Visibility. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

33 crash reports9 fire reports21 injury reports

Exterior Lighting complaints

17 reports

Clear category filter

Mileage unknown · Jun 8, 2004

Air BagsExterior Lighting

CONSUMER RECEIVED NHTSA RECALL 04V096000 CONCERNING BRAKE LIGHT SWITCH. AFTER HAVING THE REPAIRS DONE VEHICLE STALLED, AND THE AIR BAG LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON.*AK

NHTSA ODI #10075926

Mileage unknown · Mar 12, 2004

Electrical SystemExterior LightingVisibility

Read full complaint

WHILE DRIVING TO WORK, MY HEADLIGHTS, DASHLIGHTS, HEATER/DEFROST, ALL WENT OUT AND MY E-BRAKE LIGHT CAME ON. DO TO THE CONDITIONS AND THE COLD, MY WINDSHIELD FOGGED UP EXTEMEMLY QUICKLY AND MADE IT DIFFICULT TO DRIVE. THIS HAS HAPPENED MANY TIMES SINCE, ALMOST ON A DAILY BASIS. I FIGURED OUT LATER ON, THAT BY MOVING THE IGNITION SWITCH AROUND, EVERYTHING WENT BACK TO NORMAL. I HAVE NOT CONTACTED THE DEALER ABOUT THIS DUE TO MY MILITARY SCHEDULE. I AM DEPLPYED RIGHT NOW AND AM PLANNING TO CONTACT THE DEALER IN FARGO AS SOON AS I RETURN.*AK

NHTSA ODI #10062053

Mileage unknown · Jun 27, 2003

Electrical SystemExterior LightingPower Train

Read full complaint

BRAKE LIGHT SWITCH REPLACED BECAUSE CEL ILLUMINATED INDICATING A FAILURE OF SAME. AFTER SOME TESTING, IT BECAME APPARENT THAT THE BRAKE LIGHTS WERE NOT ILLUMINATING APPROXIMATELY 9 OUT OF 10 TIMES THAT THE BRAKES WERE APPLIED. AT APPROXIMATELY THE SAME TIME, THE RIGHT TURN SIGNAL BEGAN ARCING. REPLACED THE RIGHT FRONT SIGNAL BULB DUE TO CARBON BUILDUP ON THE BULB. ALSO REPLACED THE TURN SIGNAL RELAY. RIGHT OUTER CV BOOT WAS FOUND TO BE LEAKING GREASE ON 5/22/2002 AND AGAIN ON 4/29/2003; IN BOTH CASES IT WAS REPLACED. BATTERY DIED ON 3/10/2003. ON 7/9/2002, THE CENTER REAR SEAT BELT BECAME STUCK IN ITS RETRACTOR AND WOULD NOT RELEASE. SEAT BELT ASSEMBLY WAS REPLACED. ON 10/1/2001, THE DRIVER'S FRONT WINDOW REGULATOR WAS REPLACED AFTER THE WINDOW FELL INTO THE DOOR WITHOUT WARNING. *JB

NHTSA ODI #10023910

Mileage unknown · Feb 27, 2002

Exterior Lighting

BRIGHT LIGHTS STAY ON. CONSUMER CANNOT ADJUST THEM. DEALER CONTACTED. *AK

NHTSA ODI #8004640

Mileage unknown · Feb 27, 2002

Exterior Lighting

TURN SIGNAL HANDLE BROKE , CAN'T USE TURN SIGNAL. DEALER CONTACTED. *AK

NHTSA ODI #8004637

Mileage unknown · Nov 15, 2000

Electrical SystemEngine And Engine CoolingExterior Lighting

Read full complaint

OIL LIGHT CAME ON 2000 MILES AFTER OILCHANGE/BURNING OR LEAKING EXCESSIVE OIL,AND OIL LEVEL LOW. PASSENGER'S WINDOW MOTOR STOPPED WORKING, RESULTING IN WINDOW FALLING DOWN,. ALSO, ENGINE REVVED HIGH/ LIGHT SWITCH ON INTERIOR LIGHT FELL OFF/ FRONT RIGHT MICHELIN TIRE BLEWOUT, AND HAD TO REPLACE BATTERY. DEALER KEPT REPAIRING PROBLEMS. CONSUMER CONTACTED VW CO, AND WAS TOLD THEY WOULD GET BACK TO HER, BUT NEVER DID. CONSUMER FELT VEHICLE WAS A LEMON. PLEASE ADD ADDITIONAL INFORMATION. *AK

NHTSA ODI #875011

Mileage unknown · Dec 17, 1999

Exterior Lighting

HEADLIGHTS ARE AIMED INCORRECTLY. THIS CAUSES POOR VISIBILITY FOR NIGHT TIME OPERATION. DRIVER CANNOT SEE FAR ENOUGH AHEAD TO DRIVE PROPERLY. FIRST IT WAS ONLY ONE LIGHT, NOW SINCE DEALER HAS REPAIRED, PROBLEM OCCURRED WITH OTHER HEADLIGHT. *AK

NHTSA ODI #854111

Official recalls

06V183000 · Exterior Lighting:brake Lights:switch

May 24, 2006

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.

Consequence & remedy

Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.

04V096000 · Exterior Lighting:brake Lights:switch

Feb 20, 2004

ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.

Consequence & remedy

Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.

Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.

03V156000 · Equipment:other:labels

Apr 23, 2003

CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.8L VR6 ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE RECOMMENDED COLD TIRE INFLATION PRESSURE PUBLISHED ON THE LABEL FOR TIRES OF THE SIZE 205/50 R15 86H IS 0.1 BAR (1.45 PSI) TOO LOW. IT SHOULD BE 2.5 BAR (36.3 PSI). THE LABEL RECOMMENDS 2.4 BAR (34.8 PSI = 35 PSI).

Consequence & remedy

Consequence: UNDER INFLATED TIRES CAN AFFECT VEHICLE HANDLING, AND DRIVING WITH SUBSTANTIALY UNDER INFLATED TIRES PUTS THE CONSUMER AT A RISK FOR A CRASH.

Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS, OR A DEALER CAN INSTALL THE LABEL IF THE OWNER WISHES. OWNER NOTIFICATION BEGAN SEPTEMBER 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VW AT 1-800-893-5298.

02V026000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

Jan 25, 2002

ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.

Consequence & remedy

Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.

Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.

99V251000 · Structure:frame And Members

Sep 17, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES DO NOT COMPLY WITH THE HEAD INJURY CRITERION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE UPPER RETAINER CLIP NEAR THE BP1 IMPACT LOCATION IS DESIGNED TO BREAK WHEN IMPACTED BY THE HEAD FORM. IN SOME CASES, THE MATERIAL OF THE TRIM PART MAY BE MORE IMPACT RESISTANT AS A RESULT OF VARIATIONS IN THE MOLDING PROCESS.

Consequence & remedy

Consequence: THIS CONDITION COULD PREVENT THE CLIP FROM BREAKING ON IMPACT AND RESULT IN LESS DEFORMATION IN THE IMPACTED AREA AND A HIGHER DECLERATION OF THE HEAD FORM, INCREASING THE RISK OF PERSONAL INJURY IN THE EVENT OF A CRASH.

Remedy: DEALERS WILL REMOVE THE TRIM COVER FROM EACH OF THE B PILLARS AND INSTALL A NEW COVER.

99V022000 · Structure:frame And Members

Feb 5, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SOUND ABSORBING MAT ATTACHED TO THE INSIDE OF THE B-PILLAR SIDE TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED. SURFACE AND EDGES OF THE MAT COULD HAVE BEEN DAMAGED DURING THE ASSEMBLY PROCESS. IT COULD IGNITE WHEN EXPOSED TO THE EXHAUST GAS OF THE SEAT BELT PRE-TENSIONER IGNITER IN THE EVENT OF A SEVERE FRONT OR SIDE COLLISION.

Consequence & remedy

Consequence: THIS COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REMOVE THE MATTING MATERIALS FROM INSIDE THE B-PILLAR ON BOTH SIDES OF THE VEHICLE.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ06004 · Brake Light Switch Failure

Opened Feb 28, 2006 · Closed Aug 7, 2006

Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch

BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.

Additional source detail variants (2)

Exterior Lighting:brake Lights:switch

Exterior Lighting:brake Lights

RQ03010 · Brake Light Switch

Opened Dec 17, 2003 · Closed Mar 1, 2004

Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch

THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.

EA00028 · Fuel Tank Puncture

Opened Dec 28, 2000 · Closed Jan 29, 2002

Status: closed (inferred from source dates) · Vehicle Speed Control:linkages

No summary supplied.

PE00033 · Fuel Tank Puncture

Opened Aug 10, 2000 · Closed Dec 28, 2000

Status: closed (inferred from source dates) · Vehicle Speed Control:linkages

THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.

PE99007 · Passenger Compartment Fire

Opened Jan 29, 1999 · Closed Feb 8, 1999

Status: closed (inferred from source dates) · Unknown Or Other

IN ITS LETTER DATED FEBRUARY 4, 1999, VOLKSWAGEN STATED THAT IT WILL RECALL APPROXIMATELY 23,600 REDESIGNED 1999 JETTA AND GOLF 4-DOOR VEHICLES, OF WHICH APPROXIMATELY 11,000 HAVE BEEN SOLD TO CUSTOMERS, TO CORRECT A DEFECT THATMAY CAUSE A FIRE IN THE PASSENGEER COMPARTMENT AFTER A VEHICLE COLLISION.A SOUND INSULATION MATERIAL ATTACHED TO THE INSIDE OF THE B-PILLAR TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED.IN THE EVENT OF A COLLISION SEVERE ENOUGH TO ACTIVATE THE SEAT BELT PRETENSIONER, THE HOT EXHAUST GAS FROM THE PRETENSIONER COULD IGNITE THE INSULATION MATERIAL IF IT IS TOO CLOSE TO THE PRETENSIONER.VOLKSWAGEN DEALERS WILL REMOVE THE INSULATION MATERIAL FROM THE B-PILLARS.