TL*THE CONTACT OWNS A 2004 VOLKSWAGEN NEW BEETLE. WHEN THE CONTACT STARTED THE VEHICLE, HE NOTICED THAT THE AIR BAG INDICATOR WAS ILLUMINATING ON THE INSTRUMENT PANEL. THE INDICATOR DID NOT DIM ONCE THE VEHICLE WAS IN MOTION. THE VEHICLE WAS DRIVEN TO THE DEALER AND THEY STATED THAT THE DRIVER'S SIDE SEAT LATCH FOR THE SEAT B…
Read full complaint
TL*THE CONTACT OWNS A 2004 VOLKSWAGEN NEW BEETLE. WHEN THE CONTACT STARTED THE VEHICLE, HE NOTICED THAT THE AIR BAG INDICATOR WAS ILLUMINATING ON THE INSTRUMENT PANEL. THE INDICATOR DID NOT DIM ONCE THE VEHICLE WAS IN MOTION. THE VEHICLE WAS DRIVEN TO THE DEALER AND THEY STATED THAT THE DRIVER'S SIDE SEAT LATCH FOR THE SEAT BELT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT INSPECTED THE VEHICLE AND NOTICED A FAILED WIRE BY THE LATCH OF THE SEAT BELT ON THE DRIVER'S SIDE. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WERE NOT LIABLE FOR THE REPAIRS. THE CURRENT MILEAGE WAS 27,888 AND FAILURE MILEAGE WAS 27,858.
NHTSA ODI #10259349
33,000 miles · Feb 2, 2009
Air BagsSeat Belts
TL*THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. EVER SINCE THE VEHICLE WAS PURCHASED, IT HAS BEEN TAKEN TO THE DEALER SEVERAL TIMES FOR THE AIR BAG INDICATOR ILLUMINATING. THE DEALER REPLACED THE FRONTAL AIR BAG CRASH SENSOR AND REPROGRAMMED THE AIR BAG SYSTEM; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE DEALER STATED THAT IF T…
Read full complaint
TL*THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. EVER SINCE THE VEHICLE WAS PURCHASED, IT HAS BEEN TAKEN TO THE DEALER SEVERAL TIMES FOR THE AIR BAG INDICATOR ILLUMINATING. THE DEALER REPLACED THE FRONTAL AIR BAG CRASH SENSOR AND REPROGRAMMED THE AIR BAG SYSTEM; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE DEALER STATED THAT IF THE INDICATOR ILLUMINATED AGAIN, THE AIR BAG MODULE WILL NEED TO BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBERS 08V178000 (AIR BAGS: FRONTAL: SENSOR/CONTROL MODULE OR RECALL) AND 03V3560000 (AIR BAGS). THE FAILURE MILEAGE WAS 33,000 AND CURRENT MILEAGE WAS 36,000. UPDATED 06/23/09. *LJ A DIAGNOSTIC INDICATED FAILURE OF THE DRIER SEAT BUCKLE WHICH HAD TO BE REPLACED. UPDATED 06/24/09.*JB
NHTSA ODI #10257213
8,000 miles · Feb 24, 2008
Air BagsSeat Belts
THE AIRBAG LIGHT, AMONG OTHER THINGS, IN OUR 2004 NEW BEETLE HAS COME ON APPROXIMATELY 10 TIMES IN THREE YEARS. EACH TIME, THE VEHICLE WAS TAKEN BACK TO THE DEALER AND SUPPOSEDLY FIXED, BUT WITHOUT FAIL, THE LIGHT CAME BACK ON EACH TIME. THE SEATBELT BUCKLE WAS CHANGED, CONNECTIONS WERE SECURED, THEY SAID IT WAS SHORTED (GUIDE…
Read full complaint
THE AIRBAG LIGHT, AMONG OTHER THINGS, IN OUR 2004 NEW BEETLE HAS COME ON APPROXIMATELY 10 TIMES IN THREE YEARS. EACH TIME, THE VEHICLE WAS TAKEN BACK TO THE DEALER AND SUPPOSEDLY FIXED, BUT WITHOUT FAIL, THE LIGHT CAME BACK ON EACH TIME. THE SEATBELT BUCKLE WAS CHANGED, CONNECTIONS WERE SECURED, THEY SAID IT WAS SHORTED (GUIDED FAULT FINDINGS, BUMPER COVER REMOVED, SEAT REMOVED), AND OTHERS. I HAVE ALL COPIES OF SERVICE RECORDS. AFTER ALL THESE SERVICE VISITS, THE AIRBAG LIGHT IS STILL ON AND WE ARE VERY CONCERNED THAT THE AIRBAG SYSTEM IS NOT WORKING CORRECTLY AND COULD CAUSE SERIOUS DAMAGE AND MAY NOT DEPLOY CORRECTLY DURING AN ACCIDENT. I HEARD THERE WAS AN INVESTIGATION BEING CONDUCT ON THE 2004 NEW BEETLES AND WANTED TO LET YOU KNOW OF OUR EXPERIENCE. *TR CRASH SENSOR.PCO
NHTSA ODI #10219014
35,851 miles · Mar 26, 2007
Air BagsExterior LightingSeat Belts
TL*THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE PASSENGER'S SIDE AIR BAG INDICATOR CONSTANTLY ILLUMINATED. ALSO, THE SEAT BELT INDICATOR ILLUMINATED INTERMITTENTLY EVEN WHEN THE VEHICLE WAS UNOCCUPIED. IN ADDITION, THE DAYTIME RUNNING LAMPS WOULD SHUT OFF, BUT THE DEALER REPLACED THE BULBS. THE C…
Read full complaint
TL*THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE PASSENGER'S SIDE AIR BAG INDICATOR CONSTANTLY ILLUMINATED. ALSO, THE SEAT BELT INDICATOR ILLUMINATED INTERMITTENTLY EVEN WHEN THE VEHICLE WAS UNOCCUPIED. IN ADDITION, THE DAYTIME RUNNING LAMPS WOULD SHUT OFF, BUT THE DEALER REPLACED THE BULBS. THE CONTACT HAD AN APPOINTMENT TO HAVE THE AIR BAG INDICATOR DIAGNOSED. THE CURRENT AND FAILURE MILEAGE WERE 35851. *AK
VOLKSWAGEN IS RECALLING 76,900 MY 2004-2005 NEW BEETLE AND MY 2003-2005 NEW BEETLE CONVERTIBLES EQUIPPED WITH AN ADVANCED (DUAL-STAGE) AIR BAG SYSTEM. THIS SYSTEM MAY HAVE AIR BAG FRONTAL CRASH SENSORS THAT CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS. IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE FALLBACK ALGORITHM WILL ENSURE THAT THE FRONT AIR BAGS ALWAYS DEPLOY IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.
Consequence & remedy
Consequence: IN LOW-SEVERITY FRONTAL IMPACTS, THE FRONT AIR BAGS MAY DEPLOY MORE FORCEFULLY THAN DESIGNED, INCREASING THE POSSIBILITY OF INJURY TO OUT-OF-POSITION FRONT SEAT OCCUPANTS.
Remedy: DEALERS WILL INSPECT EACH VEHICLE TO DETERMINE THAT THE SPECIFIC DEFECT CRASH SENSOR IS PRESENT ON ONE OR BOTH SIDES OF THE VEHICLE. ALL OF THE DEFECT CRASH SENSORS WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 31, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
Remedy: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08012 · Front Air Bag Crash Sensor Failure
Opened Feb 15, 2008 · Closed Apr 24, 2008
Status: closed (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CERTAIN SUBJECT VEHICLES, MODEL YEAR (MY) 2003 CONVERTIBLE AND MY 2004 SEDAN AND CONVERTIBLE VEHICLES ARE EQUIPPED WITH AN ADVANCED DUAL-STAGE AIR BAG SYSTEM.THE AIR BAG CRASH SENSORS (#1F0 909 606) CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS.IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE CONTROL MODULE WILL ENABLE A FALLBACK ALGORITHM THAT WILL ENSURE THAT THE FRONT AIR BAG ALWAYS DEPLOYS IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.HOWEVER, IN LOW-SEVERITY FRONTAL IMPACTS, THE FRONT AIR BAGS MAY DEPLOY MORE FORCEFULLY THAN DESIGNED, INCREASING THE POSSIBILITY OF INJURY TO OUT-OF-POSITION FRONT SEAT OCCUPANTS.VOLKSWAGEN WILL INSPECT FOR THE DEFECTIVE CRASH SENSOR AND REPLACE WITH AN UPDATED DESIGN.IN ADDITION, 16,177 EARLY-MY 2005 NEW BEETLE SEDAN AND CONVERTIBLE VEHICLES (BUILT THROUGH OCT 31, 2004) ARE ALSO INCLUDED IN THE RECALL CAMPAIGN.THIS PRELIMINARY EVALUATION IS CLOSED (SEE RECALL 08V-178)
2004 Volkswagen Beetle Problems, Complaints & Recalls | Skip That Year
Illustration