IllustrationMileage unknown · Oct 1, 2024
Electrical SystemEngineUnknown Or Other
Unknown
NHTSA ODI #11617386
2002 Volkswagen Beetle
Owner reports · Recalls · Investigations
More warning signs than most Beetle years
Owner complaints for the 2002 Volkswagen Beetle are substantially higher than the model-year median of 49.
About this comparison →How this year compares
Owner complaints by model year
Compare all Beetle years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
170–25K
2325–50K
3850–75K
1675–100K
15100–150K
5150K+
114 reports with mileage · 51 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports4 fire reports11 injury reports
What owners actually said
165 reportsUnknown
I was driving down the road an the car started accelerating all by it's self so I pulled over but every time I let off the break it acted like I had the gas to the floor. The O2 sensor wire's shorted and burnt up the ECM making the CPU light to come on.
I WAS DRIVING ON THE HIGHWAY WITH MY DAUGHTER AND GIRLFRIEND WHEN SUDDENLY THE CAR CAUGHT AN ELECTRICAL FIRE OUT OF NOWHERE. I PULLED OVER AND CLOUDY SMOKE WAS ARISING LUCKILY THE STATE TROOPER HAD A FIRE EXTINGUISHER TO PUT IT OUT BEFORE THE CAR CAUGHT ON HEAVY FLAMES.
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN BEETLE. WHILE DRIVING 60 MPH, THE ABS MAIN CONTROL UNIT INDICATOR ILLUMINATED. AN INDEPENDENT MECHANIC STATED THAT THE ABS WAS MALFUNCTIONING. THE CONTACT TOOK THE VEHICLE TO THE DEALER (VOLKSWAGEN OF OAKLAND, 2740 BROADWAY, OAKLAND, CA 94610) WHO STATED THAT THERE WERE NO ACTIVE RECALLS. T…
Read full complaint
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN BEETLE. WHILE DRIVING 60 MPH, THE ABS MAIN CONTROL UNIT INDICATOR ILLUMINATED. AN INDEPENDENT MECHANIC STATED THAT THE ABS WAS MALFUNCTIONING. THE CONTACT TOOK THE VEHICLE TO THE DEALER (VOLKSWAGEN OF OAKLAND, 2740 BROADWAY, OAKLAND, CA 94610) WHO STATED THAT THERE WERE NO ACTIVE RECALLS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 89,605. *TT
VEHICLE WAS IN MOTION (ABOUT 25 MPH) WHEN A FRONT END COLLISION OCCURRED WHICH RESULTED IN THE PASSENGER SIDE AIRBAG ACTIVATING ONLY. THE DRIVER SIDE STEERING WHEEL AIRBAG DID NOT ACTIVATE. DRIVER'S FACE HIT THE STEERING WHEEL.
ABS TRACTION CONTROL SYSTEM MALFUNCTIONING, TOLD BY DEALER AND MECHANIC THAT THE CONTROL MODULE IS DEFECTIVE. THE ABS KICKS IN EVEN WHEN NOT BRAKING AND NO LIGHT ON. CAR ABRUPTLY SWERVES AS BRAKES ENGAGE ONE WHEEL ONLY. THE DEALER SAID THERE IS NO RECALL FOR MY VIN NUMBER BUT THE PART IS THE SAME NUMBER AS THE ONE FOR OTHER LIST…
Read full complaint
ABS TRACTION CONTROL SYSTEM MALFUNCTIONING, TOLD BY DEALER AND MECHANIC THAT THE CONTROL MODULE IS DEFECTIVE. THE ABS KICKS IN EVEN WHEN NOT BRAKING AND NO LIGHT ON. CAR ABRUPTLY SWERVES AS BRAKES ENGAGE ONE WHEEL ONLY. THE DEALER SAID THERE IS NO RECALL FOR MY VIN NUMBER BUT THE PART IS THE SAME NUMBER AS THE ONE FOR OTHER LISTED RECALLS. I CALLED VW AMERICA AND THEY ARE UNWILLING TO TAKE RESPONSIBILITY. THE COST TO REPLACE AND REPROGRAM THE NEW MODULE IS $2,000
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE.
THE CAR WAS DRIVEN IN THE MORNING THEN PARKED AT MY HOME. WHEN I WENT TO USE IT AGAIN IT WILL NOT COME OUT OF PARK. THE LIGHT WILL NOT GO OUT SO THAT I CAN PULL THE GEAR SHIFT OUT OF PARK.
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN BEETLE CONVERTIBLE. WHILE DRIVING APPROXIMATELY 40 MPH IN THE RAIN, WATER SUDDENLY LEAKED INTO THE CABIN OF THE VEHICLE AND ONTO THE DRIVER. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 29…
Read full complaint
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN BEETLE CONVERTIBLE. WHILE DRIVING APPROXIMATELY 40 MPH IN THE RAIN, WATER SUDDENLY LEAKED INTO THE CABIN OF THE VEHICLE AND ONTO THE DRIVER. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 29,000.
WE PURCHASE OUR 2002 VW BEATLE FROM A PRIVATE 6 YEARS AGO. WE HAVE REPLACED THE FUSE BOX ABOVE THE BATTERY ON 3 PREVIOUS OCCASIONS AS THE BOX SHORTS OUT AND MELTS CAUSING THE CAR TO TURN OFF AND NOT RESTART. THE FIRST TWO TIMES WE HAD REPAIR FACILITIES FIX THE PROBLEM TO THE TUNE OF $500 PLUS EACH TIME. THE 3RD TIME THIS HAPPEN…
Read full complaint
WE PURCHASE OUR 2002 VW BEATLE FROM A PRIVATE 6 YEARS AGO. WE HAVE REPLACED THE FUSE BOX ABOVE THE BATTERY ON 3 PREVIOUS OCCASIONS AS THE BOX SHORTS OUT AND MELTS CAUSING THE CAR TO TURN OFF AND NOT RESTART. THE FIRST TWO TIMES WE HAD REPAIR FACILITIES FIX THE PROBLEM TO THE TUNE OF $500 PLUS EACH TIME. THE 3RD TIME THIS HAPPENED I ORDERED THE PART ON LINE AND DID THE REPAIR MYSELF. WELL IT JUST BURNED OUT AGAIN THIS WEEK WHICH NOW MAKES 4 TIMES IN A 6 YEAR HISTORY THIS HAS OCCURRED. I TALKED WITH VW CONCERNING THIS AND THEY SAID THE CABLE WAS TOO SMALL WHEN VW FIRST MANUFACTURED THE CAR. SO THE 3RD TIME IT WENT OUT I REPLACED THE SO CALLED FAULTY CABLE AS WELL. WELL I GUESS THAT WASN'T THE PROBLEM AS I SAID IT NOW BURNED UP AGAIN AND THAT WAS REPLACING THE CABLE AND GOING TO A LARGER GAGE SIZE WIRE THAT VW SUGGESTED. NOT WHAT SHOULD I JUST EXPECT IT TO HAPPEN AGAIN. NEEDLESS TO SAY I HAVE SEEN THIS SAME COMPLAINT SEVERAL TIMES WHEN IS VW GOING TO STAND UP AND TAKE RESPONSIBILITY. I KNOW HAVE SPENT OVER $1500 FIXING THE SAME THING NOW FOR THE 4TH TIME. VERY DISAPPOINTING VW.
Official recalls
207V063000 · Exterior Lighting:brake Lights:switch
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
06V183000 · Exterior Lighting:brake Lights:switch
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA03002 · Brake Light Switch
Opened Apr 8, 2003 · Closed Aug 20, 2003
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Exterior Lighting:brake Lights
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.