1. AIR BAG: THE AIR BAG INDICATOR LIGHT IS ILLUMINATING. 2. SUNROOF DRAIN SYSTEM CLOGGED: THERE IS LEAKAGE THROUGH THE SUNROOF OF THE PASSENGER SIDE. ALL RAIN WATER IS COMING IN FROM THE PASSENGER DOOR. AFTER ABOUT 2 WEEKS OF THUNDER STORMS THE CAR HAS WATER ALL OVER THE INSIDE AND THE CEILING AND SMELLS BAD. (AS SOON AS I FOU…
Read full complaint
1. AIR BAG: THE AIR BAG INDICATOR LIGHT IS ILLUMINATING. 2. SUNROOF DRAIN SYSTEM CLOGGED: THERE IS LEAKAGE THROUGH THE SUNROOF OF THE PASSENGER SIDE. ALL RAIN WATER IS COMING IN FROM THE PASSENGER DOOR. AFTER ABOUT 2 WEEKS OF THUNDER STORMS THE CAR HAS WATER ALL OVER THE INSIDE AND THE CEILING AND SMELLS BAD. (AS SOON AS I FOUND OUT THE SUNROOF LEAKAGE PROBLEM OF THIS CAR, I FOUND THAT HE U.S. COURT OF APPEALS FOR THE THIRD CIRCUIT HAS APPROVED A $69 MILLION SETTLEMENT STEMMING FROM A CLASS-ACTION LAWSUIT THAT STARTED IN 2007 OVER LEAKING SUNROOFS. HTTP://WWW.CARCOMPLAINTS.COM/NEWS/2014/VOLKSWAGEN-SETTLES-LAWSUIT-LEAKING-SUNROOFS.SHTML)
NHTSA ODI #10876204
105,000 miles · Aug 13, 2012
Visibility/wiper
BOTH REAR WINDOW CONTROL MECHANISMS HAVE GONE BAD. I HAVE DONE A SEARCH AND THIS SEEMS TO BE A RE-OCCURRING PROBLEM WITH THIS VEHICLE. VERY EXPENSIVE TO REPLACE. *TR
NHTSA ODI #10470410
44,000 miles · Jun 28, 2012
Visibility/wiper
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN NEW BEETLE CONVERTIBLE. THE CONTACT STATED THAT BOTH THE PASSENGER AND DRIVER SIDE WINDOWS WERE INOPERABLE AND REMAINED OPEN. THE CONTACT WAS UNABLE TO CLOSE THE WINDOWS. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE WINDOW REGULATOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REP…
Read full complaint
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN NEW BEETLE CONVERTIBLE. THE CONTACT STATED THAT BOTH THE PASSENGER AND DRIVER SIDE WINDOWS WERE INOPERABLE AND REMAINED OPEN. THE CONTACT WAS UNABLE TO CLOSE THE WINDOWS. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE WINDOW REGULATOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 44,000 AND THE CURRENT MILEAGE WAS 50,000.
VOLKSWAGEN IS RECALLING 76,900 MY 2004-2005 NEW BEETLE AND MY 2003-2005 NEW BEETLE CONVERTIBLES EQUIPPED WITH AN ADVANCED (DUAL-STAGE) AIR BAG SYSTEM. THIS SYSTEM MAY HAVE AIR BAG FRONTAL CRASH SENSORS THAT CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS. IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE FALLBACK ALGORITHM WILL ENSURE THAT THE FRONT AIR BAGS ALWAYS DEPLOY IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.
Consequence & remedy
Consequence: IN LOW-SEVERITY FRONTAL IMPACTS, THE FRONT AIR BAGS MAY DEPLOY MORE FORCEFULLY THAN DESIGNED, INCREASING THE POSSIBILITY OF INJURY TO OUT-OF-POSITION FRONT SEAT OCCUPANTS.
Remedy: DEALERS WILL INSPECT EACH VEHICLE TO DETERMINE THAT THE SPECIFIC DEFECT CRASH SENSOR IS PRESENT ON ONE OR BOTH SIDES OF THE VEHICLE. ALL OF THE DEFECT CRASH SENSORS WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 31, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
Remedy: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08012 · Front Air Bag Crash Sensor Failure
Opened Feb 15, 2008 · Closed Apr 24, 2008
Status: closed (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CERTAIN SUBJECT VEHICLES, MODEL YEAR (MY) 2003 CONVERTIBLE AND MY 2004 SEDAN AND CONVERTIBLE VEHICLES ARE EQUIPPED WITH AN ADVANCED DUAL-STAGE AIR BAG SYSTEM.THE AIR BAG CRASH SENSORS (#1F0 909 606) CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS.IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE CONTROL MODULE WILL ENABLE A FALLBACK ALGORITHM THAT WILL ENSURE THAT THE FRONT AIR BAG ALWAYS DEPLOYS IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.HOWEVER, IN LOW-SEVERITY FRONTAL IMPACTS, THE FRONT AIR BAGS MAY DEPLOY MORE FORCEFULLY THAN DESIGNED, INCREASING THE POSSIBILITY OF INJURY TO OUT-OF-POSITION FRONT SEAT OCCUPANTS.VOLKSWAGEN WILL INSPECT FOR THE DEFECTIVE CRASH SENSOR AND REPLACE WITH AN UPDATED DESIGN.IN ADDITION, 16,177 EARLY-MY 2005 NEW BEETLE SEDAN AND CONVERTIBLE VEHICLES (BUILT THROUGH OCT 31, 2004) ARE ALSO INCLUDED IN THE RECALL CAMPAIGN.THIS PRELIMINARY EVALUATION IS CLOSED (SEE RECALL 08V-178)
2004 Volkswagen Beetle Problems, Complaints & Recalls | Skip That Year
Illustration