IllustrationTHE MIDDLE REAR SEATBELT LOCKS UP AND WILL NOT RELEASE. THE SEATBELT LOCKING MECHANISM IS LOCATED IN THE SEAT IN AN INACCESSIBLE LOCATION AND IS ALSO NOT AVAILABLE TO RELEASE THE SEATBELT. *TR
1999 Volkswagen Jetta
Owner reports · Recalls · Investigations
More warning signs than most Jetta years
Owner complaints for the 1999 Volkswagen Jetta are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jetta years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
1325–50K
2650–75K
2175–100K
18100–150K
4150K+
88 reports with mileage · 261 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
33 crash reports9 fire reports21 injury reports
Seat Belts complaints
24 reports1999 VOLKSWAGEN JETTA, REAR MIDDLE PASSENGER SEAT BELT HAS BECOME TIGHTENED TO THE POINT THAT IT WON'T RELEASE. IT SEEMS THAT EACH TIME THE SEAT BACK WAS LOWERED TO INCREASE THE CARGO AREA OF THE TRUNK, THE BELT TIGHTENS MORE. *TR
IN MY 99.5 VW JETTA GLS THE MIDDLE REAR SEAT BELT HAS TIGHTENED AND WILL NOT RELEASE. I HAVE TAKEN IT TO A REPAIR SHOP AND HAVE HAD THEM WORK ON IT AND NORMALLY THEY CAN GET IT TO RELEASE. HOWEVER ONCE IT IS RELEASED, IT CAN'T BE USED B/C THE NEXT TIME I GO TO USE THE SEAT BELT AND PULL IT OUT IT LOCKS AGAIN. THE SEAT CAN'T BE U…
Read full complaint
IN MY 99.5 VW JETTA GLS THE MIDDLE REAR SEAT BELT HAS TIGHTENED AND WILL NOT RELEASE. I HAVE TAKEN IT TO A REPAIR SHOP AND HAVE HAD THEM WORK ON IT AND NORMALLY THEY CAN GET IT TO RELEASE. HOWEVER ONCE IT IS RELEASED, IT CAN'T BE USED B/C THE NEXT TIME I GO TO USE THE SEAT BELT AND PULL IT OUT IT LOCKS AGAIN. THE SEAT CAN'T BE USED. IT HAS ALSO MADE IT IMPOSSIBLE TO LAY DOWN THE BACK SEATS, OR ONCE I LAY IT FLAT THE SEAT CAN'T BE RETURNED TO THE UP RIGHT POSITION. *TR
THE REAR MIDDLE SHOULDER BELT OF MY 1999 JETTA IS CONSTANTLY BROKEN. EVERY TIME I FOLD THE MIDDLE SEAT DOWN IN THE BACK THE SEATBELT GETS TIGHTER AND TIGHTER AND TIGHTER. THIS HAPPENS UNTIL EVENTUALLY THE BELT IS TOO TIGHT FOR ME TO EVEN FOLD THE SEAT DOWN ANY LONGER AND I HAVE TO TAKE THE CAR IN TO BE WORKED ON. APPARENTLY IT I…
Read full complaint
THE REAR MIDDLE SHOULDER BELT OF MY 1999 JETTA IS CONSTANTLY BROKEN. EVERY TIME I FOLD THE MIDDLE SEAT DOWN IN THE BACK THE SEATBELT GETS TIGHTER AND TIGHTER AND TIGHTER. THIS HAPPENS UNTIL EVENTUALLY THE BELT IS TOO TIGHT FOR ME TO EVEN FOLD THE SEAT DOWN ANY LONGER AND I HAVE TO TAKE THE CAR IN TO BE WORKED ON. APPARENTLY IT IS SOME "BUTTON" THAT IS BREAKING. THIS HAPPENS EVERY TIME I TRY TO FOLD THE SEAT DOWN AND AS A RESULT I AM NOT ABLE TO SAFELY SECURE PASSENGERS IN MY MIDDLE SEAT. SO FAR I HAVE HAD THIS BUTTON REPLACED 3 TIMES. *JB
1) SEAT BELT!!! CENTER SEAT BELT IN BACK SEA DOES NOT WORK. VW REFUSED TO FIX EVEN THOUGH THIS IS A BIG SAFETY ISSUE! 2) MUSTY SMELL FROM A/C!! IT HAPPENS EVERY SUMMER. I TREAT IT WITH LYSOL BUT THAT ONLY LASTS A WEEK. HAS IT DONE PROFESSIONALLY, THAT ONLY LASTED ONE MONTH. 3) WINDOW REGULATORS NOT WORKING. DRIVER SIDDE WINDO…
Read full complaint
1) SEAT BELT!!! CENTER SEAT BELT IN BACK SEA DOES NOT WORK. VW REFUSED TO FIX EVEN THOUGH THIS IS A BIG SAFETY ISSUE! 2) MUSTY SMELL FROM A/C!! IT HAPPENS EVERY SUMMER. I TREAT IT WITH LYSOL BUT THAT ONLY LASTS A WEEK. HAS IT DONE PROFESSIONALLY, THAT ONLY LASTED ONE MONTH. 3) WINDOW REGULATORS NOT WORKING. DRIVER SIDDE WINDOW WILL ONLY GO ALL THE WAY UP OR ALL THE WAY DOWN. NOTHING IN BETWEEN. 4) GLOVE BOX LATCH BROKE. 5) RUBBERCOATING IS RUBBING OFF OF ALL HANDLES.*AK
I BOUGHT THE CAR IN AUGUST 2003, I NOTICED A REPAIR DOCKET FROM PREVIOUS OWNER FOR LEFT LOWER BALL JOINT AND LEFT TIE ROD ASSEMBLE W FRONT END ALIGNMENT ON 5/29/03 AT 34383 MILES. I HAD A LOT OF NOISE UNDER THE ENGINE. VW CAPISTRANO CHECKED IT OUT AND SAID IT WAS DRIVER SIDE BALL JOINT. I BOUGHT CAR FROM A FORD DEALER WHO DID …
Read full complaint
I BOUGHT THE CAR IN AUGUST 2003, I NOTICED A REPAIR DOCKET FROM PREVIOUS OWNER FOR LEFT LOWER BALL JOINT AND LEFT TIE ROD ASSEMBLE W FRONT END ALIGNMENT ON 5/29/03 AT 34383 MILES. I HAD A LOT OF NOISE UNDER THE ENGINE. VW CAPISTRANO CHECKED IT OUT AND SAID IT WAS DRIVER SIDE BALL JOINT. I BOUGHT CAR FROM A FORD DEALER WHO DID NOT WANT ANYTHING TO DO WITH IT. FINALLY, VW CAPISTRANO FORCED THEIR HAND AND PROCESSED IT THROUGH MY THEN CURRENT WARRANTY. AT THE TIME, I HAD 45K MILES ON THE CAR. I THOUGHT IT SHOCKING THAT A CAR SO YOUNG SHOULD HAVE SUCH A MAJOR PROBLEM (FOR THE SECOND TIME). WHEN I PICKED CAR UP, A COUPLE OF DAYS LATER, I HEARD A LOUD CRUNCHING NOISE IN THE FRONT LEFT HAND SIDE OF THE MOTOR OR WHEEL. I THOUGHT NOTHING OF IT, DROVE IT ANOTHER 5000 MILES, HAD TO REPLACE 4 TIRES, AND ASKED THE TIRE TECH TO CHECK IT OUT. HE SAID IT WAS THE STEERING KNUCKLE AND IT WAS IN BAD SHAPE. I CONTACTED VW WHO SAID, BAD LUCK, IT'S ONLY COVERED FOR 24K MILES OR 2YEARS. I AGAIN AM SHOCKED, FIRSTLY BECAUSE THAT'S IMPOSSIBLE ONE OF THESE SHOULD GO OUT SO EARLY, ADDED TO THAT, IF THE BALL JOINT WAS REPLACED, THEN ISN'T THE STEERING KNUCKLE, MOVED IN SOME WAY SHAPE OR FORM, SO THERE SHOULD BE SOME SORT OF RECOURSE. THIS CAR IS A LEMON, HOWEVER, CA LAW STATES IT ISN'T. I WAS RIPPED OFF BY THEODORE ROBBINS IN COSTA MESA AND WOULDN'T RECOMMEND ANYONE BUY FROM THEM, THEY WERE SUSPECT FROM DAY ONE ONCE I DROVE MY CAR FROM THEIR LOT. ALSO, THE BACK RIGHT SEAT BELT IS FIXED TO THE SEAT AND IS UNUSABLE, I COMPLAINED IT WAS DANGEROUS, FORD SAID TOO BAD, YOU BOUGHT IT THAT WAY FIX IT. SINCE THEN MY HORN HAS GONE OUT BECAUSE THE CAR 'LOST' IT'S UNDER WHEEL COVER AND WATER GOT INTO THE HORN. THIS CAR REPORTEDLY HAD A 100 POINT INSPECTION, WHICH I BELIEVE TO BE NOT TRUE. THE RADIO HAS NEVER WORKED A DAY, IT'S ALWAYS 'FUZZY'. *AK
THE CENTER REAR SEATBELT LOCKED UP AND WILL NOT RELEASE, WAS TOLD BY DEALER AND VW CUSTOMER SERVICE THAT THIS IS EXTREMELY COMMON, I WAS ADVISED I CAN EITHER PAY THE $200 + TO GET IT REPAIRED OR ELSE CUT IT AND NOT USE IT. *AK
REAR PASSENGER'S SEAT BELT BROKE. AFTER PUTTING THE SEAT IN THE RECLINING POSITION A PIN BROKE WHICH CONTROLLED THE RELEASING OF THE SEAT BELT, SAID THE DEALER. *AK
I OWN A 1999 1/2 VOLKSWAGEN JETTA. THE SEAT BELT MECHANISM ON THE DRIVER SIDE SEAT BROKE AND HAD TO BE REPLACED AT A SUBSTANTIAL COST OF MY OWN. THE PIECE THAT BROKE WAS THE BUCKLE WHERE THE BELT GETS INSERTED INTO. I WAS CURIOUS TO KNOW IF SEATBELTS HAVE LIFETIME WARRANTY WITH CARS. IF NOT, DOES THE VOLKSWAGEN JETTA HAVE A …
Read full complaint
I OWN A 1999 1/2 VOLKSWAGEN JETTA. THE SEAT BELT MECHANISM ON THE DRIVER SIDE SEAT BROKE AND HAD TO BE REPLACED AT A SUBSTANTIAL COST OF MY OWN. THE PIECE THAT BROKE WAS THE BUCKLE WHERE THE BELT GETS INSERTED INTO. I WAS CURIOUS TO KNOW IF SEATBELTS HAVE LIFETIME WARRANTY WITH CARS. IF NOT, DOES THE VOLKSWAGEN JETTA HAVE A HISTORY OF SEAT BELT FAILURES? THANK YOU, [XXX]. *AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
BRAKE LIGHT SWITCH REPLACED BECAUSE CEL ILLUMINATED INDICATING A FAILURE OF SAME. AFTER SOME TESTING, IT BECAME APPARENT THAT THE BRAKE LIGHTS WERE NOT ILLUMINATING APPROXIMATELY 9 OUT OF 10 TIMES THAT THE BRAKES WERE APPLIED. AT APPROXIMATELY THE SAME TIME, THE RIGHT TURN SIGNAL BEGAN ARCING. REPLACED THE RIGHT FRONT SIGNA…
Read full complaint
BRAKE LIGHT SWITCH REPLACED BECAUSE CEL ILLUMINATED INDICATING A FAILURE OF SAME. AFTER SOME TESTING, IT BECAME APPARENT THAT THE BRAKE LIGHTS WERE NOT ILLUMINATING APPROXIMATELY 9 OUT OF 10 TIMES THAT THE BRAKES WERE APPLIED. AT APPROXIMATELY THE SAME TIME, THE RIGHT TURN SIGNAL BEGAN ARCING. REPLACED THE RIGHT FRONT SIGNAL BULB DUE TO CARBON BUILDUP ON THE BULB. ALSO REPLACED THE TURN SIGNAL RELAY. RIGHT OUTER CV BOOT WAS FOUND TO BE LEAKING GREASE ON 5/22/2002 AND AGAIN ON 4/29/2003; IN BOTH CASES IT WAS REPLACED. BATTERY DIED ON 3/10/2003. ON 7/9/2002, THE CENTER REAR SEAT BELT BECAME STUCK IN ITS RETRACTOR AND WOULD NOT RELEASE. SEAT BELT ASSEMBLY WAS REPLACED. ON 10/1/2001, THE DRIVER'S FRONT WINDOW REGULATOR WAS REPLACED AFTER THE WINDOW FELL INTO THE DOOR WITHOUT WARNING. *JB
Official recalls
606V183000 · Exterior Lighting:brake Lights:switch
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
04V096000 · Exterior Lighting:brake Lights:switch
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
03V156000 · Equipment:other:labels
Apr 23, 2003
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.8L VR6 ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE RECOMMENDED COLD TIRE INFLATION PRESSURE PUBLISHED ON THE LABEL FOR TIRES OF THE SIZE 205/50 R15 86H IS 0.1 BAR (1.45 PSI) TOO LOW. IT SHOULD BE 2.5 BAR (36.3 PSI). THE LABEL RECOMMENDS 2.4 BAR (34.8 PSI = 35 PSI).
Consequence & remedy
Consequence: UNDER INFLATED TIRES CAN AFFECT VEHICLE HANDLING, AND DRIVING WITH SUBSTANTIALY UNDER INFLATED TIRES PUTS THE CONSUMER AT A RISK FOR A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS, OR A DEALER CAN INSTALL THE LABEL IF THE OWNER WISHES. OWNER NOTIFICATION BEGAN SEPTEMBER 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VW AT 1-800-893-5298.
02V026000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Jan 25, 2002
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
99V251000 · Structure:frame And Members
Sep 17, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES DO NOT COMPLY WITH THE HEAD INJURY CRITERION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE UPPER RETAINER CLIP NEAR THE BP1 IMPACT LOCATION IS DESIGNED TO BREAK WHEN IMPACTED BY THE HEAD FORM. IN SOME CASES, THE MATERIAL OF THE TRIM PART MAY BE MORE IMPACT RESISTANT AS A RESULT OF VARIATIONS IN THE MOLDING PROCESS.
Consequence & remedy
Consequence: THIS CONDITION COULD PREVENT THE CLIP FROM BREAKING ON IMPACT AND RESULT IN LESS DEFORMATION IN THE IMPACTED AREA AND A HIGHER DECLERATION OF THE HEAD FORM, INCREASING THE RISK OF PERSONAL INJURY IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REMOVE THE TRIM COVER FROM EACH OF THE B PILLARS AND INSTALL A NEW COVER.
99V022000 · Structure:frame And Members
Feb 5, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SOUND ABSORBING MAT ATTACHED TO THE INSIDE OF THE B-PILLAR SIDE TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED. SURFACE AND EDGES OF THE MAT COULD HAVE BEEN DAMAGED DURING THE ASSEMBLY PROCESS. IT COULD IGNITE WHEN EXPOSED TO THE EXHAUST GAS OF THE SEAT BELT PRE-TENSIONER IGNITER IN THE EVENT OF A SEVERE FRONT OR SIDE COLLISION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE MATTING MATERIALS FROM INSIDE THE B-PILLAR ON BOTH SIDES OF THE VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
PE99007 · Passenger Compartment Fire
Opened Jan 29, 1999 · Closed Feb 8, 1999
Status: closed (inferred from source dates) · Unknown Or Other
IN ITS LETTER DATED FEBRUARY 4, 1999, VOLKSWAGEN STATED THAT IT WILL RECALL APPROXIMATELY 23,600 REDESIGNED 1999 JETTA AND GOLF 4-DOOR VEHICLES, OF WHICH APPROXIMATELY 11,000 HAVE BEEN SOLD TO CUSTOMERS, TO CORRECT A DEFECT THATMAY CAUSE A FIRE IN THE PASSENGEER COMPARTMENT AFTER A VEHICLE COLLISION.A SOUND INSULATION MATERIAL ATTACHED TO THE INSIDE OF THE B-PILLAR TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED.IN THE EVENT OF A COLLISION SEVERE ENOUGH TO ACTIVATE THE SEAT BELT PRETENSIONER, THE HOT EXHAUST GAS FROM THE PRETENSIONER COULD IGNITE THE INSULATION MATERIAL IF IT IS TOO CLOSE TO THE PRETENSIONER.VOLKSWAGEN DEALERS WILL REMOVE THE INSULATION MATERIAL FROM THE B-PILLARS.