O MENOS POR LO POCO QUE NO PUDO EXPLICAR POR LO AFECTADA QUE ESTABA.INMEDIATAMENTE ELLA SE DETUVO Y SE BAJO DE VEHICULO PARA LLAMAR A SU PAPA Y JUCTO EN ESE MOMENTO SE INCENDIO Y ESTAMOS SEGUROS QUE FUE UN PROBLEMA DE FABRICA PARA QUE SE INCENDIARA DE ESA MANERA.GRACIAS A DIOS QUE MI HIJA ESTABA FUERA DEL VEHICULO PORQUE POR LO QUE RAPIDO SUCEDIO NO LE HUBIERA DADO DE SALIR Y LA HISTORIA HUBIERA SIDO OTRA.HAGO ESTE REPORTE PARA QUE NO VUELVA A SUCEDER ALGO ASI.PORQUE MI HIJA ESTA SUMAMENTE AFECTADA. MUCHAS GRACIAS POR SU ATENCION. *TR

NHTSA ODI #10445143

60,000 miles · Nov 25, 2011

Electrical SystemSeatsInjury

MY DRIVERS SIDE SEAT HEATER DOESN'T RECOGNIZE THE SETTING OF 0-5. IT'S EITHER ON, OR OFF. MEANING, 0-4 THE SEAT HEATER DOESN'T HEAT THE SEAT. BUT WHEN I TURN IT TO 5 ON THE SETTING WITHIN 10 MINUTES THE SEAT GETS SO HOT IT BURNS MY LEGS THROUGH CLOTHING. *TR

NHTSA ODI #10437253

170,000 miles · Oct 12, 2011

Electrical SystemPower Train

Read full complaint

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA WAGON. THE CONTACT STATED THAT THE SPEEDOMETER FAILED TO PROVIDE AN ACCURATE SPEED TRAVELED. THE CONTACT ALSO STATED THAT WHEN THE CRUISE CONTROL SWITCH WAS ACTIVATED, IT WOULD CAUSE THE VEHICLE TO SURGE FORWARD ABNORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY CONFIRMED THAT THE SENSOR IN THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 170,000 AND THE CURRENT MILEAGE WAS 211,000. UPDATED 12/14/11 THE CONSUMER STATED THE TRANSMISSION WAS EXHIBITING AN INTERMITTENT HESITATION. UPDATED 12/20/11. *JB

NHTSA ODI #10429612

Official recalls

18V406000 · Air Bags:frontal:driver Side:inflator Module

Jun 13, 2018

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X3.

07V063000 · Exterior Lighting:brake Lights:switch

Feb 20, 2007

ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.

Consequence & remedy

Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP05004 · Engine Stalling

Opened Aug 11, 2005 · Closed Dec 8, 2005

Status: closed (inferred from source dates) · Electrical System:ignition:module

BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

PE04081 · Inadvertent SIDE-AIRBAG Deployment

Opened Dec 16, 2004 · Closed Apr 1, 2005

Status: closed (inferred from source dates) · Air Bags:side/window

THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

EA04010 · Driver Side Front Seat Overheats

Opened Mar 30, 2004 · Closed Oct 21, 2004

Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler

THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.

PE03052 · Driver Seat Overheats/burns

Opened Nov 19, 2003 · Closed Mar 30, 2004

Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler

THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.