Engine And Engine CoolingPower TrainService Brakes, Hydraulic
VEHICLE IS SEVEN YEARS OLD WITH 59,100 MILES AND ALREADY NEEDS A NEW TRANSMISSION DUE TO INCORRECT GEAR RATIO FAULT 17114, AND PO330. ALSO, NEEDS A CATALYTIC CONVERTER, HAS AIR LEAK FROM BRAKE BOOSTER VACUUM PIPE. VW CORPORATION ADVISED CONVERTER UNDER WARRANTY AND OFFERED $1,000 TOWARD A NEW OR USED VW. THE TRANSMISSION IS APPR…
Read full complaint
VEHICLE IS SEVEN YEARS OLD WITH 59,100 MILES AND ALREADY NEEDS A NEW TRANSMISSION DUE TO INCORRECT GEAR RATIO FAULT 17114, AND PO330. ALSO, NEEDS A CATALYTIC CONVERTER, HAS AIR LEAK FROM BRAKE BOOSTER VACUUM PIPE. VW CORPORATION ADVISED CONVERTER UNDER WARRANTY AND OFFERED $1,000 TOWARD A NEW OR USED VW. THE TRANSMISSION IS APPROXIMATELY $4,000. I DECLINED THEIR OFFER. I ALSO HAD TO REPLACE THREE WINDOW REGULATORS. ...UPDATED 01/30/12 *BF
NHTSA ODI #10445389
115,730 miles · Dec 27, 2011
Service Brakes, HydraulicCrash
THE VEHICLE HAD A CATASTROPHIC BRAKE LINE FAILURE ON THE STEEL BRAIDED LINE OFF THE MASTER CYLINDER FOR THE FRONT BRAKES DURING A PANIC STOP AT HIGHWAY SPEEDS. THE LINE HAS A RUBBER ANTI VIBRATION RING PLACED ON THE HOSE , THIS WAS SAID TO BE "OUT OF LOCATION" AND THE STEEL BRAIDED LINE WORE AGAINST THE "AIR BOX" IN THE AREA T…
Read full complaint
THE VEHICLE HAD A CATASTROPHIC BRAKE LINE FAILURE ON THE STEEL BRAIDED LINE OFF THE MASTER CYLINDER FOR THE FRONT BRAKES DURING A PANIC STOP AT HIGHWAY SPEEDS. THE LINE HAS A RUBBER ANTI VIBRATION RING PLACED ON THE HOSE , THIS WAS SAID TO BE "OUT OF LOCATION" AND THE STEEL BRAIDED LINE WORE AGAINST THE "AIR BOX" IN THE AREA THAT BURST. THE ANTI VIBRATION RING EITHER VIBRATED OUT OF LOCATION OR WAS POSSIBLY MOVED/MISS-INSTALLED. THE VEHICLE HAD PREVIOUS WORK DONE AT A CERTIFIED VW DEALERSHIP ON THE MASTER CYLINDER 2 YEARS PRIOR TO CORRECT A FAILED BREAK POWER ASSIST UNIT. THIS MAY HAVE BEEN A CONTRIBUTORY FACTOR BUT THE DEALERSHIP DECLINED RESPONSIBILITY FOR THE FAILURE. DURING THE ACCIDENT THE REAR BRAKES CONTINUED TO WORK CORRECTLY , THE VEHICLE SLOWED SUBSTANTIALLY AND THE ANTI-LOCK COULD BE "HEARD" TO ENGAGE, THE VEHICLE DID NOT SKID OR LOSE CONTROL BUT WAS NOT SLOWED ENOUGH TO KEEP FROM HITTING THE REAR OF THE CAR AHEAD OF ME. *TR
NHTSA ODI #10441402
Mileage unknown · Dec 14, 2004
Air BagsEngine And Engine CoolingService Brakes, HydraulicCrash
CONSUMER WAS INVOLVED IN AN ACCIDENT WHERE THE AIR BAGS FAILED TO DEPLOY. THE AIRBAG LIGHT WAS ON, AS WELL AS THE CHECK ENGINE AND ABS LIGHTS. CONSUMER WENT TO DEALERSHIP TO GET VEHICLE SERVICED, BUT DEALERSHIP COULD NOT DETERMINE THE CAUSE OF THE PROBLEM.*AK
VOLKSWAGEN IS RECALLING 76,900 MY 2004-2005 NEW BEETLE AND MY 2003-2005 NEW BEETLE CONVERTIBLES EQUIPPED WITH AN ADVANCED (DUAL-STAGE) AIR BAG SYSTEM. THIS SYSTEM MAY HAVE AIR BAG FRONTAL CRASH SENSORS THAT CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS. IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE FALLBACK ALGORITHM WILL ENSURE THAT THE FRONT AIR BAGS ALWAYS DEPLOY IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.
Consequence & remedy
Consequence: IN LOW-SEVERITY FRONTAL IMPACTS, THE FRONT AIR BAGS MAY DEPLOY MORE FORCEFULLY THAN DESIGNED, INCREASING THE POSSIBILITY OF INJURY TO OUT-OF-POSITION FRONT SEAT OCCUPANTS.
Remedy: DEALERS WILL INSPECT EACH VEHICLE TO DETERMINE THAT THE SPECIFIC DEFECT CRASH SENSOR IS PRESENT ON ONE OR BOTH SIDES OF THE VEHICLE. ALL OF THE DEFECT CRASH SENSORS WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 31, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
Remedy: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08012 · Front Air Bag Crash Sensor Failure
Opened Feb 15, 2008 · Closed Apr 24, 2008
Status: closed (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CERTAIN SUBJECT VEHICLES, MODEL YEAR (MY) 2003 CONVERTIBLE AND MY 2004 SEDAN AND CONVERTIBLE VEHICLES ARE EQUIPPED WITH AN ADVANCED DUAL-STAGE AIR BAG SYSTEM.THE AIR BAG CRASH SENSORS (#1F0 909 606) CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS.IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE CONTROL MODULE WILL ENABLE A FALLBACK ALGORITHM THAT WILL ENSURE THAT THE FRONT AIR BAG ALWAYS DEPLOYS IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.HOWEVER, IN LOW-SEVERITY FRONTAL IMPACTS, THE FRONT AIR BAGS MAY DEPLOY MORE FORCEFULLY THAN DESIGNED, INCREASING THE POSSIBILITY OF INJURY TO OUT-OF-POSITION FRONT SEAT OCCUPANTS.VOLKSWAGEN WILL INSPECT FOR THE DEFECTIVE CRASH SENSOR AND REPLACE WITH AN UPDATED DESIGN.IN ADDITION, 16,177 EARLY-MY 2005 NEW BEETLE SEDAN AND CONVERTIBLE VEHICLES (BUILT THROUGH OCT 31, 2004) ARE ALSO INCLUDED IN THE RECALL CAMPAIGN.THIS PRELIMINARY EVALUATION IS CLOSED (SEE RECALL 08V-178)
2004 Volkswagen Beetle Problems, Complaints & Recalls | Skip That Year
Illustration